Advertisement
OPERATING
INSTRUCTIONS
Boxed Pizza Holding Bin
Model No. DHB4PT-25
ELECTRICAL SPECIFICATION
Model
DHB4PT-25
DHB4PT-25J
DHB4PT-25CE
DHB4PT-25GB
Printed in 2001
Prince Castle Inc.
Volts
Hz
Watts Amps
120
60
1700
200
50/60 1700
220-240 50
1850
220-240 50
1850
355 East Kehoe Blvd.
Tel: (630) 462-8800
Toll Free: 1-800-PCASTLE
TABLE OF CONTENTS
Installation ..................................................................... 2
Operating ....................................................................... 2
Cleaning ........................................................................ 3
Exploded View .............................................................. 4
Parts List ....................................................................... 4
Troubleshooting Guide ................................................. 5
Wiring Diagram ............................................................. 6
This product is warranted to be free from defects in
material and/or workmanship for a period of two (2) years
from date of original installation (with the exception of
racks, pans, and covers), not to exceed 30 months from
date of shipment from our factory. P.C. Boards and
Heater Assemblies are warranted for three (3) years from
date of installation, not to exceed 42 months from date
of shipment.
Any component which proves to be faulty in material and/
or workmanship will be replaced or repaired (at the option
of Prince Castle, Inc.) without cost to the customer for
parts or labor. This warranty covers on location service
(i.e. trip charges and/or mileage). Travel mileage is
limited to 100 miles (200 kilometers) round trip (one trip
warranty) from an authorized service agency or its sub-
service agency.
This warranty is subject to the following exceptions/
conditions:
14.2
Use of any non-genuine Prince Castle parts voids this
warranty.
8.5
All labor shall be performed during regular work hours.
7.7
Overtime premium will be charged to the buyer.
Damage caused by carelessness, neglect, and/or
7.7
abuse (e.g., dropping, tampering or altering parts,
equipment damaged in shipment, by fire, flood or an
act of God) is not covered under this warranty.
Carol Stream, IL 60188
!
Fax: (630) 462-1460
!
LIMITED WARRANTY
PAGE
549-503revA
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Prince Castle DHB4PT-25
Summary of Contents for Prince Castle DHB4PT-25
-
Page 1: Table Of Contents
Any component which proves to be faulty in material and/ or workmanship will be replaced or repaired (at the option of Prince Castle, Inc.) without cost to the customer for parts or labor. This warranty covers on location service (i.e. trip charges and/or mileage). Travel mileage is... -
Page 2: Installation
The SET POINT LED indicator will be on when the Set-point mode is selected. Press and hold the Prince Castle button then press and hold the SET-POINT button to program the temperature for the selected heater... -
Page 3: Cleaning
SET POINT button 1. Press the timer button, the display changes and press the PRINCE CASTLE button for 6 from —:— to –5—. The character 5 will be seconds. The LED indicator next to PROG flashing. -
Page 4: Exploded View
EXPLODED VIEW PARTS LIST ITEM PART DESCRIPTION 72-207S Power Cord 549-033 Cover, Side 549-031 Cover, Top 740-239S PCB, Timer 545-046S PCB, Display 545-047S Main PCB (Not Shown) 740-028S Overlay & Face Plate (Timer) 545-039S Overlay & Face Plate (Main) 549-016 Cover, Bottom 545-076 Insulation... -
Page 5: Troubleshooting Guide
TROUBLESHOOTING Problem Cause Solution A. Display flashes Open relay. Replace Power Circuit Board “Opn” & “rEL” Circuit inoperable B. Display flashes Shorted relay. Replace Power Circuit Board. “SHr” & “rEL” Circuit inoperable. Open heater. Test heater resistance.(150.2 Ohms) Replace Heater Power and Main Circuit Boards. -
Page 6: Wiring Diagram
WIRING DIAGRAM...
Need help?
Do you have a question about the DHB4PT-25 and is the answer not in the manual?
Questions and answers