User’s Guide and Operator Instructions www.fetco.com FETCO Hot Tea Brewer TBS-2111XTS Extractor Touch Screen Models для России: Модернизированная электронная автоматическая самовара Table of Contents Description & Features ...........3 Error Codes..............14 Operational Description ..........4 Operator Training............15 Basic Screens..............4 Service Guide to a Successful Installation....16 Instructions to access the Programming Menu ....5...
Page 2
-RANGE User selectable: 80-97°C/176°-207°F -Brew Temperature may be individually set for each of the eight recipes. Coffee Filter Size: 15” X 5 ½ ”– standard FETCO # F001 Go to fetco.com for the latest versions of all information Page 2 User Guide &...
At 0:00, recipe screen will refresh See following page for programming Icons shown for factory set recipe #1 Go to fetco.com for the latest versions of all information Page 4 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
<Firmware Version> Batch 7 DEMO Mode <Batch ON/OFF> Batch 8 <Batch ON/OFF> Batch Copy <Copy From B.> Go to fetco.com for the latest versions of all information Page 5 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 6
|_____ ___________| brewbasket during drip-out Safety Feature 0:30 10:00 • Alarm at End |______________ YES ……… NO Go to fetco.com for the latest versions of all information Page 6 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 7
90°C sec. This will lower hot water 90° 90°C tank temperature 3-4 degrees 90° 90°C 90° 90°C Go to fetco.com for the latest versions of all information Page 7 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 8
Temperature Probe SD Card If Yes: Calibrate Follow directions Cal. Touch Scr Calibrate ________________[]____ on the touch screen Go to fetco.com for the latest versions of all information Page 8 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 9
Press To Test TEST Use for servicing. Screen • Screen Contrast Contrast |____________[]____| • S. Brightness Brightness |____________[]____| Go to fetco.com for the latest versions of all information Page 9 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
A 3 liter/1 gal BREW valve. measuring container is recommended. Calibration must be repeated for the BYPASS valve Go to fetco.com for the latest versions of all information Page 10 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 11
This is the calibration test flow 0:60 The calibration results are enetered into the slider that automacially displays CAL IN PROGRESS ENTER THE CALIBRATION TEST FLOW RESULTS The calibration is adjusted by the TBS-2111XTS software by entering the ▲ < OUTPUTS >...
Page 12
The calibration results are enetered into the slider that automacially displays CAL IN PROGRESS ENTER THE CALIBRATION TEST FLOW RESULTS The calibration is adjusted by the TBS-2111XTS software by entering the ▲ amount of water into the slilider that was dispensed in 60 seconds.
Page 13
[Not on all units] components in demo mode. Some software versions will not have “DEMO- MODE” Go to fetco.com for the latest versions of all information Page 13 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
This is a SAFETY FEATURE Never attempt to remove a brew basket-during brew-this is a safety feature Go to fetco.com for the latest versions of all information Page 14 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
5. Do not attempt to move hot beverage equipment once it is filled. Drain equipment before moving. 6. FETCO commercial coffee brewers prepare large amounts of coffee or tea in a single batch using very hot water 7. Commercial coffee brewers provides very hot water from the sprayhead, brew basket and faucet when it is pulled.
4. Brewers in this series wire differently in regards to a neutral wire. Review the wire diagrams. 5. The electrical diagram is located in the Users Guide and online at www.fetco.com. 6. Make sure of the tight grounding of the equipment and use the external ground bolt.
Page 17
Do not operate if unit has been submerged or saturated with water. Labels and warnings for hot beverage equipment For BACK PANEL of equipment (1046.00035.00) Go to fetco.com for the latest versions of all information Page 17 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Drawings and Wiring DiagramsParts Drawing 1101.00321.00 TBS-211 ASSEMBLY Go to fetco.com for the latest versions of all information Page 18 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 19
LABEL, WARNING, "HOT WATER FAUCET" B020000G2 BREW BASKET ASS'Y., TBS-2111, GREEN HANDLE PLUG 1063.00030.00 CORD PWR, 16A/250VAC, EU1-16P PLUG, W/O Go to fetco.com for the latest versions of all information Page 19 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 20
STANDOFF, 1/4" HEX 1044.00004.00 LABEL, DANGER, HIGH VOLTAGE 1022.00101.00 BACK INSULATION, TANK, TBS-2111 1022.00102.00 FRONT INSULATION, TANK, TBS-2111 Go to fetco.com for the latest versions of all information Page 20 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Page 21
17:30 minutes: seconds 0.086 15:30 minutes: seconds 0.104 10:30 minutes: seconds 0.125 8:10 minutes: seconds 0.280 1:20 minutes: seconds Go to fetco.com for the latest versions of all information Page 21 User Guide & Operator instructions P152 Rev. 001 NEW December 2016...
Hot water faucet installation instructions Hot water service faucet, if required by operator, is installed before initial set-up TBS-2111XTS is supplied with part number 1000.00109.00 hot water faucet accessory set. Professional installation is required. Do not connect water or electrical utilities before installing.
Need help?
Do you have a question about the TBS-2111XTS and is the answer not in the manual?
Questions and answers