Page 1
OPERATION MANUAL SERIES MODEL MVCe82VBW ONE - WAY PLATE COMPACTOR (HONDA GXE2.OH DC POWER UNIT HONDA DP72104Z BATTERY) Revision #0 (02/01/24) To find the latest revision of this publication or associated parts manual, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
COULD result in DEATH or SERIOUS INJURY. CAUTION Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Addresses practices not related to personal injury. PAGE 4 — MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24)
Page 5
DO NOT use the equipment for any purpose other than its intended purposes or applications. ALWAYS clear the work area of any debris, tools, etc. that would constitute a hazard while the equipment is in operation. MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 5...
Page 6
DC POWER UNIT CAUTION DO NOT touch the DC power unit during work or soon after work, because it is very hot. PAGE 6 — MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24)
Page 9
Emission in the Environment by equipment for use outdoors. Products are tested for hand/arm vibration (HAV) level in accordance with European Directives 2002/44/EC and EN500-4 and ISO 5349-1:2001, ISO 5349-2:2001. MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 9...
The water tank provides lubrication to the base plate when compacting asphalt and may be used for dust control in dry work environments. MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 11...
Page 13
8. Switch Box — contains buttons and indicators to the battery tray. operate compactor. 9. Wheel Kit (Optional) — When deployed, used to move plate compactor to a different location. MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 13...
3. If the oil level is low, fill up to the oil plug with the recommended oil type (Table 7). Maximum oil capacity is 0.148 quarts (0.14 liters). PAGE 14 — MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24)
Page 15
3. Remove the battery pack. 4. Attach the battery connector cap to the power cable. BATTERY FASTENER LEVER Figure 5. Battery Fastener Lever MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 15...
1. Check the water tank for leaks after filling up with water. Figure 7. Fill and Leak Check 2. Check the water tank ON and OFF vave. Valve of Water Tank Figure 8. Water Tank ON-OFF Valve PAGE 16 — MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24)
Then, push the wheel kit to the underside of vibrating plate until the frame of wheel kit touches the vibrating plate (Figure 11). MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 17...
2. The DC Power Unit stops and the POWER indicator turns off. turns off. CAUTION You can also stop the DC Power unit by pressing the POWER button, but it may take some time to stop. PAGE 18 — MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24)
Page 19
14). Figure 14. Water Tank Valve (Open) 2. When stopping sprinkling work, close the valve of water tank (Figure 15). Figure 15. Water Tank Valve (Close) MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 19...
DAILY INSPECTION 1. Check for leakage of fuel or oil. 2. Check for loose screws including tightness. See Table 9 (Tightening Torque) for retightening. Figure 17. V-Belt Tension PAGE 20 — MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24)
Page 21
2. If switch box assembly is loose, it may get damaged or fall off. 3. To tighten, remove the switch box, then replace the grommet installed to switch box panel to new one (Figure 18). MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 21...
2. Clean entire plate compactor, especially the bottom plate removing all dirt and foreign matter. 3. Cover plate compactor and engine with plastic covering or equivalent and store in a clean, dry place. PAGE 22 — MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24)
DC Power Unit starts normally, but forward V-belt slips or comes off? Correct or replace. movement is not stable or it does not vibrate. Bearing failure? Replace. Shock absorbers wear or cracks? Replace. MVCe82VBW COMPACTOR • OPERATION MANUAL — REV. #0 (02/01/24) — PAGE 23...
Need help?
Do you have a question about the MVCe82VBW and is the answer not in the manual?
Questions and answers