Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Orion BLACK COIL Series
Summary of Contents for Orion BLACK COIL Series
- Page 1 HCCA121SPLX HCCA151SPLX HCCA181SPLX High Performance Competition Subwoofers...
- Page 2 Thank you for purchasing this Orion product. Orion products are specif ically engineered and designed for the mobile audio environment. This manual contains important information about installation, set-up procedures and integrating your new Orion product into your vehicle. With proper care and installation, your new product will provide you with many years of high performance listening enjoyment.
-
Page 3: Table Of Contents
TABLE OF CONTENTS INTRODUCTION......................2 FEATURES......................3 SPECIFICATION..................4 WIRING CONFIGURATION..................5-6 BUILDING AN ENCLOSURE..................7 ENCLOSURE DETAILS....................8 WARNING & DISCLAIMER...................9 TROUBLESHOOTING....................10 WARRANTY.......................11-12 WHAT’S IN THE BOX 1 x HCCA SPLX Subwoofer 1 x Mounting Template 1 x Owner’s Manual 1 x Window Sticker... -
Page 4: Features
FEATURES Paper dust cap - moisture and UV resistant. Tall, wide, balanced, NBR Foam (high density expanded polyester foam) surround for linear controlled long excursion using a Tri Radius symmetrical edge design optimized on non-linear FEA. Glass fiber paper complexus cone - moisture and UV resistant. Custom Cast Aluminum frame. -
Page 5: Specification
SPECIFICATIONS HCCA121SPLX HCCA151SPLX HCCA181SPLX Thiele/Small Parameters 12” 15” 18” Fs (free-air resonance, Hz) 40.5 38.5 26.4 Vas (equivalent compliance, cu. ft) 0.3937 1.1039 2.4849 Vas (equivalent compliance, liters) 11.1482 31.2598 70.365 Qms (Q, mechanical) 12.376 5.531 12.114 Qes (Q, electrical) 0.734 0.596 0.781... -
Page 6: Wiring Configuration
WIRING CONFIGURATION Series - One Speakers (Dual 1 ohm voice coils) One dual 1 ohm voice coil woofer with voice coils connected in series results in a 2 ohm load to the amplifier. Series-Parallel - Two Speakers (Dual 1 ohm voice coils) Two dual 1 ohm voice coil woofers with voice coils in series and then parallel will result in a 1 ohm load to the amplifier. - Page 7 WIRING CONFIGURATION 2 Amplifiers - One Speaker (dual 1 ohm) One dual 1 ohm voice coil woofer with each voice coil connected to an individual amplifier, resulting in a 1 ohm load to each amplifier.
-
Page 8: Building An Enclosure
BUILDING AN ENCLOSURE If you’re planning to build your own enclosure and are confused in what type of enclosure best suits your needs this page will help you choose what enclosure best f its your needs. There are many different types of enclosures. The two most common used enclosures are sealed and vented enclosure. -
Page 9: Enclosure Details
ENCLOSURE DESIGN This section gives the basic description for a sealed enclosure. Orion HCCA 15” SPL woofers are designed for sealed enclosures and vented enclosures. Sealed enclosures are generally considered the most versatile for all music types and are the easiest to build. -
Page 10: Warning & Disclaimer
IMPORTANT: Never cut any metal that is an integral part of the vehicle’s safety or structural support system. If you are unsure, it is best to have the product professionally installed by an Authorized ORION Dealer. Never sacrif ice your safety for sound. -
Page 11: Troubleshooting
TROUBLESHOOTING Symptom Check Point Remedy No Sound Is the amplifier power LED 1. Check fuses in amplifier illuminated? 2. Check turn-on lead 3. Check signal lead 4. Check gain control 5. Check source unit volume 6. Clean contacts on fuse holders Is the amplifier overload LED Check speaker for short or illuminated? -
Page 12: Warranty
5. The sole responsibility of Orion under this warranty shall be limited to the repair or replacement thereof, at the sole discretion of Orion. 6. If it becomes necessary to send the product or any defective part to... - Page 13 ALSO HAVE OTHER RIGHTS THAT VARY FROM STATE TO STATE. 10. Should you have any difficulties with the performance of this product during warranty or with any Orion authorized service center, you may contact Orion by emailing us at support@orioncaraudio.com.
- Page 14 __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________...
- Page 15 __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________ __________________________________...
- Page 16 3130 WEST 15TH AVENUE HIALEAH, FLORIDA 33012 TEL: 786.464.0247 EMAIL: SUPPORT@ORIONCARAUDIO.COM ORIONCARAUDIO.COM PROUD SPONSOR OF Copyright ORION All rights reserved. Any unauthorized reproduction or use of any Orion logos, images or design elements is strictly prohibited by law. Specifications subject to change without notice. REV. 23.5...
Need help?
Do you have a question about the BLACK COIL Series and is the answer not in the manual?
Questions and answers