Viking C-1000B Technical Practice page 4

I n s t a l l a t i o
I n s t a l l a t i o
A. Mounting
IMPORTANT: Electronic devices are susceptible to lightning and power station electrical surges from both the AC outlet and the
!
telephone line. It is recommended that a surge protector be installed to protect against such surges. Contact Panamax at (800)
472-5555 or Electronic Specialists Inc. at (800) 225-4876.
Caution: When warm air comes in contact with cold surfaces, such as outside walls and conduits, it causes condensation. To prevent
condensation from accumulating inside the W-3005 always bring conduit into the bottom of the unit. If this is not possible, drill a 1/4" diam-
eter hole in the bottom of the gray plastic box.
*Note: Peel off paper liner and adhere gasket to the back of the faceplate, centering it over the four corner mounting holes. Be careful
to position the modular jack inside the chassis as not to damage the components on the circuit board.
4.0"
Front View of
Plastic Rough-In
Box (included)
Wire knock out
(2) Standard flat head dry wall
(sheet rock) screws (not included)
Important: The W-3005 will NOT
mount to a standard double gang box.
Note: The plastic rough-in box (part # 259576) may be purchased separately
in advance. Go to www.vikingelectronics.com and click on "Spare Parts".
B. Wiring the W-3005 Board
Important: Do NOT install a W-3005 on a
telephone line without a C-1000B Controller
(Fax Back Document 155).
C-1000B Controller
VIKING
MODEL C-1000B
©
VIKING
ELECTRONICS
HUDSON, WI 54016
DOOR ENTRY / CCTV VIDEO
/ PAGING CONTROLLER
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19
COM N.O. N.C. - - - - AUX.
CONTACT
OUTPUT
ON
SIG GND SIG GND SIG GND
VIDEO 1 IN VIDEO 2 IN VIDEO OUT
C C 1 2
TALK BATTERY
LED1 LED2
OFF ON
EARTH C.O. LINE OUT TO KEYLESS DOOR DOORBOX DOOR N.O. COM N.C. N.O. COM N.C.
GND INPUT PHONES C.C. INPUT BOX 1 13VAC PWR BOX 2 DOOR STRIKE 1
C.O.
Line
* Note: The gel-filled (water-tight) butt connectors are designed for insulation displacement on 19-26 guage wire with a maximum insulation of 0.082
inches. Do not strip wires prior to terminating.
** Note: To increase surge protection, loosen the PCB mounting screw labeled
ed) from the mounting screw to Earth Ground (grounding rod, water pipe, etc.)
*** Warning: The doorbox power run wire length is limited to 125 ft of 24 AWG wire. Longer power runs will require heavier gauge wire (doubling
pairs) and/or a higher voltage power adapter. Power runs from 125 - 250 ft of 24 AWG wire are possible using a Radio Shack 18VAC adapter (part
# 273-1690). Voltage at the doorbox power input connections must not exceed 18VAC RMS.
4
n
n
2.1"
*
Adhere gasket to front panel,
centering over mounting holes
5.0"
Push to Call Button
Yellow Call Progress LED Indicator
Condensation Drain Hole
(4) 6-32 X 3/4" stainless steel, flat
head, hexdrive, screws (included)
Unused
PABX/KSU
Single Line
Trunk Input
Phone
3 C
LED3
DOOR STRIKE 2
or
Multi-Line
Phone
3.25"
5.22"
5.14"
Condensation
Front View of Optional
2.25"
VE-5x5 (not included)
The optional VE-5x5 Surface Mount Box is designed
to be surface mounted to a single gang box, double
gang box or VE-GNP gooseneck pedestal (right).
Need More Information on VE-5x5 or VE-GNP?
?
Call (715) 386-4345 and select 424.
(Spade connector
included)
** Earth
Ground
(optional)
* Gel-filled butt
connectors
(EWP only)
Red
Green
IMPORTANT: Electronic devices are susceptible to lightning and power station elec-
!
trical surges from both the AC outlet and the telephone line. It is recommended that
a surge protector be installed to protect against such surges. Contact Panamax at (800)
472-5555 or Electronic Specialists Inc. at (800) 225-4876.
(as shown above) and fasten a wire with spade terminal (includ-
(4) 0.38" diameter
(for gooseneck mounting)
(4) 0.2 x 0.43 slots
for double gang box
(2) 0.2 x 0.43 slots
for single gang box
(1) .74" dia 3.0" 3.3"
Drain Hole
3.0"
Rear View of VE-5x5
(not included)
3.63" Typical
3.63"
Gel-filled butt
*** 13.8VAC
connectors
(18VAC max)
(EWP only)
W-3005 shown with
Viking Model
VE-GNP
Gooseneck
Pedestal
Rear View of
the W-3005
120V AC