Page 1
Please read the following instructions carefully before installing cyclone housing unit into service. Trouble free and safe operating of the unit can only be guaranteed if recommendations and conditions stated in this manual are respected. Omega Air User Manual CKL-CHP v3.00 eng...
Page 2
This element separates already liquefied water from mainstream and prevents the liquids and large particles from being airborne again. To discharge condensate from the CKL-CHP condensate separator it is essential to install automatic or electronic condensate drain. Components Part Plugs G1/8”...
CKL-CHP - Installation and operating manual PRESSURE EQUIPMENT DIRECTIVE PED 2014/68/EU (Fluid group 1) Size PED Category 003 - 047 Category 3, Module H Category 4, Module H1 There is Technical datasheet available. For additional technical specification, contact manufacturer. Safety instructions The relevant safety at work and accident prevention regulations, plus operating instructions, shall apply for operating the cyclone.
Use the device for appropriate purpose only. Appropriate use CKL-CHP series cyclone separators are designed for high efficient removal of bulk liquids from compressed air and vacuum systems. This appliance must be used only for the purpose for which it was specifically designed. All other uses are to be considered incorrect and will void warranty.
CKL-CHP - Installation and operating manual Installation p=0 bar O-ring back-up ring...
Page 7
CKL-CHP - Installation and operating manual Cyclone can be hand over to market and operation only in case, if it is properly installed and used for intended purpose. Installation must not be dangerous for health and safety of people. Cyclone must be installed to solid and levelled ground by support legs (if necessary fixing with bolts).
CKL-CHP - Installation and operating manual Maintenance To prevent air leakage and malfunction replace housing O-ring if necessary. For replacement contact manufacturer. Damaged components are to be replaced by new ones. If a marked degree of damage is found, the entire cyclone is to be replaced.