Hearth & Home Outdoor Lifestyles ODCOUG-36NR Installation Manual
Hide thumbs
Also See for Outdoor Lifestyles ODCOUG-36NR:
- Owners manual care and operation (26 pages) ,
- Installation manual (26 pages) ,
- Owner's manual (26 pages)
Table of Contents
Advertisement
Quick Links
INSTALLER: Leave this manual with party responsible for use and operation.
OWNER: Retain this manual for future reference.
NOTICE: DO NOT discard this manual!
WARNING!
Risk of Fire!
'R QRW LQVWDOO JODVV GRRUV RQ WKLV ¿UHSODFH
Glass doors could cause overheating of
adjacent structures.
Outdoor Lifestyles by Hearth & Home Technologies • Courtyard Installation Manual • 4150-901 Rev. B • 06/23
Installation Manual
Installation and Appliance Setup
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
•
Shut off gas to the appliance.
•
([WLQJXLVK DQ\ RSHQ ÀDPH
•
If odor continues, leave the area immediately.
•
$IWHU OHDYLQJ WKH DUHD FDOO \RXU JDV VXSSOLHU RU ¿UH
department.
•
)DLOXUH WR IROORZ WKHVH LQVWUXFWLRQV FRXOG UHVXOW LQ ¿UH
or explosion, which could cause property damage,
personal injury, or death.
WARNING
'R QRW VWRUH RU XVH JDVROLQH RU RWKHU ÀDPPDEOH YD-
pors and liquids in the vicinity of this or any other
appliance
$Q /3F\OLQGHU QRW FRQQHFWHG IRU XVH VKDOO QRW EH
stored in the vicinity of this or any other appliance.
WARNING: For outdoor use only.
,QVWDOODWLRQ DQG VHUYLFH PXVW EH SHUIRUPHG E\ D
TXDOL¿HG LQVWDOOHU VHUYLFH DJHQF\ RU WKH JDV VXSSOLHU
WARNING:
Improper installation, adjust-
ment, alteration, service or maintenance can cause
injury or property damage. Read the installation,
operating and maintenance instructions thoroughly
EHIRUH LQVWDOOLQJ RU VHUYLFLQJ WKLV HTXLSPHQW
WARNING:
If the information in this manual
LV QRW IROORZHG H[DFWO\ D ¿UH RU H[SORVLRQ PD\
result causing property damage, personal injury, or
loss of life.
1
Advertisement
Table of Contents
Related Manuals for Hearth & Home Outdoor Lifestyles ODCOUG-36NR
Summary of Contents for Hearth & Home Outdoor Lifestyles ODCOUG-36NR
- Page 1 Installation Manual Installation and Appliance Setup INSTALLER: Leave this manual with party responsible for use and operation. OWNER: Retain this manual for future reference. NOTICE: DO NOT discard this manual! DANGER FIRE OR EXPLOSION HAZARD If you smell gas: • Shut off gas to the appliance.
-
Page 2: Table Of Contents
Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. •... -
Page 3: Installation Standard Work Checklist
Installation Standard Work Checklist ATTENTION INSTALLER: Follow this Standard Work Checklist This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in this installation manual. Customer: Date Installed: Lot/Address: Location of Fireplace: Installer: Dealer/Distributor Phone # Model (circle one):... -
Page 4: 3Urgxfw 6Shfl¿F Dqg ,Psruwdqw 6Dihw\ ,Qirupdwlrq
3URGXFW 6SHFL¿F DQG ,PSRUWDQW 6DIHW\ ,QIRUPDWLRQ $ $SSOLDQFH &HUWL¿FDWLRQ ' 1RQFRPEXVWLEOH 0DWHULDOV 6SHFL¿FDWLRQ 0DWHULDO ZKLFK ZLOO QRW LJQLWH DQG EXUQ 6XFK PDWHULDOV DUH MODEL: ODCOUG-36NR; ODCOUG-36TS WKRVH FRQVLVWLQJ HQWLUHO\ RI VWHHO LURQ EULFN WLOH FRQFUHWH VODWH JODVV RU SODVWHUV RU DQ\ FRPELQDWLRQ WKHUHRI ODCOUG-42NR;... -
Page 5: 5Htxluhphqwv Iru Wkh &Rpprqzhdowk Ri 0Dvvdfkxvhwwv
Inspection Note: The following requirements reference various 7KH VWDWH RU ORFDO JDV LQVSHFWRU RI WKH VLGH ZDOO KRUL]RQ- 0DVVDFKXVHWWV DQG QDWLRQDO FRGHV QRW FRQWDLQHG LQ WKLV tally vented gas fueled equipment shall not approve the document. LQVWDOODWLRQ XQOHVV XSRQ LQVSHFWLRQ WKH LQVSHFWRU RE- VHUYHV FDUERQ PRQR[LGH GHWHFWRUV DQG VLJQDJH LQVWDOOHG I. -
Page 6: Getting Started
Getting Started 3RVVLELOLW\ RI ÀRRGLQJ RU UXQQLQJ ZDWHU A. Design and Installation Considerations • Gas supply piping requirements. The Courtyard series gas appliance is designed for outdoor • Electrical wiring requirements. XVH DQG PD\ EH LQVWDOOHG DV D VWDQG DORQH XQLW RU EXLOW LQWR ‡... -
Page 7: Inspect Appliance And Components
C. Inspect Appliance and Components +HDUWK +RPH 7HFKQRORJLHV GLVFODLPV DQ\ UHVSRQVLELOLW\ • Carefully remove the appliance and components from IRU DQG WKH ZDUUDQW\ ZLOO EH YRLGHG E\ WKH IROORZLQJ DFWLRQV the packaging. • Installation and use of any damaged appliance. •... -
Page 8: Applaince Framing Dimensions And Clearances
Appliance Framing Dimensions and Clearances A. Appliance Dimension/Weights Diagrams Dimensions are actual appliance dimensions. Use for reference only. For framing dimensions and clearances refer to page 9. Appliance Weights 0RGHO Pounds ODCOUG-36NR ODCOUG-36TS ODCOUG-42NR ODCOUG-42TS 3 in 20 in (76 mm) (508 mm) Outside Air Outside... -
Page 9: Framing Dimensions
B. Framing Dimensions WARNING! Risk of Fire or burns! Provide adequate NOTICE: ,OOXVWUDWLRQV UHÀHFW W\SLFDO LOOXVWUDWLRQV DQG DUH clearance around air openings and for service access. FOR DESIGN PURPOSES ONLY. Illustrations/diagrams Due to high temperatures, the appliance should be lo- are not drawn to scale. -
Page 10: Ohdudqfh Wr &Rpexvwleohv
C. Clearances to Combustibles WARNING! Risk of Fire! 0DLQWDLQ VSHFL¿HG DLU VSDFH clearances to appliance: When selecting a location for the appliance it is important ‡ ,QVXODWLRQ DQG RWKHU PDWHULDOV PXVW EH VHFXUHG WR SUHYHQW WR FRQVLGHU WKH UHTXLUHG FOHDUDQFHV WR ZDOOV VHH )LJXUH accidental contact. -
Page 11: Vent Terminal Clearances
D. Vent Terminal Clearances = AREA WHERE TERMINAL IS NOT PERMITTED = AIR SUPPLY INLET = FIREPLACE OPENING H or i Electrical Service U.S.A. Installations: In accordance with the current ANSI Z223.1/NFPA 54, National Fuel Gas Code. Canadian Installations: In accordance with the current CSA B149.1, Natural Gas and Propane Installation Code. U.S.A. -
Page 12: Hearth Extension/Floor Protection
$FFHSWDEOH PHWKRG IRU DSSOLFDWLRQ RI PRLVWXUH PHPEUDQH E. Hearth Extension/Floor Protection material shown. See Figures 3.5, 3.6 and 3.7. This appliance does not require a hearth extension. 7KH DSSOLDQFH ZLOO QRW SHUIRUP DV DQ H[WHULRU ZDOO 0RLV- F. Installations WXUH SHQHWUDWLRQ PXVW EH FRQVLGHUHG IRU FRQVWUXFWLRQ WKDW places the appliance in structure walls or on moisture Stand-Alone Installation sensitive surfaces. -
Page 13: Water Drainage
Side View Optional Drain Water Membrane Figure 3.7 Side View of Drainage H. Water Drainage This appliance is designed to operate outdoors experi- encing rain and other sources of moisture that will enter WKH ¿UHER[ 7KH DSSOLDQFH KDV EXLOWLQ GUDLQ KROHV LQ WKH EDVH ZKLFK ZLOO DOORZ PRLVWXUH WR SDVV WKURXJK WKH ERW- tom of the enclosure. -
Page 14: Appliance Preparation
Appliance Preparation A. Securing and Leveling Appliance CAUTION! Risk of Cuts, Abrasions or Flying Debris. Wear protective gloves and safety glasses during instal- lation. Sheet metal edges are sharp. Position, level, and secure the appliance. ‡ ,QVWDOO RQ ZRRG FRPSRVLWH RU QRQFRPEXVWLEOH FRQWLQXRXV ÀDW VXUIDFH H[WHQGLQJ IXOO ZLGWK DQG GHSWK of the appliance to prevent damage. -
Page 15: Electrical Information
Electrical Information A. Wiring Requirements Note: The Courtyard appliance MUST EH FRQQHFWHG WR D *)&, *URXQG )DXOW &LUFXLW ,QWHUUXSW SURWHFWHG FLUFXLW EUHDNHU WARNING! Risk of Shock or Explosion! DO NOT wire 110-120 VAC to the valve or to the appliance wall switch. Incorrect wiring will damage controls. -
Page 16: Wall Switch Control
E. Wall Switch Control The Courtyard series outdoor gas appliance is supplied with a Wall Switch Control. See Figure 5.3 . Connector Switch Box Cover Plate Rock Template Trim Ring On/Off Switch Figure 5.3 Wall Switch Control Kit 8VLQJ WKH QDLOLQJ WDEV PRXQW FRQWURO LQ WKH GHVLUHG location, within 14 feet of the appliance. -
Page 17: Wiring Diagram
F. Wiring Diagram JUNCTION BOX GAS VALVE PILOT ASSEMBLY 3V ADAPTOR WHITE ORANGE BLK (NOT USED) RED (NOT USED) GRN (NOT USED) ON/OFF SWITCH WALL SWITCH WIRE WIRE HARNESS CONTROL MODULE Figure 5.5 Outdoor Lifestyles by Hearth & Home Technologies • Courtyard Installation Manual • 4150-901 Rev. B • 06/23... -
Page 18: Gas Information
Gas Information A. Valve Access WARNING 7KH YDOYH DQG FRQWUROV DUH ORFDWHG LQVLGH WKH EXUQHU DV- Fire Risk. VHPEO\ ([SORVLRQ +D]DUG 7KH FRQWURO ER[ DQG FRQWUROV FDQ EH DFFHVVHG E\ UHPRY- High pressure will damage valve. Low ing the Valve Access Cover shown in Figure 6.1. pressure could cause explosion. -
Page 19: Gas Connection
D. Fuel Conversion C. Gas Connection • 0DNH VXUH WKH DSSOLDQFH LV FRPSDWLEOH ZLWK DYDLODEOH • Refer to Section 3.A for location of gas line access in gas types. appliance. • The Courtyard series gas appliance is supplied from ‡ 7KH JDS EHWZHHQ VXSSO\ SLSLQJ DQG JDV DFFHVV KROH WKH IDFWRU\ IRU XVH ZLWK QDWXUDO JDV ,I D 3URSDQH /3 PD\ EH FDXONHG ZLWK FDXON ZLWK D PLQLPXP RI ž) FRQYHUVLRQ LV UHTXLUHG NLW 2'&28*/3. -
Page 20: Finishing
Finishing A. Facing Material WARNING! Risk of Fire! DO NOT apply combustible materials beyond the minimum clearances. Comply with WARNING! Risk of Fire! Metal front faces may be cov- DOO PLQLPXP FOHDUDQFHV WR FRPEXVWLEOHV DV VSHFL¿HG LQ ered with non-combustible materials only. this manual. -
Page 21: C.decorative Fronts
Combustible or Non-Combustible Mantel Legs or D. Good Faith Wall Surface/TV Guidelines Wall Projections Gray area is 6.00” Unit To Ceiling combustible material 140°F 1" 1" 150°F 2" 2" 3" 3" 150°F 4" 4" 30 in. 5" 5" 24 in. 160°F 6"... - Page 22 Good Faith Guidelines for TV / on’s above a Typical Gas Appliance Combus ble Mantel inch 20.00 mm 508 Non-Combus ble Mantel TV recessed into the wall inch 15.00 TV on the wall mm 381 6" Min. 27" Min. 27" Min. A Min.
-
Page 23: Appliance Setup
Appliance Setup 3. To remove rear refractory, it is necessary to remove A. Remove the Shipping Materials WKH %XUQHU 5HDU &RYHU 5HPRYH VFUHZV VHFXULQJ Remove the plastic coating and shipping materials from cover, lift cover to remove and set aside. See Figure the appliance. -
Page 24: Verify Pilot Shield
E. Verify Pilot Shield Ensure proper placement of the pilot shield. See Fig- XUH 6KLSSLQJ FRXOG FDXVH LW WR EHFRPH GLVSODFHG F. Install Lava Rock Media Be sure to spread Lava rock evenly over the hearth area LQFOXGLQJ WKH KHDUWK SDQ 'R QRW FRYHU EXUQHU WXEH RU pilot when using Lava rock. -
Page 25: Reference Materials
Reference Materials A. Accessories Drain Pans • ODGSDP-36 36” Drain Pan • ODGSDP-42 42” Drain Pan • ODGSDPFLT-36 36” Drain Pan, Flat • ODGSDPFLT-42 42” Drain Pan, Flat LP Conversion Kit • ODCOUG-NGK Natural Gas Conversion Kit for Courtyard Appliance •... - Page 26 2XWGRRU /LIHVW\OHV D EUDQG RI +HDUWK +RPH 7HFKQRORJLHV 7571 215 6WUHHW :HVW /DNHYLOOH 01 www.hearthnhome.com Please contact your Outdoor Lifestyles dealer with any questions or concerns. For the location of your nearest Outdoor Lifestyles dealer, please visit www.hearthnhome.com. Printed in U.S.A. - Copyright 2014 Outdoor Lifestyles by Hearth &...