Propane Gas Connection - Broil King DPA151P-1 Owner's Manual

PROPANE GAS CONNECTION

IR Side Burner Location
This IR Side Burner is designed for outdoor use only.
This IR Side Burner only mounts into the DPA153 side shelf on
either side of a Broilmaster gas grill and cannot be used with
another grill or for any other purpose.
Never operate your Grill and IR Side Burner in any building,
garage, or other enclosed area. Never operate your Grill and
IR Side Burner in a recreational vehicle or boat. Never operate
your Grill and IR Side Burner under any combustible materials, such
as carports, covered porches, awnings, or overhangs.
t
he installation and operation of this Grill and IR Side
Burner at clearances less than specified below may cause
a fire, property damage, or personal injury.
A minimum clearance of sixteen inches is required from all sides
of the IR Side Burner to any combustible material. Refer to the
grill's Owner's Manual for specific grill clearances.
The area surrounding the Grill and IR Side Burner should be
clear to ensure proper ventilation. Do not obstruct the flow of
combustion and ventilation air in any way. The ventilation open-
ings on the propane cylinder enclosure must also remain free
and clear of debris.
Portable grills with IR Side Burners should be level and posi-
tioned away from direct wind prior to each use.
Never move a hot grill.
d
o not install or operate this Grill and IR Side Burner
where gasoline or other flammable materials are used or
stored. Failure to comply with this warning could result
in explosion or fire causing property damage or personal
injury.
Propane Cylinder Safety
Propane vapor fuels your Grill and IR Side Burner. Propane is a
liquid only when it is highly compressed. Keeping it compressed
requires a heavy-duty tank - the LP cylinder.
Inside a full cylinder, the liquid propane makes top up the bottom
80 percent; while propane vapor makes up the 20 percent. As
Page 16
CAUTION
WARNING
you draw this vapor from the top of the tank, the liquid below
expands and turns to vapor. Once all of the liquid turns to vapor,
pressure inside the cylinder drops and gas flow stops.
Liquid Propane (LP) gas has a long history of safe use when the
safety precautions provided in this manual are followed.
Failure to follow these safety precautions could result in
a fire or explosion causing property damage or personal
injury.
Use extreme caution when handling propane gas cylinders.
Keep the cylinder upright while carrying.
While transporting in a vehicle, keep the cylinder upright and
secured to prevent movement. Never place a propane gas cyl-
inder in the passenger area of a vehicle.
Replace any cylinder that has been dropped, dented, has a
malfunctioning valve, or is visibly damaged. Never attempt to
use or repair a damaged propane gas cylinder.
When refilling your cylinder, always insist on a reputable, quali-
fied gas dealer. Your propane gas cylinder is filled by weight, and
should never exceed eighty percent (80%) of its weight limit. If
the cylinder is not completely empty, the gas dealer must make
adjustments to ensure it is not overfilled. Never use an overfilled
Propane gas cylinder.
When you finish grilling, turn off the grill's burners and turn off
the gas at the cylinder. If the grill will not be used for an extend
period, remove the cylinder from the grill for storage.
Cylinder Storage
Store your grill outdoors in a well-ventilated area when the LP
cylinder is attached to it.
Store Propane cylinders in a secured upright position.
Keep children away from LP cylinders.
Store cylinders out of direct sunlight and well away from heat
sources. Do not store cylinders in a building, garage, or other
enclosed area.
Disconnected cylinders must have a threaded valve plug tightly
installed.
Do not store flammable materials near LP cylinders - including
gasoline, paper, grill covers, etc.
B102245-1-0415