Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Gared PSS 6100 Series
Summary of Contents for Gared PSS 6100 Series
- Page 1 Model: 6100 series Scholastic Telescopic Volleyball System Installation, Operation, and Maintenance Instructions Please read all instructions before attempting installation or operation of these units SAVE THESE INSTRUCTIONS FOR FUTURE USE UBLICATION 601751790 RevA 07/05/2022...
-
Page 2: Table Of Contents
6100 Scholastic Telescopic Volleyball System Table of Contents Section Page No. Introduction Parts List by Sub-Assembly Specifications Floor Sleeve Installation Floor Cover Installation Post Installation Instructions Net Installation Instructions 11-14 System Removal Instructions Troubleshooting 16-17 Maintenance Check Sheet... -
Page 3: Introduction
Bill of Materials are present prior to beginning assembly and setup. Please do not substitute for factory parts. Please contact the PSS or Gared Sports customer service department and allow them to determine if substitute parts are acceptable. - Page 4 6100 Scholastic Telescopic Volleyball System...
-
Page 5: Specifications
6100 Scholastic Telescopic Volleyball System MODEL 6100 SCHOLASTIC TELESCOPIC VB SYSTEM MODEL 6105 SCHOLASTIC TELESCOPIC VB SYSTEM less SLEEVES AND COVERS With Sleeves Without sleeves and Covers and Covers 6100-BEIGE 6105-BEIGE 6100-BLACK 6105-BLACK 6100-FOREST 6105-FOREST ... - Page 6 6100 Scholastic Telescopic Volleyball System MODEL 6102 SCHOLASTIC TELESCOPIC TWO COURT VB SYS MODEL 6103 SCHOLASTIC TELESCOPIC TWO COURT VB SYS less SLEEVES AND COVERS Pad Colors BEIGE BLACK FOREST GRAY KELLY MARINE MAROON ...
-
Page 7: Floor Sleeve Installation
1. Mark (2) points on the floor exactly 36 feet apart (refer to most recent set of architectural prints for exact locations within the gym). These represent the CENTERS of each sleeve installation. If sleeves are to be more or less than 36 feet apart, contact a PSS or Gared representative for information regarding this alteration. - Page 8 6100 Scholastic Telescopic Volleyball System Note: A skilled woodworker will be needed for the following operation! Using a router and template, make a counterbore 6-7/16” diameter by 9/16” deep centered over the original 5” hole in the floor, to receive the brass floor cover. A template can be made from a piece of Masonite or thick plastic.
- Page 9 6100 Scholastic Telescopic Volleyball System...
-
Page 10: Floor Cover Installation
6100 Scholastic Telescopic Volleyball System Counterbore Details and Floor Cover Installation... -
Page 11: Post Installation Instructions
6100 Scholastic Telescopic Volleyball System Post Installation Instructions 1. Lift and rotate the floor covers out of the way. Insert the Winch Post(s) and End Post. 6102 & 6103 systems will have (2) Winch Posts and (1) End Post. One of the Winch Posts will be used as a center post. -
Page 12: Net Installation Instructions
6100 Scholastic Telescopic Volleyball System Net Installation Instructions (6100 & 6105) 1. Lay out the net in the approximate position between the two posts. 2. Make sure the winch is centered below the top cable ensuring a straight-line feed from the net to the winch by loosening the winch positioning knob and positioning the winch bracket assembly accordingly. - Page 13 6100 Scholastic Telescopic Volleyball System Net Installation Instructions (6102 & 6103) 1. Lay out the nets in the approximate positions between the three posts. 2. Make sure the winch is centered below the top cable ensuring a straight-line feed from the net to the winch by loosening the winch positioning knob and positioning the winch bracket assembly accordingly.
- Page 14 6100 Scholastic Telescopic Volleyball System The Net Top Cable is fully tensioned when the court center of the net no longer raises with additional tightening of the winch. DO NOT OVER TENSION THE NET. Net Height at Center Court Men’s VB 95 5/8 Inches 2.429 meters...
- Page 15 6100 Scholastic Telescopic Volleyball System 10. Once the net height is adjusted, center the net on the top cable so that there is equal space between the ends of the net and the posts (about 23” per side as shown above). Undo the Velcro net straps as they come shipped with the net.
-
Page 16: System Removal Instructions
6100 Scholastic Telescopic Volleyball System System Removal Instructions a. Remove antennae (you may leave side marker sleeves attached). b. Unhook net straps from posts at both ends. c. Crank winch until net cable can be unhooked from snap links. d. Fold net up and transport net and posts to storage. 6107 End Post with Net 6106 Winch Post with Net... -
Page 17: Troubleshooting
6100 Scholastic Telescopic Volleyball System Troubleshooting Volleyball posts are not perpendicular to floor when inserted in floor sleeves. As noted on page 7, the posts are to be at a 3-degree angle when installed, this is to accommodate the flex of the post when under tension. ... - Page 18 6100 Scholastic Telescopic Volleyball System Volleyball net top cable too short / will not reach both posts 1. Make sure top cable is not directly attached to T-Handle Pin but attached to quick link, and the quick link attached to T-Handle Pin. 2.
-
Page 19: Maintenance Check Sheet
6100 Scholastic Telescopic Volleyball System Maintenance 1. General inspection of equipment when used should be performed to ensure no catastrophic failures have occurred during the course of use between yearly inspections. 2. It is recommended that yearly inspections be conducted to determine if any bolts or any other hardware has become worn or loosened. - Page 20 Gared Holdings, LLC Performance Sports Systems Gared Sports 9200 E. 146 Street 9200 E. 146 Street Noblesville, IN 46060 Noblesville, IN 46060 800-848-8034 800-325-2682 www.perfsports.com www.garedsports.com...
Need help?
Do you have a question about the PSS 6100 Series and is the answer not in the manual?
Questions and answers