General; Introduction; Oven Installation; Oven Operation - Vulcan-Hart VCV13 Service Manual

INTRODUCTION

Vulcan-Hart Cook and Hold Oven Systems are
produced with quality workmanship and material.
Proper installation, usage and maintenance will result
in many years of satisfactory performance.
Before performing maintenance on the oven,
thoroughly read this manual and carefully follow all
instructions in the order given.
This manual is applicable only to models listed on
the cover page. Procedures in this manual will apply
to all models unless specified. Illustrations can be
of any model unless the illustration needs to be
model-specific.

OVEN INSTALLATION

Refer to the Installation and Operation Manual for
detailed installation instructions.

OVEN OPERATION

Refer to the Installation and Operation Manual for
detailed operating instructions.
MODEL NO. HEIGHT
IN (mm)
78 (1981)
VCV13
43 (1093)
VCV6
32.5 (826)
VCV4
31.5 (800)
VCV5

ELECTRICAL REQUIREMENTS

The Vulcan-Hart Models VCV13 and VCV6 are
factory-wired for dual 208/240-V, 1-Ph, 60-Hz, AC
power, but may be supplied by 208/240-V, 3-Ph
50-Hz, AC power. Vulcan-Hart models VCV4 and
VCV5 are factory-wired for 120-V, 1-Ph, 60-Hz,
AC power.
COOK AND HOLD OVEN SYSTEMS

GENERAL

SPECIFICATIONS

DEPTH WIDTH
IN (mm) IN (mm)
30.75 (781) 22.25 (566)
30.75 (781) 22.25 (566)
26.875 (683) 17.25 (438)
33.75 (857) 28.5 (718)
Page 5 of 28

OVEN CLEANING

Refer to the Installation and Operation Manual for
detailed cleaning instructions.

SERIAL NUMBER LOCATION

The Serial Number and Model Number for the unit
are located on the Serial Data Plate, which is located
by the electrical connection.
Figure 1: Serial Data Plate
SHIPPING VOLTS
WT. Lb (kg)
438 (199) 208/240
275 (125) 208/240
130 (59) 120
170 (77) 120

TOOLS

Standard
• Standard set of hand tools
• Volt-Ohm-Meter (VOM) with AC current tester
with sensitivity of at least 20,000 Ohms per volt
• Standard Thermometer
• Pop Rivet Gun and 1/8" pop rivets for Models
VCV4/VCV5 Oven Door Gasket replacement
Special
• CLR Treatment Kit to remove Calcium/Lime/
Rust from oven (Contact Authorized
Vulcan-Hart Servicer)
WATTS AMPS
3800/5060 19/22
1900/2530 10/11
1500 15
1200 15
F-38056 (5-08)