Preventive Daily Maintenance; Fuel System Leaks; Engine Oil Level; Cooling System - Zetor MAJOR Operator's Manual

Preventive daily maintenance

Perform this maintenance daily or after every 8 - 10 hours
of operation at the latest.

Fuel system leaks

Check the fuel system for leaks, including the fuel tank.
Repair any leaks immediately. The hole for draining dirt
from the fuel tank is found in its bottom.

Engine oil level

Perform a check on a daily basis before putting into
operation, making the tractor stable on a flat surface with
the engine off. The engine oil gauge (1) is located on the
left-hand side of the engine.
Pull out the gauge (1), wipe it with a clean fibreless rag
and slip it fully back in.
After pulling out the gauge once again check the oil level.
The oil level must be always between MIN and MAX.
You can top up the oil if need be.

Cooling system

Check the connections of the engine cooling system for
leaks and the coolant quantity in the expansion tank.
Replenish the missing quantity up to the upper mark
indicated MAX. The minimum acceptable cooling liquid
level is indicated by the MIN mark.
Only release the overpressure plug when the
coolant has cooled down! There is a danger of
scalding!
PREVENTIVE DAILY MAINTENANCE
21
NM13N083
NM14D006