Prevent Battery Explosions; Prevent Battery Explosions; Frost Protection - Winterization; Live With Safety - Nanni N4.65 Operator's Manual

S02 SAFETY
Always remove grounded (-) battery clamp first and
replace grounded clamp last. Sulfuric acid in battery
electrolyte is poisonous and strong enough to burn skin,
eat holes in clothing, and cause blindness if splashed
into eyes.
Avoid hazards and acid burns in :
• Filling batteries in a well-ventilated area
• Wearing eye protection and rubber gloves
• Avoiding use of air pressure to clean batteries
• Avoiding breathing fumes when electrolyte is
• Avoiding spilling or dripping electrolyte
• Using correct battery booster or charger procedure.
If acid is spilled on skin or in eyes:
• Flush skin with water
• Apply baking soda or lime to help neutralize the acid
• Flush eyes with water for 15-30 minutes.
• Get medical attention immediately.
If acid is swallowed:
• Do not induce vomiting
• Drink large amounts of water or milk, but do not
exceed 2 L (2 qt.)
• Get medical attention immediately.

PREVENT BATTERY EXPLOSIONS

Keep sparks, lighted matches, and open
flame away from the top of battery. Battery
gas can explode. Never check battery
charge by placing a metal object across
the posts. Use a volt-meter or hydrometer.
Do not charge a frozen battery: it may
explode. Warm up battery to 16°C (60°F) before doing it.
WARNING !
Battery posts, terminals, and related accessories contain
lead and lead compounds. Rinse hands after handling
batteries.

FROST PROTECTION - WINTERIZATION

See Maintenance Section 08 - Raw Water System - Risk
of icing conditions / Protection against frost.
WARNING !
When the engine has been set for winterization, place
"DO NOT OPERATE" labels onto taps, valves, parts of
equipment which have been turned off. Place a large and
visible reminder on the wheelhouse dashboard.

LIVE WITH SAFETY

Before returning engine to customer, make sure engine
is functioning properly, especially the safety systems.
Make sure that all guards and shields are in place.

PREVENT ACCIDENTS

IMPORTANT !
When engine is OFF, always set the transmission lever to
neutral position.
16