Airxcel Coleman-mach 47000 Series Installation, Operation And Maintenance Instructions
  1. Manuals
  2. Brands
  3. Airxcel Manuals
  4. Air Conditioner
  5. Coleman-Mach 47000 SERIES
  6. Installation, operation and maintenance instructions

Airxcel Coleman-mach 47000 Series Installation, Operation And Maintenance Instructions

Hide thumbs Also See for Coleman-mach 47000 Series:
Table of Contents

Advertisement

Available languages

Available languages

Quick Links

INSTALLATION, OPERATION AND
MAINTENANCE INSTRUCTIONS FOR
47000 SERIES AIR CONDITIONERS

TABLE OF CONTENTS

I.
II.
III.
IV.
V.
VI.
VII.
(9400 Series)
VIII.
These instructions are a general guide for installing the 47000 Series Coleman-Mach roof top Air Conditioners. For
specific air conditioner details, it will be necessary to refer to ALL printed documents supplied with this unit.
These instructions are for the use of qualified individuals specially trained and experienced in installation of this
type equipment and related system components.
Installation and service personnel are required by some states to be licensed. PERSONS NOT QUALIFIED
SHALL NOT INSTALL NOR SERVICE THIS EQUIPMENT.
NOTE: The words "Shall" or "Must" indicate a requirement which is essential to satisfactory and safe product
performance. The words "Should" or "May" indicate a recommendation or advice which is not essential and not
required but which may be useful or helpful.
WARNING! - SHOCK HAZARD To prevent the possibility of severe personal injury or equipment damage
due to electrical shock, always be sure the electrical power source to the appliance is disconnected.
CAREFULLY FOLLOW ALL INSTRUCTIONS AND WARNINGS IN THIS BOOKLET TO AVOID DAMAGE TO
WARNING! Improper installation may damage equipment, can create a hazard and will void the warranty.
The use of components not tested in accordance with these units will void the warranty, may make the
equipment in violation of state codes, may create a hazard and may ruin the equipment.
P/N: 1980-002, Rev 2
2
2
2
2
4
5
5
6
IMPORTANT NOTICE
THE EQUIPMENT, PERSONAL INJURY OR FIRE.
IX.
i.
ii.
iii.
iv.
v.
vi.
X.
XI.
1
6
6
6
9
9
10
10
23
24
07-14-2020

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Coleman-mach 47000 Series and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Airxcel Coleman-mach 47000 Series

Summary of Contents for Airxcel Coleman-mach 47000 Series

  • Page 1: Table Of Contents

    INSTALLATION, OPERATION AND MAINTENANCE INSTRUCTIONS FOR 47000 SERIES AIR CONDITIONERS TABLE OF CONTENTS Operation and Maintenance General Information General Information Control Panel Air Conditioning Sizing iii. Operation III. Selecting an Installation Location Maintenance Installing the Roof Top Unit Wall Thermostat Identification and Operation Electrical Wiring Warranty Service...

  • Page 2: General Information

    III. SELECTING AN INSTALLATION LOCATION 2. It may be necessary to seal some of the old roof Your Airxcel, Inc. air conditioner has been designed for vent mounting screw holes which may fall outside use primarily in recreational vehicles.
  • Page 3 Airxcel, Inc. requires that the spacing from the vehicle roof top to the interior ceiling be no less than 1”. A typical support frame is shown in Figure 1.

  • Page 4: Electrical Wiring

    ETC.), STRIP ROUTING 115 VAC Wiring SHEATH BACK TO EXPOSE 4-6 INCHES OF THE Following Airxcel’s high voltage wiring specifications and SUPPLY LEADS. all local and national electrical codes, route the 115 VAC STRIP THE INDIVIDUAL WIRE LEAD ENDS FOR supply wiring from its power source to the wire box.

  • Page 5: Installing The Optional Heater Accessory

    DANGER – SHOCK HAZARD D. Connect the supply power black conductor to the TO PREVENT THE POSSIBILITY OF SHOCK black pigtail wire, the white conductor to the INJURY, WHITE WIRE MUST white pigtail wire and the supply ground CONNECTED TO NEUTRAL IN THE SERVICE conductor to the green pigtail wire found in the BOX ENTRANCE AND THE MECHANICAL wiring box using the 3 provided wire nuts.

  • Page 6: System Checkout

    VIII. SYSTEM CHECKOUT necessary to review the specific unit operation Airxcel, Inc. manufactures a wide range of roof top characteristics (features) described in the product air conditioners which incorporate different product OPERATION MAINTENANCE operation features. To properly evaluate the INSTRUCTIONS section of this booklet.
  • Page 7 Apply today by filling out the application located on the back cover of this Installation and Operation Manual and mailing it in along with your check or money order for $89.95 to Airxcel, Inc., P.O. Box 4020, Wichita, KS 67204. A contract will be sent to you within a few weeks.

  • Page 8: General Information

    IX. OPERATION AND MAINTENANCE INSTRUCTIONS FOR 47000 SERIES ROOF TOP AIR CONDITIONERS AND CEILING PLENUM GENERAL INFORMATION R410A Roof Top Air Conditioners This roof mount air conditioner is designed to operate High Pressure Switch Lockout Circuit from a 115 VAC, 60 HZ, 1 Phase power supply. Any Air conditioners and heat pumps using R410A time an air conditioner is not operating properly, the refrigerant may utilize a factory installed High Pressure...

  • Page 9: Operation

    iii. OPERATION on and off in this fashion until the selector switch is I. For Cooling (Refer to Figure 1, page 8). turned to another mode of operation. A. Turn the selector switch to the “LOW COOL” or C. Position the louvers to the desired direction the “HIGH COOL”...

  • Page 10: Wall Thermostat Identification And Operation

    Airxcel, Inc. support help may be accessed by e-mail cord is being used for the distance covered from at RVPSupport@Airxcel.com. All written the utility outlet to the RV. The required minimum...
  • Page 11 CLIMATISEURS SÉRIE 47000 INSTRUCTIONS POUR INSTALLATION ET LE FONCTIONNEMENT ET D’ENTREITIEN TABLE DES MATIERES Opération et maintenance Informations générales Informations générales Sélection d’un climatiseur approprié Panneau de Controle Sélection de l’emplacement III. Functionnement iii. d’installation Entretien Installation de l’unité de toit Identification et functionnement du Câblage électrique thermostat mural...

  • Page 12: Sélection D'un Climatiseur Approprié

    à votre représentant nous recommandons les endroits ci-dessous. Airxcel ou à Airxcel devraient contenir le nom et le Autocaravanes : une unité unique ou l’unité avant de numéro de série du modèle du climatiseur. Le nom et deux devrait être installée à...
  • Page 13 La série 47000 d’Airxcel exige un écart minimum de 2,54 cm (1 po) entre le toit du véhicule et son plafond (intérieur). Un cadre de soutien type est illustré dans la Figure 1.

  • Page 14: Câblage Électrique

    CÂBLE DU CONNECTEUR ÉLECTRIQUE. LA ACHEMINEMENT DU CÂBLAGE 115 V CC GAINE DOIT PÉNÉTRER AU-DELÀ DE LA En respectant les spécifications d’Airxcel, Inc. pour le DOUILLE DU SERRE-CÂBLE À L’INTÉRIEUR DE câblage haute tension et l’ensemble des codes de LA BOÎTE, TEL QU’ILLUSTRÉ. ASSUREZ-VOUS l’électricité...

  • Page 15: Installation De L'accessoire De Chauffage Facultatif

    Figure 4 Figure 6 Figure 5 VI. INSTALLATION DE L’ACCESSOIRE DE CHAUFFAGE FACULTATIF DANGER - RISQUE DE CHOC ÉLECTRIQUE! IMPORTANT REMARQUE : AFIN DE PRÉVENIR LA POSSIBILITÉ DE L’accessoire de chauffage facultatif sert à éliminer BLESSURE PAR CHOC ÉLECTRIQUE, LE FIL la fraîcheur de l’air intérieur quand celui-ci est BLANC DOIT...

  • Page 16: Installation De L'ensemble De Plafond (Série 9400)

    SYSTÈME fournies (voir Figure 8). F. Branchez la conduite électrique du climatiseur dans Airxcel, Inc. fabrique une gamme étendue de la prise à 9 positions de la façon illustrée dans la climatiseurs de toit qui incorporent différentes Figure 7.
  • Page 17 Figure 9...
  • Page 18 Postulez dès aujourd’hui en remplissant le formulaire situé sur la couverture arrière de cette installation et d’utilisation et en l’envoyant dans le long avec votre chèque ou mandat à Airxcel, Inc., PO Box 4020, Wichita, KS 67204. Un contrat sera envoyé à...

  • Page 19: Panneau De Controle

    IX. MODE D’EMPLOI ET UTILISATION SÉRIES 47000 DES CLIMATISEURS DE TOIT DES PLÉNUM DE PLAFOND i. RENSEIGNEMENTS GÉNÉRAUX R410A CLIMATISEURS DE TOIT Circuit de blocage du contacteur haute pression Ces climatiseurs de toit furent conçus pour fonctionner Pompes à chaleur utilisant le R410A réfrigérant utiliser à...

  • Page 20: Entretien

    iii. FONCTIONNEMENT thermostat met le compresseur en marche lorsque la température de l’air qui entre dans le climatiseur I. Pour le refroidissement diminue de quelques degrés sous le réglage choisi. (se reporter aux figure 1, page 22). Lorsque la température de l’air qui entre dans le A.

  • Page 21: Identification Et Functionnement Du

    électriques ne doivent être effectués que par un P.O. Box 4020 personnel d’entretien qualifié. Contactez votre Wichita, KS 67204 centre d’entretien Airxcel, Inc. s’il y a des problèmes. IMPORTANT B. Points de contrôle – Les climatiseurs ont quelquefois 1. Lisez attentivement l’AN GARANTIE LIMITÉE 2, des problèmes de démarrage ou de refroidissement.
  • Page 22 Figure 1 Figure 2...

  • Page 23: Serial Number Nomenclature

    X. SERIAL NUMBER NOMENCLATURE The serial number format from March 2020 to present is: the first 2 digits signify the production year, the last 7 years are sequential production numbers (random number) EXAMPLE: 20XXXXXXX XXXXXXX Year 7 random (2020) numbers The serial number format from January 2013 to March 2020 is: the first 2 digits signify the production year, the second 2 digits signify the month of production...

  • Page 24: Optional Extended Warranty

    Apply today by filling out the application below and mailing it with your check or money order for $89.95 to Airxcel, Inc., P.O. Box 4020, Wichita, KS 67204. A contract will be sent to you within a few weeks. You should retain with your paperwork for proof of purchase.

Table of Contents