Table of Contents

Advertisement

Quick Links

GAS GRILL
LP Gas Grill Owner's Guide
670
YOU MUST READ THIS OWNER'S GUIDE
BEFORE OPERATING YOUR GAS GRILL.
m DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flames.
3. Open lid.
4. If odour continues, keep away from the
appliance and immediately call your gas
supplier or your fire service.
Leaking gas may cause a fire or explosion,
which can cause serious bodily injury or
death, or damage to property.
m WARNING
1. Do not store or use petrol or other
flammable vapours and liquids in the
vicinity of this or any other appliance.
2. A gas supply cylinder not connected for
use should not be stored in the vicinity
of this or any other appliance.
#56524
m WARNING: Follow all leak-check
procedures carefully in this manual
before operating barbecue. Do this even
if barbecue was dealer-assembled.
m WARNING: Do not ignite this appliance
without first reading the BURNER
IGNITION sections of this manual.
INFORMATION FOR THE INSTALLER:
This manual must remain with the owner,
who should keep it for future use.
OUTDOOR USE ONLY.
845BR-0035
0845
56524 08/01/13 LP
EN - INTERNATIONAL ENGLISH

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 56524 and is the answer not in the manual?

Questions and answers

Summary of Contents for Weber 56524

  • Page 1 2. A gas supply cylinder not connected for 845BR-0035 use should not be stored in the vicinity of this or any other appliance. 0845 56524 08/01/13 LP EN - INTERNATIONAL ENGLISH...
  • Page 2: Warnings

    Ignoring this warning could cause a fire or instructions. an explosion that may damage property or cause serious m Do not use charcoal, briquettes or lava rock in your Weber ® bodily injury or death. ◆...
  • Page 3: Table Of Contents

    ROTISSERIE BURNER MANUAL IGNITION . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27 WEBER GRILL OUT™...
  • Page 4: Exploded View

    EXPLODED VIEW SUMMIT_670_LP_EN_080113...
  • Page 5: Exploded View List

    40. IR Burner Hose 62. Matchstick Holder 19. Small Knob Bezel 41. Rotisserie Spit Assembly 63. Caster 20. Small Knob 42. Cooking Grate 64. Locking Caster 21. Large Knob 43. Smoker Box 22. Large Knob Bezel 44. Smoker Bar www.weber.com ®...
  • Page 6: Warranty

    ® Infrared rotisserie burner: 2 years Weber is not liable for any special, indirect or consequential damages . Some regions do not allow the All remaining parts: 2 years exclusion or limitation of incidental or consequential damages, so this limitation or exclusion may not apply to you .
  • Page 7: Gas Instructions

    . Under moderate pressure, inside a cylinder, LP gas is a liquid . As the pressure is released, the liquid readily vapourises gas hose assembly on your Weber gas barbecue every ®...
  • Page 8: Installing The Cylinder

    A) Place the cylinder on the ground, outside the base cabinet, on the right side of the grill (7) . B) Turn the LP cylinder so the opening of the valve is facing the front of the Weber ® barbecue .
  • Page 9: Connecting The Liquid Propane Cylinder

    Make sure regulator lever is in the off position . Slide the collar of the regulator up (7) (9) . Push the regulator down onto the tank valve and maintain pressure . Slide collar closed (8) (10) . If regulator does not lock, repeat procedure . ◆ www.weber.com ®...
  • Page 10: Leak-Check Preparation

    GAS INSTRUCTIONS LEAK-CHECK PREPARATION m WARNING: The gas connections of your Summit gas grill ® have been factory-tested. We do, however, recommend that you leak-check all gas connections before operating your Summit gas grill. ® Remove Control Panel Tools needed: Screwdriver, pliers, and towels . A) Remove burner control knobs (1) .
  • Page 11: Check For Gas Leaks

    NOTE: All factory-made connections have been thoroughly checked for gas leaks. The burners have been flame-tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber® gas barbecue. Shipping and handling may loosen or damage a gas fitting.
  • Page 12 DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® D) Side burner hose to bulkhead connection (4) .
  • Page 13: Refilling The Liquid Propane Cylinder

    WEBER GRILL OUT HANDLE LIGHT ® ® The Weber Grill Out handle light has a built-in “tilt sensor . ” With the power button (1) ® ® activated, the light will come on when the grill lid is open . The light will turn off when the lid is closed .
  • Page 14: Before Using The Grill

    WARNING: Always check hose before using barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber authorised replacement hose. Contact ® the Customer Service Representative in your area using the contact information on our web site.
  • Page 15: Snap Ignition Operation

    Repeat lighting procedure a second time . m WARNING: If the burner still does not light, turn the burner control knob to OFF and wait five minutes to let the gas clear before you try again or try to light with a match. ◆ www.weber.com ®...
  • Page 16: Main Burner Ignition & Usage

    MAIN BURNER IGNITION & USAGE MAIN BURNER IGNITION m DANGER Failure to open the lid while igniting the barbecue’s burners, or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up, which can cause serious bodily injury or death.
  • Page 17: Main Burner Manual Ignition

    OFF and wait five minutes to let the gas clear before you try again. ◆ TO EXTINGUISH Push in and turn each burner control knob clockwise to OFF position .Turn gas supply off at the source . ◆ www.weber.com ®...
  • Page 18: Grilling Tips & Helpful Hints

    NOTE: If grill loses heat while cooking refer to the troubleshooting section of this manual. m WARNING: Do not move the Weber gas barbecue when ® operating or while barbecue is hot.
  • Page 19: Cooking Methods

    . For longer cooking times, add water to the foil pan to keep drippings from burning . The drippings can be used to make gravies or sauces . ◆ www.weber.com ®...
  • Page 20: Side Burner Ignition & Usage

    SIDE BURNER IGNITION & USAGE SIDE BURNER IGNITION m DANGER Failure to open the lid while igniting the side burner, or not waiting five minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up, START/HI which can cause serious bodily injury or death.
  • Page 21: Sear Station ® Ignition & Usage

    The grills illustrated in this be damaged in any way, do not use the barbecue. Replace Owner's Guide may vary slightly from model purchased . using only Weber authorised replacement hose. Contact ® the Customer Service Representative in your area using the contact information on our web site.
  • Page 22: Sear Station ® Burner Manual Ignition

    Food is placed in the area of intense heat between the lit burners . USING THE SEAR STATION ® Your Weber ® gas barbecue includes a sear burner for searing meats such as steak, poultry cuts, fish, and chops .
  • Page 23: Smoker Burner Ignition & Usage

    Customer Service Representative in your area using the Owner's Guide may vary slightly contact information on our web site. from model purchased . Log onto www.weber.com ® A) Open the grill lid (1) . B) Open smoker box lid (2) .
  • Page 24: Smoker Burner Manual Ignition

    Contact the ® Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® A) Open the lid (1) . m DANGER Failure to open the lid while igniting the grill, or not waiting...
  • Page 25: Using The Smoker

    To a lesser degree a “smoke” residue will accumulate on the inside of your gas grill. This residue need not be removed and will not adversely affect the function of your gas grill. ◆ www.weber.com ®...
  • Page 26: Rotisserie Burner Ignition & Usage

    WARNING: Always check hose before using grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only a Weber authorised replacement hose. Contact the ®...
  • Page 27: Rotisserie Burner Manual Ignition

    WARNING: Always check hose before using grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only a Weber authorised replacement hose. Contact the ®...
  • Page 28: Important Safeguards

    This rotisserie is not for use by children. Representative in your area using the contact information m To protect against electrical hazards do not immerse power on our web site. Log onto www.weber.com ® lead, plugs, or motor in water or other liquids.
  • Page 29: Rotisserie Cooking

    CAUTION: Do not allow rotisserie spit to come into contact with any gas lines. B) Store rotisserie forks by placing them on the hooks located on the catch pan holder within the grill cabinet (2) . ◆ www.weber.com ®...
  • Page 30: Troubleshooting

    LP cylinder . Replace with a spare LP cylinder and resume cooking . If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® SIDE BURNER TROUBLESHOOTING...
  • Page 31: Sear Station ® Troubleshooting

    . Turn cylinder valve on slowly . Refer to “MAIN safety device. BURNER IGNITION”) . If problems cannot be corrected by using these methods, please contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ® ROTISSERIE TROUBLESHOOTING PROBLEM...
  • Page 32: Maintenance

    MAINTENANCE CLEANING WEBER SPIDER/INSECT SCREENS ® m WARNING: Turn your Weber gas barbecue off and wait for Your Weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders ® and other insects . They can nest in the venturi section (1) of the burner tubes . This it to cool before cleaning.
  • Page 33: Replacing Main Burners

    (9) . Do not disconnect the blue wire from the left side of the manifold assembly . C) Pull the selected burner tube(s) through the front of cookbox and replace with new burner tube(s) (10) . www.weber.com ®...
  • Page 34 MAINTENANCE Remove Sear Station Burner ® To remove the Sear Station burner, pull the burner tube toward you . This removes it ® from the burner tube notch (11) . Then rotate the tube clockwise (12), so that the screw at the end of the tube (13) fits through the notch in the heat shield opening (14).
  • Page 35: Side Burner Maintenance

    . If the spider/insect screen becomes damaged or cannot be cleaned, please contact the Customer Service Representative in your area using the contact information on our web site . Log onto www .weber .com ® Burner Flame Pattern...
  • Page 36 This product has been safety-tested and is only certified for use in a specific country. Refer to country designation located on outside of box. These parts may be gas-carrying or gas-burning components . Please contact Weber-Stephen Products LLC Customer Service Department for genuine Weber-Stephen Products LLC replacement part(s) information .

This manual is also suitable for:

Summit e-670Summit 6707371001

Table of Contents