Troubleshooting - Winston Industries Collectramatic 8000 Series Use & Care Manual

Fryer control 8 channel very low pressure/temperature 4 head & 6 head

Hide thumbs

Table Of Contents

Table of Contents

TROUBLE

ALL FRYERS

Power lamp fails to light ................................................................ 1, [CS]

Power lamp dim............................................................................. 1, [CS]

Heat ON lamp not on when heating .............................................. [CS]

Display reads "Lo" or "Heat", heat on lamp is off, and fryer ......... 18

is not heating up

No heat (all lamps out) .................................................................. 1, [CS]

Heats slowly .................................................................................. [CS]

Cooking oil smoking excessively ................................................... 2, 3, [CS]

Cooking oil foaming excessively ................................................... 3

Cooking oil boils over .................................................................... 4, 5, 6, 7

Cooking oil has burnt or bad taste ................................................ 8, 9, [CS]

Cooking oil breaking down too quickly .......................................... 8, 9, 10 [CS]

Cooking oil leak around collector gasket ..................................... 11, 12

Controls not responding correctly ................................................. [CS], 17

Hi Limit light is lit ........................................................................... [CS], 17

PRESSURE FRYERS ONLY

No pressure ................................................................................... 13, 14, [CS]

Low pressure ................................................................................. 14, 15, 16, [CS]

Pressure loss excessive through vent........................................... 13, [CS]

Pressure loss excessive through lid valve .................................... 15, 16

Cooking oil leaking from back of fryer .......................................... [CS]

[CS] Call for service (see page 31)

FAULT CODE

1. Open power line (check circuit breaker) ......................... Adjust or [CS]

2. Cooking oil level below top heater .................................. Adjust, See page 15

3. Cooking oil badly broken down ....................................... Clean or Replace

4. Cracklings left in or allowed to overfill ............................ Clean,

5. Never stir in collector after warm-up ............................... See page 16

6. Heat plate left out of collector ......................................... Replace

7. Improper warm-up (solid cooking oil in collector)

8. Cracklings allowed to reach bottom heaters ................... Clean,

9. Heater holder slipped - heaters touching........................ Adjust or [CS]

10. Fryer not kept clean ........................................................ Clean,

11. Pot groove for collector gasket dirty ............................... Clean,

Collectramatic ® Fryers – Very Low Pressure/Temperature – LP46, LP56

...............

Continued on next page