1. Manuals
  2. Brands
  3. HAMPTON BAY Manuals
  4. Stove
  5. Greenfire GC60-2
  6. Owner's manual

HAMPTON BAY Greenfire GC60-2 Owner's Manual

Freestanding cast iron pellet stove
Hide thumbs Also See for Greenfire GC60-2:
Table of Contents

Advertisement

Quick Links

Download this manual
PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLATION AND USE OF THIS
PELLET-BURNING ROOM HEATER. FAILURE TO FOLLOW THESE INSTRUCTIONS
COULD RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH.
Contact your building or fire officials about restrictions and installation inspection
WARNING:
Improper installation, adjustment, alteration, service
or maintenance can cause injury, property damage,
or loss of life. Refer to this manual. For assistance or
additional information consult an authorized
installer or service agency.
Tested by:
IMPORTANT: SAVE THESE INSTRUCTIONS
920-586
FPI FIREPLACE PRODUCTS INTERNATIONAL, LTD. 6988 Venture St., Delta, BC, Canada V4G 1H4
Greenfire
OWNER'S MANUAL
Freestanding Cast Iron
requirements in your area.
Do not store or use gasoline or other flammable
vapours and liquids in the vicinity of this or any other
appliance.
Installation and service must be performed by an
authorized installer or service agency.
GC60-2
®
Pellet Stove
French Manual: https://bit.ly/3v9xArf
Manuel en Français : https://bit.ly/3v9xArf
FOR YOUR SAFETY:
09.22.22

Advertisement

Table of Contents
loading

Related Manuals for HAMPTON BAY Greenfire GC60-2

Summary of Contents for HAMPTON BAY Greenfire GC60-2

  • Page 1 Greenfire GC60-2 ® OWNER’S MANUAL Freestanding Cast Iron Pellet Stove French Manual: https://bit.ly/3v9xArf Manuel en Français : https://bit.ly/3v9xArf PLEASE READ THIS ENTIRE MANUAL BEFORE INSTALLATION AND USE OF THIS PELLET-BURNING ROOM HEATER. FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN PROPERTY DAMAGE, BODILY INJURY OR EVEN DEATH. Contact your building or fire officials about restrictions and installation inspection requirements in your area.
  • Page 2 TO THE NEW OWNER Congratulations! You are the owner of a state-of-the-art Pellet Stove. Thank you for purchasing an FPI FIREPLACE PRODUCT. The pride of workmanship that goes into each of our products will give you years of trouble-free enjoyment. Should you have any questions about your product that are not covered in this manual, please contact the HAMPTON DEALER in your area.

  • Page 3: Table Of Contents

    Table of Contents Introduction..................4 Rating Label Location..............4 Fuel Quality................4 Safety Warnings & Recommendations............5 Operating Instructions................7 Dimensions & Specifications............7 Control Board Functions.............8 Automatic Safety Features of Your Pellet Stove......8 Operating Your Pellet Stove............9 Turning Your Pellet Stove Off............10 Slider/Damper Set-Up...............10 Routine Cleaning and Maintenance............11 Warranty...................14 Hampton GC60-2 Cast Pellet Stove Owner’s Manual...

  • Page 4: Introduction

    Introduction * This manual is designed for the home owner in conjunction with the technical manual. * ating abeL ocation The rating label is located on the inside of the rear hopper access cover. uaLity Fuel quality is important, please read the following: Your Hampton pellet stove has been designed to burn ¼”...

  • Page 5: Safety Warnings & Recommendations

    Safety Warnings & Recommendations Please read this entire Owner’s Manual before installing or operating your Hampton Pellet Stove. Failure to follow these instructions may result in property damage, bodily injury or even death. Any unauthorized modification of the appliance or use of replacement parts not recommended by the manufacturer is prohibited.
  • Page 6 Safety Decal This is a copy of the safety label that accompanies each GC60-2. We have printed a copy of the contents here for your reference. On the GC60-2 the safety label is located on the underside of the hopper lid. Sidewall Hampton GC60-2 Cast Pellet Stove Owner’s Manual...
  • Page 7 Safety Warnings & Recommendations ELECTRICAL: The use of a surge protected power bar is highly recommended. The unit must be grounded. The grounded electrical cord should be connected to a standard 110-120 volts (4.2 Amps), 60 hertz electrical outlet and also must be accessible. If this power cord should become damaged, a replacement power cord must be purchased from the manufacturer or a qualified Hampton dealer.
  • Page 8 Specifications imenSionS 23" (584mm) 3” Fresh Air Intake 4” Exhaust 28.7" (729mm) 29.4" 28" (748mm) (713mm) 31.7" (806mm) 4” Exhaust 28.4" 18.5" (722mm) (470mm) Figure 1: Dimensions of GC60-2. peciFicationS Input rating when using: Wood Pellets/Corn - 55,000BTU (16.1KW•hr) & Wheat/Barley - 53,000BTU (15.5KW•hr). Table 1: GC60-2 Specifications.

  • Page 9: Operating Instructions

    Operating Instructions ontRoL oaRd unctionS Note: The Control Panel is located underneath the units Cast Hopper Lid which is attached to a safety switch that will immediatley stop the auger. The switch will stop operation of the stove and display a #4 flash code if the lid is not closed within two minutes.

  • Page 10: Turning Your Pellet Stove Off

    Operating Instructions peRating eLLet tove THE UNIT WILL NOT OPERATE WITH THE DOOR OR ASH BOX OPEN. Open the hopper lid only to re-fuel or to adjust the controls. The unit will shut down if the hopper lid is left open for longer than two minutes. CAUTION: When operating during adverse weather, such as high winds or freezing rain, if the unit exhibits Premium Grade Pellets dramatic changes in combustion stop using the unit immediately.

  • Page 11: Slider/Damper Set-Up

    Operating Instructions • MANUAL and HI / LOW mode: To turn the unit OFF, simply press the ON / OFF button. This will stop the feed of pellets. The blowers will continue to operate and cool the stove down. When cool enough, the stove will turn off. • AUTO / OFF mode: To turn the unit OFF, turn the Thermostat down or Timer off.

  • Page 12: Routine Cleaning And Maintenance

    Routine Cleaning and Maintenance The following list of components should be inspected and maintained routinely to ensure that the appliance is operating at its optimum and giving you excellent heat value. The appliance, flue gas connector and the chimney flue require regular cleaning. Check them for blockage prior to re-lighting after a prolonged shut down period.
  • Page 13 Routine Cleaning and Maintenance 10. Set the fire grate in place, it should sit level on the front and back of the burn pot liner. Lock it in with the lever on the burn pot. 11. Close the door. Heat eXcHangeR tubeS (Weekly) The Heat Exchanger Tube’s Cleaning Rake Handle is located above the firebox door.
  • Page 14 Routine Cleaning and Maintenance EXHAUST PASSAGES (Biannually) Firebox Baffle 1. Open the firebox door by lifting the handle. 2. Remove the burn pot assembly Firebox Liner and clean all the parts. 3. Lubricate screws with penetrating oil. 4. Lift the baffle, remove the firebox Firebox Lower liner, and lift out the firebox lower.

  • Page 15: Warranty

    WARRANTY Limited Lifetime Warranty FPI Fireplace Products International Ltd. (for Canadian customers) and Fireplace Products U.S., Inc. (for U.S. customers) (collectively referred to herein as “FPI”) extends this Limited Lifetime Warranty to the original purchaser of this appliance provided the product remains in the original place of installation. The items covered by this limited warranty and the period of such coverage is set forth in the table below.
  • Page 16 WARRANTY Replacement units are limited to one per warranty term. Airtube and baffle replacements are limited to one replacement per term. Unit must be installed according to all manufacturers’ instructions as per the manual. All Local and National required codes must be met. The installer is responsible to ensure the unit is operating as designed at the time of installation.
  • Page 17 WARRANTY Limitations of Liability: The original purchaser’s exclusive remedy under this warranty, and FPI’s sole obligation under this warranty, express or implied, in contract or in tort, shall be limited to replacement, repair, or refund, as outlined above. IN NO EVENT WILL FPI BE LIABLE UNDER THIS WARRANTY FOR ANY INCIDENTAL OR CONSEQUENTIAL COMMERCIAL DAMAGES OR DAMAGES TO PROPERTY.
  • Page 18 WARRANTY Product Registration and Customer Support: Thank you for choosing a Regency Fireplace. Regency strives to be a world leader in the design, manufacture, and marketing of hearth products. To provide the best support for your product, we request that you complete a product registration form found on our Web Site under Customer Care within ninety (90) days of purchase.
  • Page 19 Hampton GC60-2 Cast Pellet Stove Owner’s Manual...
  • Page 20 Installer: Please complete the following information Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed: ______________________________________________________ Serial #: ____________________________________________________________ Printed in Canada Regency, Hampton and Greenfire are registered and / or proprietary trademarks of FPI Fireplace Products International Ltd. ©...

Table of Contents