Exploded View - SMA UTV-65-7 Owner's Manual

Maintenance During/After Spraying
Periodically check the strainer and clean the screen on your intake line.
Proper care and maintenance will prolong the life of your sprayer.
After use, fill the sprayer half way with clean water. Start the pump and
allow the water to pump through the entire plumbing system and
nozzles. Drain and then refill half full, add the recommended amount of
a good quality tank cleaner, such as FIMCO Tank Neutralizer and
Cleaner. (If no tank cleaner is available, you may substitute dish soap
for this step). Turn pump on and circulate through system for 15
minutes and then spray out through boom and handgun nozzles. Refill
sprayer half way with clean water and repeat. Follow the chemical
manufacturer's disposal instructions of all wash or rinsing water.
If boom or handgun nozzles need cleaning, remove them from the
sprayer and soak in warm soapy water. Clean with a soft bristled brush
or toothpick if necessary. Never use a metal object. Even the slightest
damage can change the flow rate and spray distribution. Water rinse
and dry the tips before storing.
Detail A

Exploded View

UTV-65-7 (5302830)
Detail B
WARNING:
allowed to soak untreated for a length of time! ALWAYS flush
the pump as instructed after each use. DO NOT allow chemicals
to sit in the pump for extended times of idleness. Follow the
chemical manufacturer's instructions on disposal of all waste
water from the sprayer.
Before storing your sprayer for winter or long term storage,
thoroughly clean and drain it as much as possible. Then pour enough
pink RV antifreeze into the tank so that when the pump is turned on
you can pump the antifreeze throughout the entire plumbing system,
including the bypass. Make sure to operate the boom and handgun
until you see pink fluid spraying from the nozzles. Leave any
remaining antifreeze in the tank. Before your next usage, rinse the
antifreeze from the sprayer with clean water.
It is nearly impossible to drain all of the water from the sprayer and
any trapped water can freeze in cold weather and damage parts of
the sprayer. Pumping the antifreeze through the system will displace
the water and help prevent this damage.
Detail A
Detail
B
Some chemicals will damage the pump valves if
Winter Storage
Page 5