Blue Seal EVOLUTION GPE506 Service Manual
  1. Manuals
  2. Brands
  3. Blue Seal Manuals
  4. Oven
  5. Evolution GPE506
  6. Service manual
Blue Seal EVOLUTION GPE506 Service Manual

Blue Seal EVOLUTION GPE506 Service Manual

Gas griddle range electric oven
Hide thumbs Also See for EVOLUTION GPE506:
Table of Contents

Advertisement

Quick Links

Download this manual
Gas Griddle Range
Electric Oven
G P E 5 0 6 / G P E 5 0 8
G P E 5 6 / G P E 5 8
S e r v i c e M a n u a l
Blue Seal Evolution Series Gas Griddle Ranges Electric Oven
© Moffat Ltd, July 2015
Amendment 7

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the EVOLUTION GPE506 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Related Manuals for Blue Seal EVOLUTION GPE506

Summary of Contents for Blue Seal EVOLUTION GPE506

  • Page 1 G P E 5 6 / G P E 5 8 S e r v i c e M a n u a l Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...
  • Page 2 ALL INSTALLATION AND SERVICE REPAIR WORK MUST BE CARRIED OUT BY QUALIFIED PERSONS WARNING: ONLY. IMPORTANT: MAKING ALTERATIONS MAY VOID WARRANTIES AND APPROVALS. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 3: Table Of Contents

    Contents Contents This manual is designed to take a more in depth look at the Blue Seal Gas Griddle Ranges Electric Oven for the purpose of making the units more understandable to service people. There are settings explained in this manual that should never require to be adjusted, but for completeness and those special cases where these settings are required to change, this manual gives a full explanation as to how, and what effects will result.
  • Page 4 Specifications Dimensions GPE506 / GPE56 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 5: Specifications

    Specifications Dimensions GPE508 / GPE58 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 6 The operating pressure is ex-factory set, through the appliance regulator and is not to be adjusted, apart from when carrying out gas conversion, if required. (Refer to the ‘Gas Conversion’ section for details). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...
  • Page 7 Gas supply connection point is located 130mm from the right hand side of the appliance, 32mm from the rear and 655mm from the floor and is entered from beneath the appliance. An optional underside connection is available. Connection is ¾” BSP male. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4...
  • Page 8 Refer to the appropriate wiring standards for the size of cable that is to be supplied to an appliance for the current drawn on that line. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015...
  • Page 9 Blue Seal Gas Griddles / Electric Oven Ranges are designed to provide years of satisfactory service and correct installation is essential to achieve the best performance, efficiency and trouble-free operation.
  • Page 10 (Refer to the ‘Specifications’ section for the gas supply location dimensions). NOTE: A Manual Isolation Valve must be fitted to the individual appliance supply line. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 11: Installation

    Ensure that the supply cable used is of a sufficient size for the current loading, refer to the 'Electrical Supply Requirements' in the ‘Specifications’ section. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015...
  • Page 12 If it is not possible to get the appliance to operate correctly, shut ‘Off’ the gas supply and contact the supplier of this appliance. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 13: Operation

    Position Elements Position HIGH Position Power Indicator Lamp (White) Oven Thermostat Control ๐ OFF Position Temperature Graduations 50°C to 320°C Fig 4 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 14: Maintenance

    Maintenance BLUE SEAL GAS GRIDDLE RANGE ELECTRIC OVEN - MAINTENANCE SCHEDULE Business Name and Address: Date: Service Report No. Phone: Fax: Serial No: Clients Order No. Serviceman:  Model: Remarks Inspect exterior condition of unit. Check door adjustment. Check working gas pressure correct to rating plate.

  • Page 15: Fault Finding Guide

    Pilot goes out when main burner comes on. Incorrect gas pressure. Check supply / adjust pressure. (Refer Specifications Section). Faulty gas control. Replace gas control. (Refer Service Section 6.2.11). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 16 Fan motor faulty. Replace fan motor. (Refer Fault Diagnosis 5.2.5). (Refer Service Section 6.3.8). Capacitor faulty Replace capacitor. (Refer Fault Diagnosis 5.2.6). (Refer Service Section 6.3.3). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 17: Fault Diagnosis

    - replace gas magnet. NOTE: Oven valves will require replacement if gas magnet is faulty. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 18 Close oven door and allow oven thermostat to regain temperature. If temperature overshoots by 50°C and continues to rise, switch ‘Off’ and replace thermostat. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 19: Service Procedures

    ALL INSTALLATION AND SERVICE REPAIR WORK MUST BE CARRIED OUT BY QUALIFIED PERSONS ONLY. WARNING: ENSURE SUPPLY IS SWITCHED OFF BEFORE COMMENCING SERVICING. ALWAYS TEST AFTER SERVICE REPAIRS. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 20: Access

    Control panel will drop down and out. Figure 6.2.1b Lift griddle plate off the unit. A second person may be required. Screw Figure 6.1.2 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 21: Griddle Burner Injector

    Griddle Plate Phial Locating Block. Alignment Holes, ‘Large’ - Overtemp, ‘Small’ - Thermostat. Figure 6.2.3 Figure 6.2.1d Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 22: Pilot Burner Injector

    6.1.1). Disconnect the thermocouple from pilot burner assembly. Undo the thermocouple from the rear of the gas control valve. Thermocouple Thermocouple wires Figure 6.2.6 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 23: Over-Temperature Thermostat (Uk Model Only)

    A small hole in the Jacking Screw burner box panel indicated the approximate position of the thermostat phial block. Figure 6.2.11a Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 24: Replacement - Oven

    Transfer wires from old capacitor to new capacitor. Undo screws securing capacitor to frame and remove capacitor. Replace and re-assemble in reverse order. 2 Screws Figure 6.3.1b Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 25: Energy Regulator

    Bottom Rear Element 25.6 Ohms. Push new neon in from front of control panel, and reconnect wires. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 26: Fan

    Before putting the control panel back on make sure that Three Screws microswitch is clicking on and off when opening and clos- ing the oven door. Figure 6.3.8 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 27: Oven Door

    Lift out door in a rising half circular motion similar to the orientation of the door when closing (refer to figures 6.3.10c, d, e). Figure 6.3.10e Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 28: Oven Door Hinges & Springs (Units Up To Lot No.0838999)

    Remove outer paneling by levering off with a screw driver. Tensioning Slacken this Screw if required Lever outer panel off base Figure 6.3.11f Figure 6.3.11c Remove spring from eyelet bolt and door hinge. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...
  • Page 29 If Door Pivot Pin will not sit flush in door frame, run a Ø12mm drill through hole. Only enlarge enough to make pivot pin a tight fit. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4...

  • Page 30: Oven Door Hinges & Springs (Units From Lot No.0839001)

    Rivets Rivets Self Tapping Screws Figure 6.3.12b Measure and note measurement from tensioning nut to end of threaded spline. Measure this Distance Figure 6.3.12c Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...
  • Page 31 Ensure that Door Pivot Shoulder Screws are fitted into door frames until shoulder of the pin is flush or below side of door frame. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4...
  • Page 32 Locking Pin Place protective material here. Figure 6.3.12j Refit oven door and remove locking rods and protective cardboard. Ensure that door operates correctly. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 33: Adjustment / Calibration

    2°C. should be replaced. Refit thermostat to rear of switch. Turn ‘On’ power and re-check thermostat calibration. Repeat procedure if necessary. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 34: Griddle Burner Aeration

    Main Burner Securing Bolt (on other side of Burner) Air Adjusting Bush Figure 6.4.5 Refit the griddle control panel (refer Section 6.1.1). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 35: Accessories

    Griddle Plate Standard Chromed (-C) Ribbed ON REQUEST, 900mm 229248 229270 Various options (depending on ribbed section width on LH or RH side). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 36 Door Assembly (All) ............................... 45 8.3.3 GPE506 / GPE508 Electrical Assembly (Static Ovens) ..................46 8.3.4 GPE56 / GPE58 Electrical Assembly (Convection Ovens) ................... 47 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 37: Exploded Parts Diagrams

    KNOB BSEAL 8mm 100-290°C 227508 PIEZO - SIT 228010 PIEZO HOUSING 228400 GREASE DRAWER WA 228173 SPLASHBACK ENDS 227960 BLUE SEAL BADGE Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 38: Gpe506 / Gpe56 Gas Assembly (Up To Lot No. 1114999)

    THERMOCOUPLE 450mm (NON - UK MODELS) 236265 THERMOCOUPLE INT LEADED (UK MODELS ONLY) 228531 REGULATOR (Natural Gas / LPG Gas [Propane]-Convertible) 3/4” BSP F/F, Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 39: Gpe506 / Gpe56 Gas Assembly (From Lot No. 1115000)

    Exploded Parts Diagrams 8.1.3 GPE506 / GPE56 Gas Assembly - From Lot No. 1115000) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 40 PILOT INJECTOR 0.25mm (LPG / PROPANE) 026393 PILOT INJECTOR 0.75mm (TOWN GAS) 019218 THERMOCOUPLE 450mm (NON - UK MODELS) 229885 THERMOCOUPLE 450mm (UK MODELS ONLY) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 41: Gpe508 / Gpe58 1200Mm Griddle

    GREASE DRAWER WA 227508 PIEZO - SIT 228010 PIEZO HOUSING 227381 KNOB BSEAL 8mm 100-290°C 228173 SPLASHBACK ENDS 227960 BLUE SEAL BADGE Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 42: Gpe508 / Gpe58 Gas Assembly (Up To Lot No. 1114999)

    PILOT INJECTOR 0.75mm (TOWN GAS) 019216 THERMOCOUPLE 450mm (NON - UK MODELS) 236265 THERMOCOUPLE INTERUPTED (UK MODELS ONLY) 228531 REGULATOR (Natural Gas / LPG Gas [Propane-Convertible) 3/4”BSP F/F, Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 43: Gpe508 / Gpe58 Gas Assembly (From Lot No. 1115000)

    Exploded Parts Diagrams 8.2.3 GPE508 / GPE58 Gas Assembly (From Lot No. 1115000) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 44 PILOT INJECTOR 0.75mm (TOWN GAS) 019218 THERMOCOUPLE 450mm (NON - UK MODELS) 236265 THERMOCOUPLE INTERUPTED (UK MODELS ONLY) 228531 REGULATOR (Natural Gas / LPG Gas [Propane-Convertible) 3/4”BSP F/F, Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 45: Electric Ovens

    OVEN SIDE RACK RH (From Lot No. 0817xxx) 227892 OVEN SIDE RACK LH 232355 OVEN BAFFLE UPGRADE KIT (From Lot No. 0817xxx) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 46: Door Assembly (All)

    DOOR HINGE KIT (INCLUDES 2 x ITEMS 15 & 16) - - - - - - PART OF 15 ABOVE 232819 COMPLETE DOOR ASSEMBLY 900mm Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 47: Gpe506 / Gpe508 Electrical Assembly (Static Ovens)

    KNOB BLUE SEAL 6mm 320-50°C 228922 NEON WHITE 229021 TERMINAL BLOCK 228941 TERMINAL BLOCK BRACKET 229145 SWITCH EGO 42-04400-008 229146 THERMOSTAT 55-34054-060 013989 REGULATOR EGO ENERGY Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 48: Gpe56 / Gpe58 Electrical Assembly (Convection Ovens)

    Exploded Parts Diagrams 8.3.4 GPE56 / GPE58 Electrical Assembly (Convection Ovens) Up to lot number 0816xxx From lot number 0817xxx Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...
  • Page 49 KNOB 6mm HI-4-3-2-1-LO (From Lot No. 0817xxx) 013989 ENERGY REGULATOR 240V 50HZ (From Lot No. 0817xxx) 232211 CONTROL PANEL DRIP GUARD KIT (Not Illustrated) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 50 Wiring Diagrams 9.1 Static Ovens (GPE506) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 51: Wiring Diagrams

    Wiring Diagrams 9.2 Convection Ovens (GPE56) Up to Lot No. 0816999 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 52 Wiring Diagrams 9.3 Convection Ovens (GPE56) From Lot No. 0817000 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 53: Circuit Schematics

    Circuit Schematics 10.1 Static Oven (GPE506) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 54 Circuit Schematics 10.2 Convection Oven (To Lot No. 0816999) 10.3 Convection Oven (From Lot No. 0817000) Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

  • Page 55: Service Contacts

    1800 551 8795 Winston-Salem 336 661 9546 NC27115 NATIONAL COVERAGE FOR SERVICE OR MAINTENANCE DIAL FREE CALL 866 673 7937 (USA ONLY). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...

  • Page 56: Appendix A: Gas Type Conversion

    Pilot Screw Low Fire Adjust NOTE: ‘Low Fire Screw’ should be sealed with coloured paint on completion of Screw low fire adjustment. Fig 11 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...
  • Page 57 Carry out a ‘Commissioning’ check of appliance as shown in Installation Section of this manual. Ensure any paint sealed components are re-sealed on completion of adjustments. Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015...
  • Page 58 The operating pressure is ex-factory set, through the appliance regulator and is not to be adjusted, apart from when carrying out gas conversion, if required. (Refer to the ‘Gas Conversion’ section for details). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...
  • Page 59 The operating pressure is ex-factory set, through the appliance regulator and is not to be adjusted, apart from when carrying out gas conversion, if required. (Refer to the ‘Gas Conversion’ section for details). Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 4 Amendment 7...
  • Page 60 GPE508 / GPE58 - UK Only Gas Type to Convert to Models Nat. Gas GPE506 / GPE56 232033 232032 GPE508 / GPE58 232037 232036 Blue Seal Evolution Series Gas Griddle Ranges Electric Oven © Moffat Ltd, July 2015 Amendment 7...

This manual is also suitable for:

Evolution gpe508Evolution gpe56Evolution gpe58

Table of Contents