Page 3
Because your purchase represents a substantial important information about features of your boat investment, we know you will want to take the and should be kept on board your Sea Ray necessary measures to protect its value. We have ®...
Page 4
Information in this publication is based upon the latest product specifications available at printing. Sea Ray Boats reserves the ® right to make changes at any time, without notice, in the colors, equipment, specifications, materials and prices of all models, or to discontinue models.
Icemakers (If Equipped) ........48 32. Canvas ..............48 This publication does not contain component or accessory manuals. Please visit www.searay.com for a library of Sea Ray Owner’s and Accessory Manuals. Sea Ray Boats DA_350_Book 1.indb 3 6/20/2017 9:04:38 AM...
NOTICE Contact state boating authorities or any marine Information which is important to proper operation or dealer for registration requirements. maintenance, but is not hazard related. Sea Ray Boats DA_350_Book 1.indb 5 6/20/2017 9:04:38 AM...
• U.S. Coast Guard Auxiliary that component. These are included with • U.S. Power Squadron your Owner’s Manual Packet. The Sea Ray ® Express Limited Warranty is on the warranty • Canadian Power and Sail Squadrons information sheet and in this manual. Please locate and read the individual warranties.
11. W arranTY nforMaTion Sea Ray advises that all rigging, installation, You will find information regarding the Sea Ray ® ® warranty following the introduction. A warranty and prep work on any Sea Ray product be ® information card is also included in the owner done by an authorized dealer at the authorized dealer’s location.
Page 10
The new owner can submit this request, free of charge, via the searay.com website or through a local authorized Sea Ray Dealer where processing fees may be applied. Sea Ray reserves the right to reject any warranty transfer request for a boat that has been damaged, neglected, or otherwise previously excluded from warranty.
Rotating propellers can injure or kill you. allowed under calm conditions. Shut off engine when persons are in water near Reduce boat loading if weather, water, or other boat, or on swim platform or ladder. conditions are adverse. Sundancer 350 DA_350_Book 1.indb 1 6/20/2017 9:04:38 AM...
• European Union – CE regulations provide water. Do not take chances! specific numbers for passenger capacity and cargo weight for all recreational vessels. Sundancer 350 DA_350_Book 1.indb 2 6/20/2017 9:04:38 AM...
Page 13
SHUT OFF ENGINE WHEN NEAR SWIMMERS boat when engines or generators are running. OR PRIOR TO USING SWIM PLATFORM AND Move to fresh air, if you feel nausea, headache, BOARDING LADDER dizziness, or drowsiness. 2027317 Sundancer 350 DA_350_Book 1.indb 3 6/20/2017 9:04:39 AM...
Page 14
Open flame appliances can ignite gasoline vapors ENGINES TO PREVENT SEA WATER causing death or injuries from the fire or explosion. INGESTION. Turn off all open flame appliances when refueling. V-Drive Option: Sundancer 350 DA_350_Book 1.indb 4 6/20/2017 9:04:39 AM...
Page 15
. 5.1) 1360 CE OPTION MEETS U.S. EPA EVAP STANDARDS USING CERTIFIED COMPONENTS SEA RAY BOATS, KNOXVILLE, TN. WARNING Carbon monoxide (CO) can cause brain damage or death. Engine and generator exhaust contains odorless and colorless carbon monoxide gas. Signs of carbon monoxide poisoning include nausea, headache, dizziness, drowsiness, and lack of consciousness.
MATERIALS THAT FLOAT “Garbage” does not include and does not include drainage fresh fish or fish parts, OUTSIDE 25 MILES from toilets, urinals, hospitals, dishwater, and gray water. and cargo spaces. PLASTICS Sundancer 350 DA_350_Book 1.indb 6 6/20/2017 9:04:40 AM...
Page 17
FORE AND AFT SUN PADS SHOULD NOT BE USED WHEN VESSEL IS UNDER WAY. DANGER STAY CLEAR OF MOVING PARTS. afety abel ocatIonS . 7.2) DANGER DO NOT CLIMB UPON OR STORE EQUIPMENT ON HARDTOP Sundancer 350 DA_350_Book 1.indb 7 6/20/2017 9:04:40 AM...
WITH WIDTH OF LIFT BATTERY TRIMMING LEVER CONTROL LEVER OPERATING SYSTEM TRIM SYMBOL) POINT OPERATION (THROTTLE & SHIFT) DIRECTION BOW DOWN WARNING FIRE NO OPEN FLAME ELECTRICAL WATER PUMP ACCESSORY RISK NO SMOKING HAZARD Sundancer 350 DA_350_Book 1.indb 8 6/20/2017 9:04:40 AM...
LED lights Do NOT have replacement bulbs. All lighting on board is LED with the following exceptions: Exterior • Navigational Lights (12V rated bulb) • Bilge Lights (fluorescent tube 15W) UTILITY LIGHT UNDERWATER LIGHT STEP LIGHT Sundancer 350 DA_350_Book 1.indb 20 6/20/2017 9:04:42 AM...
Page 31
LED lights Do NOT have replacement bulbs. All lighting on board is LED with the following exceptions: • Navigational Lights (12V rated bulb) • Bilge Lights (fluorescent tube 15W) TASK LIGHT STEP LIGHT Sundancer 350 DA_350_Book 1.indb 21 6/20/2017 9:04:42 AM...
Page 32
LED lights Do NOT have replacement bulbs. All lighting on board is LED with the following exceptions: • Navigational Lights (12V rated bulb) • Bilge Lights (fluorescent tube 15W) 12 VDC GFCI OUTLET Sundancer 350 DA_350_Book 1.indb 22 6/20/2017 9:04:42 AM...
YsTeM quippeD The V-drive system incorporates inboard engines The engines are the heart of your Sea Ray ® with an angled transmission that allows the drive Proper attention to and maintenance of your engines shaft to pass through the hull under the engine.
3. Move the joystick in the direction you want the vessel to move, or twist the joystick in the direction you want the vessel to rotate. Sundancer 350 DA_350_Book 1.indb 30 6/20/2017 9:04:44 AM...
YsTeM oyStIck peratIonS . 31.1) The exhaust system on Sea Ray boats with ® inboard engines is designed so that water from the raw water cooling system enters the exhaust system through risers where water and exhaust BOAT MOVES FORWARD are mixed.
If there are no visible signs of a problem, contact Your fuel tanks should be kept full of fuel your local dealer. whenever possible. This will reduce the amount of water condensation and reduce the possibility of contamination. Sundancer 350 DA_350_Book 1.indb 32 6/20/2017 9:04:45 AM...
Page 43
Sea Ray ® Periodically inspect for the presence of water in the Mercury or may not be ethanol-compatible.
Page 44
Primary and secondary fuel filters are located on your Sea Ray to help keep the fuel as clean ® as possible. The primary fuel filter is the Racor ®...
Page 45
. STARBOARD FUEL TANK . PORT ENGINE FUEL PICKUP . STARBOARD CARBON CANISTER . PORT FUEL TANK FILL WITH HEATSHIELD . PORT ENGINE FUEL FEED . GENERATOR FUEL FEED . STARBOARD ENGINE FUEL FEED Sundancer 350 DA_350_Book 1.indb 35 6/20/2017 9:04:45 AM...
Page 46
. GENERATOR FUEL RETURN . PORT FUEL VENT . STARBOARD FUEL RETURN . PORT FUEL TANK . STARBOARD ENGINE FUEL FEED . STARBOARD FUEL TANK FILL . STARBOARD FUEL PUMP/FILTER . GENERATOR FUEL FILTER Sundancer 350 DA_350_Book 1.indb 36 6/20/2017 9:04:45 AM...
. NOT USED . SUPPLY FROM SHORE . TO TRANSOM SHOWER . TO TRANSOM SHOWER . TO HEAD . TO HEAD . TO GALLEY . TO GALLEY . TO GALLEY . FROM WATER PUMP Sundancer 350 DA_350_Book 1.indb 37 6/20/2017 9:04:45 AM...
(40 CFR 140.3). Prior to each use and at regularly scheduled intervals, cycle the macerator seacock handle open and shut to ensure proper operation of the seacock. Sundancer 350 DA_350_Book 1.indb 41 6/20/2017 9:04:45 AM...
Page 52
. WASTE SYSTEM DECK PLATE . WASTE TANK VENT . VENT FILTER . HEAD VACUUM GENERATOR . HEAD . SEACOCK . THROUGH-HULL . WASTE LINE . WASTE SYSTEM HOLDING TANK . WASTE SYSTEM MACERATOR PUMP Sundancer 350 DA_350_Book 1.indb 42 6/20/2017 9:04:45 AM...
2. PULL HANDLE discharged. Under normal circumstances, when the ignition is ON the charge indicator light is ON. If the unit discharges, the light will go OFF. Located at the control panel Sundancer 350 DA_350_Book 1.indb 43 6/20/2017 9:04:46 AM...
The EOL signal can be reset for a period of 72 hours (3 days) for a total of up to 30 days. After this time, the unit will continuously signal EOL and will no longer detect CO and MUST BE REPLACED! Sundancer 350 DA_350_Book 1.indb 44 6/20/2017 9:04:46 AM...
Heater manual for control pad operation. Before using SmartCraft System View for the first REFER TO OWNER’S MANUAL PACKAGE FOR time, the system must be calibrated. INSTRUCTIONS AND WARRANTY INFORMATION. Sundancer 350 DA_350_Book 1.indb 45 6/20/2017 9:04:46 AM...
2. Turn ON the FRESH WATER PUMP breaker. 3. Turn ON icemaker switch, located at the bottom of the unit. Allow unit to cycle several times before using ice. REFER TO OWNER’S MANUAL PACKAGE FOR INSTRUCTIONS AND WARRANTY INFORMATION. Sundancer 350 DA_350_Book 1.indb 48 6/20/2017 9:04:46 AM...
DC accessories attached To prevent arcing or damage to the alternator, to the electrical system. always disconnect battery cables before doing any work on the engine’s electrical system. Sundancer 350 DA_350_Book 1.indb 49 6/20/2017 9:04:46 AM...
Page 60
Follow the charger instructions. Disconnecting the battery is not necessary if the boat is equipped with an on-board battery charger and the conditions mentioned above apply. Sundancer 350 DA_350_Book 1.indb 50 6/20/2017 9:04:46 AM...
(use only distilled water and no metal funnels) and use a silicone grease on the battery post terminals. Sundancer 350 DA_350_Book 1.indb 51 6/20/2017 9:04:47 AM...
With the engine key switches in the ON position, DC Distribution Panel, the Cabin Fuse Block, and the ACR isolates batteries if both battery voltages devices located in the bilge. drop below 12.25V for more than 30 seconds. Sundancer 350 DA_350_Book 1.indb 52 6/20/2017 9:04:47 AM...
Some of the various types of fuses and breakers that may be used on your boat are as follows: Sundancer 350 DA_350_Book 1.indb 53 6/20/2017 9:04:47 AM...
F i g . 54. 1 i s a c u r r e n t The 230 volt / 50Hz wiring installed on Sea Ray ® . 54.1) limiting MIDI type and if boats consists of three (3) color-coded wires. The blown must be replaced.
Page 65
A soiled cable can be cleaned with grease-cutting OFF MAIN and DOCK breakers. Disconnect power household detergent. A periodic application of vinyl cords. Consult dockmaster.) protector will help both ends and cable maintain their original appearance. Sundancer 350 DA_350_Book 1.indb 55 6/20/2017 9:04:47 AM...
Sea Ray strongly urges you to fully comply with the ® The following instructions cover only Sea Ray boats ® manual provided by the generator manufacturer. with a conventional hard wired electrical system. The generator is warranted separately by the 1.
AC power and switches between the inverter and charger modes. If AC power is available from the shore power connection or generator, the inverter passes that power to the connected Sundancer 350 DA_350_Book 1.indb 57 6/20/2017 9:04:47 AM...
Larger or additional anodes may be required for F O R O P E R AT I N G I N S T R U C T I O N S A N D proper protection. WARRANTY INFORMATION. Sundancer 350 DA_350_Book 1.indb 58 6/20/2017 9:04:47 AM...
Page 69
Sea Ray does not recommend ® that you attempt to work on the boat’s electrical system yourself. Instead, we recommend that you take your boat to your authorized Sea Ray dealer ® for service. Sea Ray reserves the right to change ®...
Page 70
THIS PAGE INTENTIONALLY LEFT BLANK DA_350_Book 1.indb 60 6/20/2017 9:04:47 AM...
Page 71
350 e undancer lectrical yStem dc W IrIng cHematIc . 61.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 61 6/20/2017 9:04:47 AM...
Page 72
350 e undancer lectrical yStem dc W IrIng cHematIc . 62.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 62 6/20/2017 9:04:47 AM...
Page 73
350 e undancer lectrical yStem dc W IrIng cHematIc . 63.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 63 6/20/2017 9:04:47 AM...
Page 74
350 e undancer lectrical yStem dc W IrIng cHematIc . 64.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 64 6/20/2017 9:04:47 AM...
Page 75
350 e undancer lectrical yStem dc W IrIng cHematIc . 65.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 65 6/20/2017 9:04:47 AM...
Page 76
350 e undancer lectrical yStem dc W IrIng cHematIc . 66.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 66 6/20/2017 9:04:48 AM...
Page 77
350 e undancer lectrical yStem dc W IrIng cHematIc . 67.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 67 6/20/2017 9:04:48 AM...
Page 78
350 e undancer lectrical yStem dc W IrIng cHematIc . 68.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 68 6/20/2017 9:04:48 AM...
Page 79
350 e undancer lectrical yStem dc W IrIng cHematIc . 69.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 69 6/20/2017 9:04:48 AM...
Page 80
350 e undancer lectrical yStem dc W IrIng cHematIc . 70.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 70 6/20/2017 9:04:48 AM...
Page 81
350 e undancer lectrical yStem dc W IrIng cHematIc . 71.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 71 6/20/2017 9:04:48 AM...
Page 82
350 e undancer lectrical yStem dc W IrIng cHematIc . 72.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 72 6/20/2017 9:04:48 AM...
Page 83
350 e undancer lectrical yStem dc W IrIng cHematIc . 73.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 73 6/20/2017 9:04:48 AM...
Page 84
350 e undancer lectrical yStem dc W IrIng cHematIc . 74.1) Warning: DO NOT attempt to work on the electrical system of this boat without professional assistance. Sundancer 350 DA_350_Book 1.indb 74 6/20/2017 9:04:48 AM...
Page 85
Engine Propulsion System ..........28 Macerator ..............40 This publication does not contain component or accessory manuals. Please visit www.searay.com for a library of Sea Ray Owner’s and Accessory Manuals. Index i Sea Ray Boats DA_350_Book 1.indb 1 6/20/2017 9:04:48 AM...
Page 86
Requirements ............. 40 Waste System Layout ........41 Water System ............36 This publication does not contain component or accessory manuals. Please visit www.searay.com for a library of Sea Ray Owner’s and Accessory Manuals. Index ii Sea Ray Boats DA_350_Book 1.indb 2...