Related Manuals for Little Wonder Optimax 9390-06-01
Summary of Contents for Little Wonder Optimax 9390-06-01
- Page 1 MODELS: 9390-06-01 CH440 KOHLER 9270-02-01 GX270 HONDA 9270-03-01 EX270 SUBARU 9270-06-01 CH395 KOHLER 9390-02-01 GX390 HONDA 9570-04-01 570 VANGUARD Owners Manual and Safety Instructions for OPTIMAX BLOWER...
- Page 2 CALIFORNIA PROPOSITION 65 WARNING: Cancer and Reproductive Harm - www.P65Warnings.ca.gov. ADVERTENCIA: Cáncer y Dãno Reproductivo - www.65Warnings.ca.gov. WARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. ADVERTENCIA El estado de California hace saber que los gases de escape de este producto con-...
-
Page 3: Table Of Contents
LITTLE WONDER BLOWER IMPORTANT MESSAGE This Operation / Part Manual provides the information necessary for safe and efficient operation and service. For your safety, it is important that you read and understand this entire manual before operating your equipment. This Operator’s Manual is part of the machine. Suppliers of both new and second-hand machines must make sure that this manual is provided with the machine. -
Page 4: Safety
LITTLE SAFETY WONDER BLOWER This symbol means: NOTICE !!! ATTENTION! Unauthorized modifications may present extreme BECOME ALERT! safety hazards to operators and bystanders and could also result in product damage. Your safety and the safety of others is involved. Schiller Grounds Care, Inc. strongly warns against, Signal word definitions rejects and disclaims any modifications, add-on accessories or product alterations that are not... - Page 5 LITTLE SAFETY WONDER BLOWER OPERATOR PREPARATION AND TRAINING SITE PREPARATION AND CIRCUMSTANCES – Read the operation manual. – Evaluate the terrain to determine what – Read the engine manufacturer’s owner manual. accessories and attachments are needed to properly and safely perform the job. –...
- Page 6 LITTLE SAFETY WONDER BLOWER OPERATION SAFETY GENERAL INTERRUPTING OPERATION Before leaving the operator's position: – Use extra care when loading or unloading the machine into a trailer or truck. - Park on level ground. - Reduce the throttle setting. – Do not run the engine in an enclosed area where - Shut off the engine.
- Page 7 LITTLE SAFETY WONDER BLOWER MAINTENANCE SAFETY - Do not smoke - Refuel outdoors only GENERAL - Use a funnel Maintain machine according to manufacturer's - Do not overfill schedule and instructions for maximum safety - If fuel is spilled, do not attempt to start the and best results.
- Page 8 LITTLE SAFETY WONDER BLOWER SAFETY DECALS An important part of the safety system incorporated in this blower are the warning labels found on the blower. Replace labels if damaged or illegible. WARNING WARNING ADVERTENCIA ADVERTENCIA Antes de comenzar: -Lea y entienda el manual del operador y las etiquetas.
-
Page 9: Set Up Instructions
LITTLE SET-UP INSTRUCTIONS WONDER BLOWER SET-UP INSTRUCTIONS Upper handle Blower housing FIGURE 1 1. Open box. Remove upper handle and cardboard insert. 2. Lay box down with blower housing up. Use lower handle to roll unit out of the box. 3. - Page 10 SET-UP INSTRUCTIONS LITTLE WONDER BLOWER SET-UP INSTRUCTIONS (continued) 7. Route the deflector cable above the axle and in front of the lower handle cross bar. Remove one of the nuts and the boot from the end of the deflector cable and install the cable through the key slot into the bracket on the upper handle.
-
Page 11: Controls
LITTLE CONTROLS WONDER BLOWER (BLOWER SHOWN WITH SUBARU EX40 ENGINE. Shown with Subaru EX40 engine OTHER ENGINES ARE SIMILAR.) SWITCH (A) Move to the “OFF” position to stop the engine. Move to the “ON” position before starting engine. Note: On Kohler engines, this SWITCH is incorporated in the FUEL SHUT-OFF (D) THROTTLE (B) Controls engine speed and the amount of air... - Page 12 LITTLE OPERATION / MAINTENANCE WONDER BLOWER OPERATION MAINTENANCE INSTRUCTIONS Stop engine and remove the spark plug wire before BEFORE STARTING THE ENGINE performing any maintenance. 1. Read the Operator Manual and Engine Manual. Become familiar with the controls, how each func- Keep blower air intake clear of debris for best tions, and what it operates.
-
Page 13: Adjustments
LITTLE ADJUSTMENTS WONDER BLOWER DEFLECTOR LEVER DEFLECTOR CHAIN If the deflector door moves from the set position dur- The sprocket needs to be installed on the deflec- ing operation, tighten the deflector lever pivot bolt just tor as shown. The chain consists of 2 master links, enough to keep the deflector in place. -
Page 14: Fan Removal And Installation
LITTLE FAN REMOVAL AND INSTALLATION WONDER BLOWER 5. Clean crankshaft internal threads with degreaser AVOID PERSONAL INJURY OR PROPERTY DAMAGE! STOP ENGINE, WAIT FOR ALL PARTS TO STOP Use compressed air and a clean rag to remove MOVING, DISCONNECT THE SPARK PLUG BEFORE degreaser and any metal fragments on internal PERFORMING ANY MAINTENANCE. - Page 15 Instruction Sheet – OPTIMAX FAN KIT (4166886, 4166887, 4166888, 4176410) LITTLE FAN REMOVAL AND INSTALLATION WONDER BLOWER 4178744 REV B ILLUSTRATED PARTS LIST: Instruction Sheet – OPTIMAX FAN KIT (4166886, 4166887, 4166888, 4176410) 4178744 REV B ILLUSTRATED PARTS LIST: Item Part No.
- Page 16 LITTLE INTAKE GUARD ASSEMBLY WONDER BLOWER ITEM PART NO. DESCRIPTION 4166183 LABEL-INTAKE GUARD 4165218.7 ASSY-GUARD INTAKE 64123-54 BLT-HEX 5/16-18X.75 64123-69 BLT-5/16-18 X 1 1/2 (USED ON 9570 MODEL ONLY) 64268-02 NUT-FL NYLON LOCK 5/16-18 64229-02 NUT 5/16-18 4165926.10 INTAKE PANEL-CENTER 4166997 RING-INLET OFFSET (USED ON 9570 MODEL ONLY)
-
Page 17: Engine Assembly
ENGINE ASSEMBLY LITTLE WONDER BLOWER ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 4166615 CABLE-PRE DEFLECTOR 64229-02 LOCKNUT-NYL 5/16-18 4164204 WHEEL-4.10/3.50 X 6 (QTY 6 ON 9570 MODEL) 64144-36 SNAP RING.625 64141-6 NUT 5/16-18 4164192-01 SPACER-PDR MTL 35X1.0X.25 4166074 ENG-HONDA GX270 4164178 AXLE (USED ON 9270-02 MODEL) -
Page 18: Housing Assembly
HOUSING ASSEMBLY LITTLE WONDER BLOWER USED ON 9570 MODEL ONLY ITEM PART NO. DESCRIPTION ITEM PART NO. DESCRIPTION 64141-6 NUT 5/16-18 4166614 CABLE-PUSH,POST DFLCTR 4166329 S-HOUSING LG BLOWER 4166615 CABLE-PUSH,PRE-DFLCTR 4166187 LABEL-BLOWER SIDE 4166324-02 BEARING-SLEEVE 4165975 LABEL-WARNING/DANGER 4166176 PIVOT-DEFLECTOR,INNER 910517 BLT-WLF 5/16-24 X 1-3/8 4166195 KNOB-1/4 FEMALE... -
Page 19: Warranty
Little Wonder products are warranted against defects in materials and workmanship for a period of Little Wonder products are warranted against defects in materials and workmanship for a period of time shown in the above table from the date of purchase from an authorized dealer by the original purchaser only, and under the following terms time shown in the above table from the date of purchase from an authorized dealer by the original and conditions. - Page 20 Operator’s Manual or other operational instructions provided by Schiller Grounds Care. Improper Use - This limited warranty does not cover any Little Wonder Product, part, or accessory that (i) has been subject to misuse, abuse, neglect, negligence, or accident, or that has not been assembled, operated, or maintained in accordance with the operating or maintenance instructions specified in the Operator’s Manual;...
Need help?
Do you have a question about the Optimax 9390-06-01 and is the answer not in the manual?
Questions and answers