Table of Contents
Advertisement
Quick Links
• Powerful 2kW heating output
• Efficient diesel burner technology
• 4.25L diesel tank
• Up to 7 days of typical usage – based on
4hrs use per day, on power level 2-3
• Low 12V DC power usage
• Suitable for heating tents, camper trailers
and small caravans.
PORTABLE
DIESEL HEATER
Important: Retain these instructions for future use.
Gasmate ® is a registered trademark of:
Sitro Group Australia Pty Ltd www.gasmate.com.au
Aber Living Ltd, N.Z www.gasmate.co.nz
Model No. DH203
04436 08/22
Advertisement
Table of Contents
Related Manuals for Gasmate DH203
Summary of Contents for Gasmate DH203
- Page 1 • Low 12V DC power usage • Suitable for heating tents, camper trailers and small caravans. Important: Retain these instructions for future use. Gasmate ® is a registered trademark of: Sitro Group Australia Pty Ltd www.gasmate.com.au Aber Living Ltd, N.Z www.gasmate.co.nz 04436 08/22...
-
Page 2: Read Me First
READ ME FIRST IMPORTANT NOTES • DO NOT store or use petrol or other flammable This appliance is not intended for use by persons liquids in the vicinity of this or any other (including children) with reduced physical, sensory appliance. or mental capabilities, or lack of experience and knowledge, unless they have been given supervision •... -
Page 3: Included Accessories
HEATER UNIT AND SETUP CARRY HANDLE FUEL FILLER CAP HOT AIR OUTLET CONTROLLER VENTILATION GRILL AIR INTAKE (REAR OF UNIT) EXHAUST OUTLET REMOTE CONTROL INCLUDED ACCESSORIES • Hot air ducting – 1m long (not shown) • 12V DC connection cable – 1m long (not shown) •... -
Page 4: Recommended Clearance
CLEARANCE & INSTALLATION RECOMMENDED CLEARANCE IMPORTANT CONSIDERATIONS The heater MUST be plugged into a 12V DC supply with Minimum Clearances from combustible materials must be: AT LEAST 15A capacity to operate properly. It CANNOT Front 200mm operate from a standard 10A car cigarette socket. When Rear 200mm choosing a location for the heater:... -
Page 5: Control Panel
OPERATING INSTRUCTIONS CONTROL PANEL ICON DESCRIPTIONS Heat level Temperature control mode control mode Input power Heater operating connected Stand by Fuel pump Temperature Glow plug sensor Fan operating Timer High altitude Error mode BUTTON FUNCTIONS Power Turns the unit ON and OFF STANDBY Increases the selected value When the heater is OFF and connected to DC power,... -
Page 6: Starting The Heater
PRIMING THE FUEL SYSTEM (first use only) To enable the heater to start easier on the first WARNING occasion after the fuel tank is filled, the fuel pump can be activated without starting the heater to feed the fuel If the combustion chamber becomes flooded, some into the fuel lines. - Page 7 OPERATING MODE – HEAT LEVEL OPERATING MODE – TEMPERATURE CONTROL In this mode ( ) the heater is controlled at one In this mode ( ) the heater is controlled based on of 6 levels – 1 being the lowest fan speed and heat the difference between the set temperature and the output, 6 being the maximum fan speed and heat output.
-
Page 8: High Altitude Mode
HIGH ALTITUDE MODE 3. Press any button on the remote control to send a signal to the controller to pair with it. When the heater is to be used in areas of high altitude 4. Press the SELECT ( OK ) button to confirm and exit for prolonged periods of time (at over 1500m above sea the pairing mode. -
Page 9: Troubleshooting
TROUBLESHOOTING ERROR CODE CAUSE ACTIONS Supply voltage is detected outside range (9-16V). Over-voltage • Check battery charge level and condition • Check fuse condition and connection Under-voltage • Check cable condition and for excessive voltage drop. • Contact service support to arrange inspection or replacement Glow plug failure of the glow plug. -
Page 10: Technical Data
TECHNICAL DATA MODEL DH203 Maximum Heating Output 2 kW Operating Temperature -40 to +50°C Standard mode Up to 1500 m above sea level Operating Altitude Altitude mode Over 1500 m above sea level Operating Voltage 12 V DC (9-16V) At start-up (with glow plug on) - Page 11 DIAGRAMMATIC REPRESENTATIONS OF OUTDOOR AREAS The following figures are diagrammatic representations of outdoor areas. Rectangular areas have been used in these figures – the same principles apply to any other shaped area. Important: Retain these instructions for future use.
- Page 12 For any queries or assistance call Customer Service (Australia Only) 1300 174 876 Hours of operation: Monday to Friday 8am - 5pm EST Do not return to place of purchase. Keep your purchase receipt, this will be required to make any claims under the 1 year warranty.