Subscribe to Our Youtube Channel
Related Manuals for Pentair Myers WHR Series
Summary of Contents for Pentair Myers WHR Series
- Page 1 WHR/WHRH/WHRE SERIES SUBMERSIBLE SEWAGE PUMPS INSTALLATION AND SERVICE MANUAL NOTE! To the installer: Please make sure you provide this manual to the owner of the equip ment or to the responsible party who maintains the system.
-
Page 2: Installation
GENERAL DESCRIPTION AND USES The grounded receptacle cannot be used in the wet sump or basin due to DANGER of current leakage. The WHR Series are solids handling pumps that can be used to pump RAW SEWAGE for COMMERCIAL Sealed junction boxes must be used in wet sumps and DOMESTIC use, but are not intended to handle or basins to make connections to motor cord. - Page 3 If raw sewage must be pumped in the home, use cover, power cord is brought through a split rubber outside basins that connect with pressure sewer plug in the basin cover. mains or gravity sewers, or run to septic tanks. 2.
-
Page 4: Troubleshooting
CAUTION! Risk of electric shock. Do not 3. Plug the pump power cord into the back of the switch cord series plug. remove cord and strain relief. Do not connect conduit to pump. 4. Tape the cords to the discharge pipe every 12". 2. - Page 5 2. Pump runs but does not deliver flow. d. Pump inlet may be plugged. Remove pump to check. a. Check for airlock. Start and stop pump several times. If this does not help it may be necessary e. Level control ball or weight may be stuck on side to loosen a union in the discharge line to relieve of basin.
- Page 6 TYPICAL SECTION DRAWING 23833A551 11/08/12...
- Page 7 REPAIR PARTS LIST SINGLE SEAL REPAIR PARTS LIST WHRH SERIES Ref. Ref. Req'd Req'd Description Part No. Description Part No. Cord, Power See Chart 14 Impeller, DI (std. series) See Chart Housing, motor 25327D000 15 Screw, Machine #10 x 3/8 06106A042 Washer, Bearing 19331A005...
-
Page 8: Performance Curves
CAPACITY LITERS PER MINUTE PERFORMANCE CURVES WHRE SERIES CAPACITY GALLONS PER MINUTE CAPACITY LITERS PER MINUTE 1000 1100 PERFORMANCE CURVES WHRH SERIES CAPACITY GALLONS PER MINUTE CAPACITY LITERS PER MINUTE PERFORMANCE CURVES WHR SERIES CAPACITY GALLONS PER MINUTE 23833A551 11/08/12... - Page 9 PUMP IN SEPARATE TANK PUMPING TO SEEPAGE MOUND ALARM AND POWER CORDS TO POWER SOURCE AWS-1 CONTROL AWS-1 CONTROL MOUND TYPE SEEPAGE BED STORAGE CAPACITY SEWER LINE IN CASE OF PUMP FROM HOUSE FLCW OR POWER FAILURE ALARM CONTROL SCUM TURN ON LEVEL LIFT-OUT GUIDE RAIL...
- Page 10 PUMP IN FIBERGLASS BASIN AT OUTLET OF SEPTIC TANK WHEN PUMPING INTO PRESSURIZED SEWER MAIN OR LEACH FIELD ALARM CABLE POWER CABLE AWS-1 CONTROL MOUNTS ON BRACKET. ACCESSIBLE FOR SERVICE SLUDGE CLEAN OUT TILE BURIED CABLE TO POWER SUPPLY AWS-1 CONNECTION BOX AND SEALED LEVEL CONTROL VENT PIPE 24”...
- Page 11 PUMP AND CONTROLS IN SEPTIC TANK WHEN PUMPING INTO PRESSURIZED MAIN OR LEACH FIELD ALARM CABLE AWS-1 CONTROL MOUNTS ON POWER BRACKET. ACCESSIBLE FOR SERVICE CABLE SLUDGE CLEAN OUT TILE 24” DIA. FIBERGLASS BASIN BURIED CABLE TO POWER SUPPLY AWS-1 CONNECTION BOX AND SEALED LEVEL CONTROL FLCW - HIGH WATER ALARM CONTROL...
-
Page 12: Standard Limited Warranty
STANDARD LIMITED WARRANTY Myers warrants its products against defects in material and workmanship for a period of 12 months from the date of shipment from Myers or 18 months from the manufacturing date, whichever occurs first - provided that such products are used in compliance with the requirements of the Myers catalog and technical manuals for use in pumping raw sewage, municipal wastewater or similar, abrasive free non-corrosive liquids.
Need help?
Do you have a question about the Myers WHR Series and is the answer not in the manual?
Questions and answers