Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for TRU-BLU Petbarn K9000 Lite
Summary of Contents for TRU-BLU Petbarn K9000 Lite
- Page 1 K9000 Lite (K9L) Operators Manual © Copyright 2016, Tru Blu Dog Wash, All rights reserved. K9000 ® is a registered trademark of Tru Blu Dog Wash. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page i © Tru Blu Dog Wash 2016...
- Page 2 Atlantic Industries - Tru Blu Dog Wash Factory No. 1, 34 Caramut Road Warrnambool Victoria 3280 Australia Tel: 03 55629088 Fax: 03 55629022 Email: info@trubludogwash.com.au Website: www.trubludogwash.com.au www.findadogwash.com Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page ii © Tru Blu Dog Wash 2016...
- Page 3 New ES Pumps 4 Various sections General Safety Version V4.0 Status Published Date 09/06/2020 Author/s Phil Worrell Build Approver Darryn Polak Sales Approver Dale Beaton Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page iii © Tru Blu Dog Wash 2016...
-
Page 4: Table Of Contents
Clearing a Note Jam....................28 Troubleshooting .....................30 Temperature Valve ......................31 Temperature Adjustment ..................31 Dryer ..........................32 Non Heated Dryer Details ..................32 Heated Dryer ......................33 8.2.1 Heated Dryer Settings ..................33 Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page iv © Tru Blu Dog Wash 2016... - Page 5 14.3 Material Safety Data Sheet (MSDS) Fido’s Fre-Itch Rinse Concentrate ....48 14.4 Material Safety Data Sheet (MSDS) Fido’s Hydrobath Flush ........48 Maintenance Record ....................49 Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page v © Tru Blu Dog Wash 2016...
-
Page 6: Petbarn K9L Inspection And Acceptance On Delivery
It is also recommended that the white film protecting the unit is not removed until after install as this will help prevent any installation damage. Z:\Build\Petbarn K9000 Lite\Petbarn K9000 Lite Operators Manual June 2020 v4.0.docx Page 1 © Tru Blu Dog Wash 2016... -
Page 7: Installation
ENSURE all doors open and close freely before securing the K9000L! Once the K9000L is level, use dyna plugs to secure the K9000L to the ground. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 2 © Atlantic Industries 2016... -
Page 8: Connecting The Water Supply And Waste Connection To The K9000L
If adjustment required, you will need adjust the regulator. The regulator is adjusted using a screw driver, where pressure needs to be increased turn the screw anticlockwise and to decrease pressure turn in a clockwise direction. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 3 © Atlantic Industries 2016... -
Page 9: Hot Water Breaker
The power must be isolated prior to removing the cover from the Control Module refer to section 4 Main Board Components. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 4 © Atlantic Industries 2016... -
Page 10: Connecting The Waste
Before connecting to the waste point or tundish ensure local regulations are considered as some sites may require copper pipe. Waste point If unsure with any of the above steps please phone (03) 5562 9088 for assistance. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 5 © Atlantic Industries 2016... -
Page 11: Connecting The Power - For Your Electrician
1000mm for the termination inside the dog wash. Water Inlet 370mm Expansion Valve outlet 25mm Flex Conduit Electrical Cable Entry Point of Dog Wash Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 6 © Atlantic Industries 2016... -
Page 12: Completing The Installation
Refer section 2.2.1 re regulation of water pressure. water temperature, should be cool at a 40cm distance from the wash gun, refer section 7.1 for water temperature adjustment. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 7 © Atlantic Industries 2016... -
Page 13: Main Board Components
Hot water breaker is left in the off position from Factory. Ensure hot water system has been filled with water before switching on. Refer to section 2.2.2 Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 8 © Atlantic Industries 2016... -
Page 14: Product Dosing Pump Settings (Iwaki Es Series Pumps)
Tub disinfectant: Flea shampoo: 40% (if applicable) To adjust settings, rotate the ‘stroke rate’ dial to the recommended percentages as above. ‘Stroke Rate’ Dial Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 9 © Atlantic Industries 2016... -
Page 15: Bleeding Product Dosing Pumps (Iwaki Es Series Pumps)
NOTE: After pump has been bled, there will be a distinctive change in the sound of the pump (pump will sound quieter). If there are problems bleeding heavier concentrates rattle the suction line (item C below). Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 10 © Atlantic Industries 2016... -
Page 16: Iwaki Dosing Pump - Exploded View (Iwaki Es Series Pumps)
4.1.3 Iwaki Dosing Pump – Exploded View (Iwaki ES Series Pumps) Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 11 © Atlantic Industries 2016... -
Page 17: Main Backboard With Iwaki Ej Series Pumps
Hot water breaker is left in the off position from Factory. Ensure hot water system has been filled with water before switching on. Refer to section 2.2.2 Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 12 © Atlantic Industries 2016... -
Page 18: Product Dosing Pump Factory Settings (Iwaki Ej & Es Series Pumps)
This will reset the SPM to 1, you can then increase to the required SPM rate. Once the required rate is reached press the start/stop button twice to save the required rate. ‘Stroke Rate’ ‘Start / Stop’ Button Button Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 13 © Atlantic Industries 2016... - Page 19 SPM as it has both up and down buttons. Once the rate is displayed it is saved. ‘Increase Stroke Rate’ Button ‘ Decrease Stroke Rate’ Button ‘On / Off Button Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 14 © Atlantic Industries 2016...
-
Page 20: Bleeding Product Dosing Pumps (Iwaki - Ej Or Es Series Pumps)
If there are problems bleeding heavier concentrates rattle the suction line (item C below), and/or squeeze it to assist with shifting the product up into the pump head. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 15 © Atlantic Industries 2016... -
Page 21: Iwaki Dosing Pump Exploded Views
4.2.3.1 Iwaki Dosing Pump – EJ Series Exploded View The pump in the diagram below is completely dismantled. Do not dismantle the pump beyond the extent shown in this instruction manual. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 16 © Atlantic Industries 2016... - Page 22 4.2.3.2 Iwaki Dosing Pump – ES Series Exploded View The ES Series pump in the diagram below is completely dismantled. Do not dismantle the pump beyond the extent shown in this instruction manual. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 17 © Atlantic Industries 2016...
-
Page 23: Approved Products
The use of non-approved products may be harmful to the dog. Damage may also be caused to the Tru Blu dog wash equipment and possible voiding of the unit’s warranty. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 18... -
Page 24: Cash Box Components
5.1 Cash Box with Note Reader LED 6 Coin Acceptor Timer/Display Override Key Warning Beeper Rotary Switch Interface Board Note Acceptor Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 19 © Atlantic Industries 2016... -
Page 25: Cash Box With Card Reader
5.2 Cash Box with Card Reader LED 6 Timer/Display Coin Acceptor Warning Beeper Override Key Valve Board Interface Board Rotary Switch Interface Board MDB Nayax Cable Petbarn EFTPOS / CC Controller Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 20 © Atlantic Industries 2016... -
Page 26: Coin Acceptor - Coin Activation
Light Button Service agent refer to - Microsystems Controls Pty Ltd Unit 6, 11 Robertson Place South Penrith NSW 2750 Ph. +61 2 4731 6655 sales@microcoin.com Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 21 © Atlantic Industries 2016... - Page 27 This is the credit multiplier, Number 1 = 1 pulse = $1 If programming a Token to = $10, press button until Display shows “0” Press & Hold Button, LED will go steady GREEN Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 22 © Atlantic Industries 2016...
-
Page 28: Coin Acceptor - Removal
With bracket down, the coin acceptor will slide from its mount. Disconnect the small ribbon cable from the interface board as shown on right. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 23 © Atlantic Industries 2016... -
Page 29: Coin Acceptor Cleaning
Do not use harsh detergents. Once the unit has been cleaned, it is a simple case of re-inserting the unit in the reverse order that was shown on previous page. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 24 © Atlantic Industries 2016... -
Page 30: Note Acceptor (Gba St1C)
Below is the table to reference when trying to determine what fault the note acceptor has. The table is found on the back of the note acceptor magazine. Indicator light The note acceptor diagnostics table Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 25 © Atlantic Industries 2016... -
Page 31: Cassette Fitting / Removal
Grey buttons are on each side of the cassette, pressing both allows the lid to be opened and access to notes View of note cassette removed from GBA ST1C Body Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 26 © Atlantic Industries 2016... -
Page 32: Cleaning The Validator Note Path
Channel. 10. Re-connect the external cables. 11. Re-fit the Cassette. 12. The supply to the unit can now be switched ON. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 27 © Atlantic Industries 2016... -
Page 33: Clearing A Note Jam
4. Clear the jammed note(s) from the note path. 5. Re-assemble unit and switch the power supply back ON. Purple central tab at bottom of plate Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 28 © Atlantic Industries 2016... - Page 34 Bottom sensor slide away from cassette View of sensor position within cassette. Back of GBA ST1C with both cassette and sensor slide removed Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 29 © Atlantic Industries 2016...
-
Page 35: Troubleshooting
GBA Talk to select required interface. 2. Poor electrical 2. Interface and 18-way connection(s). cable assemblies. 2. Ensure Interface and 18-way cable are connected firmly and correctly. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 30 © Atlantic Industries 2016... -
Page 36: Temperature Valve
NOTE: Temperature will change with the slightest adjustment. Care should be taken not to over-adjust. If in doubt check water temperature with a thermometer and DO NOT EXCEED 38 Celsius. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 31 © Atlantic Industries 2016... -
Page 37: Dryer
8 Dryer The Petbarn K9000 Lite can come with either a non-heated (standard) or heated dryer. Non Heated Dryer Details The standard K9000L dog wash comes with a fully fitted 2x1100 dryer. It does not require any action as part of the installation process. -
Page 38: Heated Dryer
Heated Dryer The Petbarn K9000 Lite dog wash, if requested can come equipped with an adjustable blower heat setting for drying dogs. 8.2.1 Heated Dryer Settings The K9000 dog wash comes equipped with an adjustable blower heat setting for drying dogs. -
Page 39: Dryer Hose Connection
8.3 Dryer Hose Connection Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 34 © Atlantic Industries 2016... -
Page 40: Override Key (Wash Down Key)
During this wash down function, all selections on the rotary dial are available except the dryer. This wash down function is not to be used for washing dogs. Remove key after wash down is complete. Turn Key to activate Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 35 © Atlantic Industries 2016... -
Page 41: Led 6 Operating And Programming Instructions
Timing starts as soon as start price is reached. K9000 set to Delayed Start Length of warning horn is seconds at one minute of time remaining. [10] Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 36 © Atlantic Industries 2016... - Page 42 Standard message and prompt is displayed in Spanish. E & S Standard message and prompt is displayed in English then displayed in Spanish. K9000 set to Standard Settings EXIT Timer returns to standby. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 37 © Atlantic Industries 2016...
-
Page 43: Floor Lifting Tool
If you wish to wear rubber gloves, ensure that you wear a pair of “rigger” gloves as well (double glove). Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 38 © Atlantic Industries 2016... -
Page 44: Operator Maintenance
Check dog restraints in the tub (chains, attachments & fittings). Check tub door latch. Flush drains, refer to cleaning section for instructions. Empty product overflow bucket. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 39 © Atlantic Industries 2016... - Page 45 Check each of the dryer clamps, tighten as necessary. Check dryer hose swivel. Replace Wash Gun. Check wash gun hose assembly, replace if necessary. Replace Dryer hose assembly. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 40 © Atlantic Industries 2016...
- Page 46 The Daily, Monday & Friday, Weekly and Monthly maintenance schedules could all be due and occur on the same day. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 41 © Atlantic Industries 2016...
-
Page 47: External Maintenance Items
The rotary dial should be checked each month to ensure it has not become loose. If it is found to be loose, use an allen key to tighten the screw that holds it in place. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 42... -
Page 48: Dryer Maintenance
Please note heated dryers only have the one clamp but have a screw that needs to be tightened. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 43 © Atlantic Industries 2016... -
Page 49: Cleaning
Warning the stainless-steel filter can have sharp edges, “rigger” gloves need to be worn to protect against injury. If required, you can wear rubber gloves underneath the “rigger” gloves. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 44 © Atlantic Industries 2016... - Page 50 Rotary dial set Wash Gun to Rinse Set to Jet Place the wash gun in the drain press on button, you don’t need to hold the gun place Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 45 © Atlantic Industries 2016...
- Page 51 Clean the stainless steel by wiping down with soft cloth and INOX or WD40 spray. Do not use abrasive cleaning products and wipe down in the direction of the brushed finish. Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 46 © Atlantic Industries 2016...
-
Page 52: General Information
How to program the Timer on your Dog Wash How to Program the tokens on your Dog Wash How to change the soap on the K9000 Dog Wash Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 47 © Atlantic Industries 2016... -
Page 53: Msds Attachments
14.3 Material Safety Data Sheet (MSDS) Fido’s Fre-Itch Rinse Concentrate TB-MSDS-029 Fido's Fre-Itch Rinse Concentrate Summary.pdf 14.4 Material Safety Data Sheet (MSDS) Fido’s Hydrobath Flush TB-MSDS-028 Fido's Hydrobath Flush Summary.pdf Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 48 © Atlantic Industries 2016... -
Page 54: Maintenance Record
The following record of maintenance needs to be completed at the time maintenance occurs. This will assist with any warranty claim. Maintenance Date of Initials Comments Schedule Maintenance Petbarn K9000 Lite Operators Manual June 2020 v4.0 Page 49 © Atlantic Industries 2016...
Need help?
Do you have a question about the Petbarn K9000 Lite and is the answer not in the manual?
Questions and answers