Atmospheric above-ground pool & spa heater (chauffe-piscine) (40 pages)
Summary of Contents for Raypak RP-045
Page 1
OPERATION MANUAL Raypak Indirect Pool Heaters Model Series RP-045 through RP-995 and B Ti-180 through B Ti-500 WARNING: If these instructions are not followed exactly, a fire or explosion may result causing property damage, personal injury or death FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors and liquids or other combustible materials in the vicinity of this or any other appliance.
Page 2
Rev. 5 reflects the following: Table A: Added "Model Number column". Changed row heading from "CR24" to "Ti". Table C: Added information rows for: RP-185, RP-305 & RP-495.
TABLE OF CONTENTS 1. WARNINGS ............. 4 Pay Attention to These Terms ......... 4 Caution ..............4 2. WATER CHEMISTRY ..........5 3. INSTALLATION GUIDELINES ......7 Plumbing ..............7 Flow................. 7 Controls ..............8 Chemical feeders or salt water generators ..... 8...
1. WARNINGS Pay Attention to These Terms Indicates the presence of immediate hazards which will cause severe personal injury, death DANGER or substantial property damage if ignored. Indicates the presence of hazards or unsafe practices which could cause severe personal WARNING injury, death or substantial property damage if ignored.
2. WATER CHEMISTRY (Corrosive water causes damage that will not be covered under warranty.) For your health and the protection of your pool equipment, it is essential that your water be chemically balanced. The following levels must be used as a guide for balanced water. Recommended Level(s) Fiberglass Pools Fiberglass Spas...
Page 6
** Titanium - widely used in industrial salt water environments. Due to its unsurpassed corrosion resistance, this unique super alloy option is a ‘true’ salt water product, now available from Raypak for the most demanding of applications, from high chlorination to high salt content.
Sample Installation Diagram TO BOILER CONTROL Indirect Pool Heater BOILER WATER FLOW Gate valve Check valve POOL WATER FLOW Flow switch Thermostat or Aquastat Thermometer Drain valve Filter Pool/Spa Pump BOILER WATER FLOW POOL WATER FLOW Bypass valve Union Boiler Pump NOTE: Damage to the Indirect Pool Heater due to improper water chemistry is not covered under the warranty Chlorine feeder must be installed after (downstream of) the Indirect Pool Heater and be installed with an...
Page 9
Applicable Warranty Period. In accordance with the terms of this Limited Warranty, Raypak will, at its option, repair or furnish a replacement for any defective part of the HEATER if it fails in normal use and service during the Applicable Warranty Period.
Page 10
Warranty is VOID if the product is repaired or altered in any way by ANY persons or agencies other than those authorized by Raypak. Raypak reserves the right at all times to inspect, or require the return of, the defective product or component part and to verify warranty coverage at its factory.
Page 11
ISO 9001 REGISTERED QUALITY MANAGEMENT SYSTEM www.raypak.com Raypak, Inc., 2151 Eastman Avenue, Oxnard, CA 93030 (805) 278-5300 Fax (805) 278-5468 Litho in U.S.A.