Page 1
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER ® WARNING! Read this Operator’s Manual carefully before using this machine. Failure understand and follow the contents of this manual may result in electrical shock, re and/or serious personal injury. READ CAREFULLY...
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Table of Contents Safety Symbols General Power Tool Safety Warnings Work Area Safety Personal Safety Service Water Jetter Safety Description, Speci cations And Standard Equipment Description Speci cations Standard Equipment Machine Assembly...
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Safety Symbols In this operator’s manual and on the product, safety symbols and signal words are used to communicate important safety information. This section is provided to improve understanding of these signal words and symbols.
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Water Jetter Safety • Engines produce carbon monoxide, a colorless, odorless poison gas. Breathing carbon monoxide can cause nausea, fainting or death. Do not start and run WARNING engine in an enclosed area, even if doors and windows are open.
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Description, Speci cations and Standard equipment Description The Jetwave Typhoon Hot G2 Engine Powered Water ® ™ Jetting Machine is a portable high pressure hot water water jetter designed to use a combination of water pressure, heat and ow to clear grease, sludge, sediment and roots out of drains.
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER The machine serial number is located on the frame. The 1. Make sure that the battery isolator (if applicable) and rst letter & digits indicate the year and month of the engine switch is in the OFF position.
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER 4. Inspect the jetter nozzle ori ces for any damage or the sight glass and add oil if needed (see Maintenance blockage. CAUTION: In case of a nozzle blockage Instructions section). Inspect Engine as directed in the never attempt to clean nozzle while high pressure line engine operator’s manual.
5. Evaluate the work area and determine if any barriers are needed to keep bystanders away. Bystanders The Typhoon Hot G2 is equipped with two hose reels, a can distract the operator. If working near traf c, erect primary reel mounted to the jetter frame and the remote cones, signs or other barriers to alert drivers.
Page 9
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER 1. Water Control Valve. Choose the valve to be used to control water ow. If using a foot valve to control water ow, route a hose from the jetter pump to the IN tting on the foot valve.
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Operating Instructions 3. Ensure fuel valve is in the OPEN position before starting the machine, when not in use CLOSE the fuel valve as pictured below. CAUTION 4. Turn the Battery Isolator switch ON and con rm the Emergency Stop button is in the out position (rotate button clockwise) (Figure 11).
Page 12
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER 6. If needed, turn the unloader valve while monitoring the When jetting a drain, typically the hose is fed into the drain pressure gauge on the unloader valve to adjust the the full distance to be cleaned and slowly pulled back. This...
OFF. When the trigger is OFF, water recirculates and it causes the water to heat up. This Jetwave water jetting machine can also be used as a pressure washer. Use as a pressure washer is similar to 4.
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Maintenance Instructions Machine Shut Down Procedure 1. When high pressure cleaning or water jetting task is WARNING complete, release high pressure trigger. Before performing any maintenance, engine switch 2. Return to the unit controls.
At 1000 hours of use (less in severe use conditions) For information on your nearest Jetwave Independent the Typhoon Hot G2 should be taken to a Jetwave Service Center or any service or repair questions: Independent Service Center for pump seal and valve •...
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Trouble Shooting PROBLEM CAUSE SOLUTION Jetter shuts off in use. Not enough water in the tank (low water Con rm water supply is ON. oat switch turning jetter off). Con rm water supply hose is clear and not kinked or collapsed.
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Maintenance Log Hour Meter Date Maintenance Performed Service Agent Reading The manufacture reserves the right to modify design features and technical facts without notice: due to our principals of continuous improvement.
Page 18
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Notes The manufacture reserves the right to modify design features and technical facts without notice: due to our principals of continuous improvement.
Page 19
TYPHOON HOT G2 MANUAL - WATER JETTER/DRAIN CLEANER Notes The manufacture reserves the right to modify design features and technical facts without notice: due to our principals of continuous improvement.