Table of Contents
Advertisement
FCC ID: NO9MED004
Operating Instructions
Radio Transmitter spectrum 1 M
BE-SP1M-V2-3(FCC).doc [ Word 2000 ] MB
Page 1 / 24
HBC
– Radio Control
R
a
d
i
o
T
r
a
n
s
m
i
t
t
e
r
s
p
e
c
t
r
u
m
1
M
R
a
d
i
o
T
r
a
n
s
m
i
t
t
e
r
s
p
e
c
t
r
u
m
1
M
for the Constructional and Industrial Use
Radio Control System
HBC-radiomatic GmbH • D-74564 Crailsheim • Germany
Information and specifications subject to change without notice.
2003-02-12
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for HBC-Radiomatic spectrum 1 M
Summary of Contents for HBC-Radiomatic spectrum 1 M
- Page 1 Radio Transmitter spectrum 1 M BE-SP1M-V2-3(FCC).doc [ Word 2000 ] MB Page 1 / 24 – Radio Control for the Constructional and Industrial Use Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12...
- Page 2 German trademark. © 2002 – 02 , HBC-radiomatic GmbH , D-74564 Crailsheim No part of any software or of the present document may be reproduced in any manner whatsoever without the expressed written permission of HBC-radiomatic GmbH.
-
Page 3: Table Of Contents
Set-up ............17 Fault Correction ................18 Maintenance .................19 In the Event of a Fault................19 Technical Data................20 Dimensions and Operating Elements of spectrum 1 M ......21 6.1.1 Industrial Version ..............21 6.1.2 Constructional Version ............22 Certification and Approvals ............23 Radio Control System HBC-radiomatic GmbH •... -
Page 4: Description
Operating the radio transmitter using a different frequency range or transmitting power requires the approval of the competent regulative authorities for telecommunication. The following radio receivers may be used in conjunction with the spectrum 1 M radio transmitter : FSE 716... -
Page 5: Safety Instructions
Pay attention to the comments and instructions given. Ignoring the information provided may permanently impair the reliability and operability of the equipment. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... -
Page 6: General Safety Instructions
Accident Prevention Regulations for Operating Cranes by Radio Controls" (VBG 9; ZH 1/547) and pr EN 12077-1. – The spectrum 1 M transmitter has been tested and approved in accordance with EMC guidelines and complies with the authoritative standards for emitted interference and interference immunity. -
Page 7: Operator Safety Instructions
As you are no longer in the crane and can no longer sense the starting of the crane movements as distinctly, crane reactions will appear sluggish or dull. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... -
Page 8: Operation
If the discharged battery is not replaced by a charged one, the transmitter will be automatically switched OFF after a few minutes. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice. -
Page 9: Automatic Switch-Off ( Apo Function )
Due to the above, a clearly visible indicator lamp should be installed on the crane – possibly a flashing one. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... -
Page 10: Battery And Battery Charger
– Use the charger at room temperature (20 °C or 68 °F) and protect it from extreme heat (direct sun). Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice. -
Page 11: Special Operating Modes ( Optional )
S C A N N E R File: SP-1M_Layout-Bau_Scanner.CDR [ CorelDraw 8.0 ] 27.09.2000 FL Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... -
Page 12: Option "Pitch - Catch
In addition, a lamp that can be mounted on the crane will indicate when the receiver is busy (busy display). Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice. -
Page 13: Option Tandem Operation
Access to both cranes Access to crane B Transmitter 1 A A + B B File: SP-1M_Layout-Industrie_Tandemf.CDR [ CorelDraw 8.0 ] 27.09.2000 FL Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... - Page 14 It is possible, however, to operate only one "master" and one "slave" transmitter. In this case, only the "master" transmitter is able to control both cranes in tandem operation. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice.
- Page 15 The extra key supplied with transmitter 2 must therefore be deposited at a superior, authoritative position and only be handed out in clarified cases Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12...
-
Page 16: Option Infrakey
The range of the infrared beam is max. approx. 20 meters (66 feet) and the angle of radiation is 34°. To activate infrakey, press the "(Crane) On" pushbutton on the transmitter. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice. -
Page 17: Infrakey Set-Up
6. Affix the "INFRAKEY OK" sticker above the set-up pushbutton The focus I infrakey receiver can now recognize the transmitter's exclusive security telegram. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... -
Page 18: Fault Correction
− The battery defective. − Ensure that the recharging process runs correctly. − Check the transmitter functions using a fully charged or replacement battery. Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice. -
Page 19: Maintenance
HBC-radiomatic GmbH – Customer Services / Repair Service – Tel.: +49 ( 0 ) 79 51 – 3 93 - 800 Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... -
Page 20: Technical Data
212 x 160 x 185 mm ( 8.3 x 6.3 x 7.3 " ) Housing dimensions Weight approx. 2,0 kg ( 4.4 lb. ) Protection class IP 55 ( Nema 4 ) Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice. -
Page 21: Dimensions And Operating Elements Of Spectrum 1 M
Operating Instructions Radio Transmitter spectrum 1 M BE-SP1M-V2-3(FCC).doc [ Word 2000 ] MB Page 21 / 24 Dimensions and Operating Elements of spectrum 1 M 6.1.1 Industrial Version Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. -
Page 22: Constructional Version
Operating Instructions Radio Transmitter spectrum 1 M Page 22 / 24 BE-SP1M-V2-2.DOC [ Word 2000 ] FL 6.1.2 Constructional Version Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice. -
Page 23: Certification And Approvals
Operating Instructions Radio Transmitter spectrum 1 M BE-SP1M-V2-3(FCC).doc [ Word 2000 ] MB Page 23 / 24 Certification and Approvals Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany Information and specifications subject to change without notice. 2003-02-12... - Page 24 Operating Instructions Radio Transmitter spectrum 1 M Page 24 / 24 BE-SP1M-V2-2.DOC [ Word 2000 ] FL Radio Control System HBC-radiomatic GmbH • D-74564 Crailsheim • Germany 2002-02-27 Information and specifications subject to change without notice.
Need help?
Do you have a question about the spectrum 1 M and is the answer not in the manual?
Questions and answers
What is the cause of the battery green blinking fast?