Page 1
修理の際は、必ず取扱説明書を参照の上、作業を行っ ● ● operating instructions without fail. てください。 Some illustrations using in this service manual are 本文中に使用しているイラストは、説明の都合上現物 ● ● slightly different from the actual set. と多少異なる場合があります。 TOKYO ,JAPAN Denon Brand Company, D&M Holdings Inc. X0270-2 V.03 DE/CDM 0607...
Page 2
AVR-2807 / AVR-987 SAFETY PRECAUTIONS The following check should be performed for the continued protection of the customer and service technician. LEAKAGE CURRENT CHECK Before returning the unit to the customer, make sure you make either (1) a leakage current check or (2) a line to chassis resistance check.
AVR-2807 / AVR-987 WIRE ARRANGEMENT ワイヤー整形図 If wire bundles are untied or moved to perform adjustment or 調整や部品の交換等により、ワイヤー類の結束をはずしたり parts replacement etc.,be sure to rearrange them neatly as 移動させた場合には、それらの作業が完了した時点でワイ they were originally bundled or placed afterward. ヤーの整形をおこなってください。正しく整形されていない Otherwise, incorrect arrangement can be a cause of noise とノイズ発生の原因となることがあります。...
AVR-2807 / AVR-987 CAUTION IN SERVICING サービス時の注意事項 Initializing AV SURROUND RECEIVER AV サラウンドアンプの初期化について AV SURROUND RECEIVER initialization should be performed マイコンやマイコン周辺部品、Digital 基板等を交換した場合は、 when the µcom, peripheral parts of µcom, and Digital P.W.B. are AV サラウンドアンプの初期化を行って下さい。 replaced. 1. Switch off the unit.
Page 6
AVR-2807 / AVR-987 ADJUSTMENT 調整 Audio Section オーディオセクション Idling Current (1U-3701-1) アイドリング電流の調整(1U-3701-1) Required measurement equipment: DC Voltmeter 調整に必要な測定器:DC Voltmeter Preparation 準備 (1) Avoid direct blow from an air conditioner or an electric (1) セットをクーラ、扇風機のそばなど風通しの良い場所を fan, and adjust the unit at normal room tempereture 15°C 避け、通常の使用状態に置きます。セットの周囲温度は...
Page 7
AVR-2807 / AVR-987 FR ch VR302 FR ch FL ch TP301 SR ch SL ch FL ch VR301 SR ch VR102 DC Voltmeter SL ch VR101 C ch VR201 C ch TP101 SBR ch SBL ch SBR ch VR402 SBL ch...
AVR-2807 / AVR-987 VIDEO Section ビデオセクション 1. SETTING 1. セッティング手順 (1) Connect the oscilloscope to the Y-signal and C-signal of (1) セットの S MONITOR OUT 端子から Y 信号と C 信号を S MONITOR OUT terminal and each terminate at 75 それぞれオシロスコープ(終端抵抗:75Ω)に接続し Ohms. ます。...
Page 9
AVR-2807 / AVR-987 2.4. Procedure 2.4. 手順 (1) Adjust the signal of S MONITOR OUT by the wave of os- (1) セットの S MONITOR OUT の信号レベルをオシロスコー cilloscope. プ上の波高値で調整します。 (a) Target, Y-signal (a) Y 信号レベル Point 1U-3737 VR601 調整個所 : 1U-3737 VR601 Adjustment Value 714 ±...
Page 10
AVR-2807 / AVR-987 (c) Target, P -signal (c) P 信号レベル Point 1U-3737 VR605 調整個所 : 1U-3737 VR605 調整値 : 525 ± 10mV Adjustment Value *525 ± 10mV 波形 Waveform -signal COMPONENT OUT COMPONENT OUT の P 信号レベル * : 486 ± 10mV for U.S.A. & Canada model...
Page 20
AVR-2807 / AVR-987 SEMICONDUCTORS Only major semiconductors are shown, general semiconductors etc. are omitted to list. 主な半導体を記載しています。汎用の半導体は記載を省略しています。 Note : Abbreviation ahead of IC No. indicates the name of P.W.B., etc. 注) :IC No. の前の記号は、基板の名称を表します。 MA : MAIN CPU UNIT PA : POWER AMP UNIT...
Page 21
AVR-2807 / AVR-987 Op Op Pin Name Symbol Type STBY stop FUNCTION (Int.) (Ext.) BYTE BYTE GND (Ext. data bus bit width switching, 16bit: L) CNVCS CNVSS Single-chip/Micro-processor mode switching (Normal single-chip: L,Rewrite boot program start:H input set) RST SUB(RESET2) SUB-μcom reset output Not used RESET RESET Reset input (Reset="L") XOUT Oscillator connection Oscillator connection P85/NMI ̲NMI Not used (Fixed to H) P84/INT2 B.DOWN E ↓ &L Power down detect (Power down:L) P83/INT1 PROTECTION E ↓...
Page 22
AVR-2807 / AVR-987 Op Op Pin Name Symbol Type STBY stop FUNCTION (Int.) (Ext.) P10/D8 GRNLED POWER/STANDBY LED control pin P07/D7 H/P DET H/P detect input(Detected:H) P06/D6 FL RST FL DRIVER control pin P05/D5 FL CE2 FL DRIVER control pin P04/D4 FL CE1 FL DRIVER control pin P03/D3 FL DATA FL DRIVER control pin P02/D2 FL CLK FL DRIVER control pin P01/D1 VSEL A Mazter Volume rotation detect input(Rotary encoder) P00/D0 VSEL B Mazter Volume rotation detect input(Rotary encoder)...
Page 23
AVR-2807 / AVR-987 M30620FCPGP (DI : IC251) M30620FCPGP Terminal Function Op Op Pin Name Symbol Type FUNCTION (Int.) (Ext.) P94/TB4 (DLINK ON) Not used P93/TB3 DIRCE DIR control pin (LC89057W) P92/SOUT3 DIRDIN DIR control pin (LC89057W) P91/SIN3 DIRDOUT DIR control pin (LC89057W) P90/CLK3 DIRCLK DIR control pin (LC89057W) BYTE BYTE GND (Ext. data bus bit width switching, 16bit: L) CNVCS CNVSS Single-chip/Micro-processor mode switching (Normal single-chip: L,Rewrite boot program start:H input set) DSPBOOT DSP rewrite boot program (DSP rewrite: L input)
Page 24
AVR-2807 / AVR-987 Op Op Pin Name Symbol Type FUNCTION (Int.) (Ext.) P71/RXD2 SCL/EDIT SCL VIDEO I2C/HDMI EDIT(E2PROM) control pin P70/TXD2 SDA/EDIT SDA VIDEO I2C/HDMI EDIT(E2PROM) control pin P67/TXD1 TXD.S Data transfer output to outside P66/RXD1 RXD.S Data receive input from outside P65/CLK1 SCLK for emulator P64/CTS1 BUSY for emulator P63/TXD0 SOMI MAIN-SUB μcom comm. control pin P62/RXD0 SIMO MAIN-SUB μcom comm. control pin P61/CLK0 CLKSIMO MAIN-SUB μcom comm. control pin P60/CTS0 REQSOMI MAIN-SUB μcom comm. control pin...
Page 25
AVR-2807 / AVR-987 TC4094BF(TP1) (MA : IC501,502,504,508) TC4094BF(TP1) Terminal Function Port Symbol Function IC504 EXP1 TRIGGER 2 TRIGGER OUT 2 control pin EXP2 TRIGGER 1 TRIGGER OUT 1 control pin EXP3 AD MUTE AD mute control pin EXP4 PRE Z2 MUTE PREOUT mute control pin EXP5 (PRE Z2 MUTE) Not used EXP6 PRE SB MUTE PREOUT mute control pin EXP7 PRE S MUTE PREOUT mute control pin EXP8 PRE SW MUTE PREOUT mute control pin IC508 EXP9 PRE C MUTE...
Page 26
AVR-2807 / AVR-987 BU4094BCFV-E2 (AV : IC708,709,710) (AV : IC711 / AVC-2920 only) BU4094BCFV-E2 Terminal Function Port Symbol Function IC708 EXP1 IN A Video input select EXP2 IN B Video input select EXP3 IN C Video input select EXP4 Z1IN INH Video input select EXP5 REC A Video RECOUT select EXP6 REC B Video RECOUT select EXP7 REC C Video RECOUT select...
AVR-2807 / AVR-987 PCM1803 (DI : IC301) MODE1 MODE0 FMT1 FMT0 AGND SCKI PDWN BYPAS DGND TEST DOUT LRCK BLOCK DIAGRAM DeltaœSigma Modulator LRCK DOUT Serial x1/64 , x1/128 Interface Decimation Filter Reference With Mode/ FMT0 HighœPass Filter Format Control FMT1 DeltaœSigma...
Page 32
AVR-2807 / AVR-987 LC89057W-VF4A (DI : IC101) EMPHA/UO AUDIO/VO XMODE Microcontroller RXOUT C bit, U bit 37 DO 36 RERR 24 SDIN 23 SLRCK Input Demodulation 22 SBCK Data Selector 21 RDATA & Selector 21 RDATA Lock Detect XMODE 20 RLRCK...
Page 33
AVR-2807 / AVR-987 Function Pin Name XOUT X’tal osc. connecting output terminal X’tal osc. connection, external clock input terminal (24.576MHz or 12.288MHz) DVDD — Digital power DGND — Digital GND EMPHA/UO Emphasis information/U-data output/Chip address setting terminal AUDIO/VO Non-PCM detect/V-flag output/ Chip address setting terminal...
Page 34
AVR-2807 / AVR-987 DSD1608PAHR (DI : IC304) DSD3 DSD4 DSD5 DSD6 AGND5 DSD7 DSD8 AGND4 PDATA1 DSD1608 PDATA2 AGND3 PDATA3 PDATA4 AGND2 PBCK PLRCK V OUT 1 Output Amp and DBCK Low-Pass Filter DSD1 DSD2 V OUT 2 Output Amp and...
Page 35
AVR-2807 / AVR-987 Terminal Functions TERMINAL DESCRIPTION DESCRIPTION NAME AGND1 — Analog ground AGND2 — Analog ground AGND3 — Analog ground AGND4 — Analog ground AGND5 — Analog ground AGND6 — Analog ground DSD audio data bit clock input (DSD) (3)
Page 40
AVR-2807 / AVR-987 BH7868FS (DI : IC608) 6.75MHz Vcc1 COUT 75Ω S-DC OUT S-DC OUT S1/S2 6.75MHz CVOUT 75Ω C IN Bias CVOUT SAG MUTE1 MUTE1 6.75MHz CV IN Clamp 75Ω YOUT SEL(CV/MIX) YOUT SAG Y IN Clamp 13.5MHz Py/G OUT Bias 75Ω...
AVR-2807 / AVR-987 NOTE FOR PARTS LIST 部品表について • Part indicated with the mark "nsp" are not always in stock and possibly to 1.nsp 印の部品は常時在庫していませんので供給に長時間を要すること take a long period of time for supplying, or in some case supplying of part があります。...
AVR-2807 / AVR-987 PARTS LIST OF P.W.B. UNIT *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
Page 63
AVR-2807 / AVR-987 Ref. No. Part No. Part Name Remarks Q'ty RESISTORS GROUP R579 00D 241 2387 908 RD14B2E010JNBST R588 00D 241 2387 908 RD14B2E010JNBST RR837 00D 244 2055 996 RS14B3A122JNBST(S) RR839,840 00D 244 2055 996 RS14B3A122JNBST(S) CAPACITORS GROUP C501...
Page 64
AVR-2807 / AVR-987 Ref. No. Part No. Part Name Remarks Q'ty OTHERS PARTS GROUP CW052 00D 205 0343 058 5P CONN.BASE(KR-PH) CW053 00D 205 0321 054 5P CONNE.BASE (RED) CW114 00D 205 0885 066 11P CON.SOCKET TUC-P CW119 00D 205 0885 066 11P CON.SOCKET TUC-P...
Page 65
AVR-2807 / AVR-987 1U-3701 POWER AMP P.W.B. UNIT ASS'Y Ref. No. Part No. Part Name Remarks Q'ty SEMICONDUCTORS GROUP IC603 00D 263 1035 002 PQ30RV11 IC604 00D 268 0073 905 ICP-N15T TR105,106 00D 273 0458 904 2SC/KTC3200BL-AT TR205 00D 273 0458 904...
AVR-2807 / AVR-987 EXPLODED VIEW (1/2) MAIN UNIT) WARNING: Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer. 印の部分は安全を維持するために重要 な部品です。従って交換時は必ず指定の 部品を使用してください。 4-12 4-11 DHCT-C3 4-10 DHCT-A3 4-14 5-14 5-13 4-13...
Page 87
AVR-2807 / AVR-987 EXPLODED VIEW (2/2) FRONT PANEL UNIT) WARNING: Parts marked with this symbol have critical characteristics. Use ONLY replacement parts recommended by the manufacturer. 印の部分は安全を維持するために重要 な部品です。従って交換時は必ず指定の 部品を使用してください。 D/S PLATE : Cut INNER PANEL H/P PLATE : Cut INNER PANEL...
AVR-2807 / AVR-987 PARTS LIST OF EXPLODED VIEW *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions. * "nsp" 印の部品は常時在庫していませんので供給に長時間を要することがあります。場合によっては、供給をお断りする場合があります。 * Part indicated with the mark “nsp” are not always in stock and possibly to take a long period of time for supplying, or in some case supplying of part may be refused.
AVR-2807 / AVR-987 PACKING VIEW EU,EC model 215 216 E1C,EUT model 207 210 E1C,EUT model PARTS LIST OF PACKING & ACCESSORIES *本表に記載されている部品は、補修用部品のため製品に使用している部品とは一部、形状、寸法などが異なる場合があります。 * The parts listed below are for maintenance only, might differ from the parts used in the unit in appearances or dimensions.
AVR-2807 / AVR-987 NOTE FOR SCHEMATIC DIAGRAM 配線図について WARNING: ! 印の部品は安全を維持するために重要な部品です。 Parts marked with this symbol ! have critical characteristics. 従って交換時は必ず指定の部品を使用してください。 Use ONLY replacement parts recommended by the manufactur- 注) CAUTION: (1) 指定なき抵抗値は Ω、k は kΩ、M は MΩ を示す。 Before returning the unit to the customer, make sure you make µ...
Page 93
AVR-2807 / AVC-2920 SCHEMATIC DIAGRAMS (1/31) SCHEMATIC DIAGRAMS (1/31) 1U-3700-1 MAIN CPU UNIT (1/2)
Page 94
AVR-2807 / AVC-2920 SCHEMATIC DIAGRAMS (2/31) SCHEMATIC DIAGRAMS (2/31) 1U-3700-1 MAIN CPU UNIT (2/2)
Page 95
AVR-2807 / AVC-2920 SCHEMATIC DIAGRAMS (3/31) SCHEMATIC DIAGRAMS (3/31) 1U-3700-2 DIGITAL IN UNIT...
Page 96
AVR-2807 / AVC-2920 SCHEMATIC DIAGRAMS (4/31) SCHEMATIC DIAGRAMS (4/31) 1U-3700-3 EXT IN / PREOUT UNIT 1U-3700-4 PRE CONNECT2 UNIT...
Page 104
AVR-2807 / AVC-2920 SCHEMATIC DIAGRAMS (12/31) SCHEMATIC DIAGRAMS (12/31) 1U-3703-1 FLD UNIT 1U-3703-2 FUNC. UNIT 1U-3703-3 P.KEY UNIT 1U-3703-4 JOINT UNIT 1U-3703-5 TACT-1 UNIT 1U-3703-6 TACT-2 UNIT 1U-3703-7 VOL UNIT 1U-3703-8 P.SW UNIT 1U-3703-9 H/P UNIT...
Page 112
AVR-2807 / AVC-2920 SCHEMATIC DIAGRAMS (20/31) SCHEMATIC DIAGRAMS (20/31) 1U-3704-3 FRONT IN UNIT 1U-3704-4 MIC UNIT 1U-3704-12 IPOD UNIT 1U-3704-13 DSP REG. UNIT...
AVR-2807 / AVR-987 DOCUMENTS FOR WEEE Details of Recycle Parts * You have to remove the parts that marked “WEEE Mark ◆ " when the recycling processing. (E1C:China model only) WEEE Ref. No. Part Name MATERIAL Q'ty MARK 1U-3700-1:MAIN CPU UNIT COMPLEX ◆...
Page 125
AVR-2807 / AVR-987 WEEE Ref. No. Part Name MATERIAL Q'ty MARK RADIATOR BRACKET (R) STEEL CARD SPACER(L=10) PA-66 INSULATING SHEET(B) PUSH RIVET PA-6 BACK PANEL STEEL LOCKING CARD SPACER PA-66 TERMINAL ASS COMPLEX ◆ AM FM TUNER COMPLEX ◆ AC INLET COMPLEX ◆...
Page 127
AVR-2807 / AVR-987 Exploded view of AVR-2807 (E1C:China model) : MAIN UNIT You have to remove the parts that marked "WEEE mark " when the recycling processing. (Europe model only) 4-12 4-11 DHCT-C3 4-10 DHCT-A3 4-14 5-14 5-13 4-13...
Page 128
AVR-2807 / AVR-987 Exploded view of AVR-2807 (E1C:China model) : FRONT PANEL UNIT You have to remove the parts that marked "WEEE mark " when the recycling processing. (Europe model only) D/S PLATE : Cut INNER PANEL H/P PLATE : Cut INNER PANEL...
Page 129
AVR-2807 / AVR-987 Details of Recycle parts for Power transformer(Ref.No.34) MATERIAL STEEL STEEL SILICON STEEL PAPER COPPER ALLOY SILICON STEEL PRESS BOARD PRESS BOARD PVC+COPPER WIRE PA66 PVC+COPPER WIRE PA66 PVC+COPPER WIRE PA66 PVC+COPPER WIRE PA66 PVC+COPPER WIRE PA66 COPPER WIRE...
Page 130
AVR-2807 / AVR-987 Details of Recycle parts for Sub transformer(Ref.No.77) MATERIAL STEEL COPPER WIRE SILICON GRASS COMPLEX COPPER WIRE COPPER ALLOY COPPER ALLOY...