Page 1
Part #122420-001 Product Manual: PELAIR Series Portable Air Conditioners IS O 9 0 0 1 Certified T.A. Pelsue Company 2500 South Tejon Street Englewood, Colorado, USA 80110 Tel. 800-525-8460 or 303-936-7432 Fax. 303-934-5581 Internet: www.pelsue.com Email: sales@pelsue.com...
Page 2
Page 2 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
Page 3
Pelsue continues the dedication that industry throughout the world. has made us pre-eminent in this field. Page 3 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
EVERY T.A. PELSUE COMPANY EMPLOYEE IS ExPECTED TO COMMIT TO THIS PHILOSOPHY IN THE PERFORMANCE OF HIS OR HER DAILY TASkS. QUALITY FIRST! T.A. PELSUE COMPANY SENIOR MANAGEMENT TEAM Page 5 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
1 year (365 days). In the event of failure of any components of a Pelsue product within the warranty period, service must be pre- approved by the T.A. Pelsue Company, and service must be performed by the T.A. Pelsue Parts and Service Department in Englewood, Colorado, or at the option of the T.A.
2.0 - Introduction & Product Information Congratulations on your choice of a Pelsue PELAIR Series Portable air conditioner. The Pelair Air Conditioner can be used for the climate control of portable shelters in a variety of applications. Such use includes, but is not limited to Fire, Police &...
3.0 - Configuration & Assembly Upon initial receipt of the PELAIR Series Portable Air Conditioner, inspect the packaging for any evidence that the product may have been damaged in shipment. While unpacking the product, inspect all of the components for damage.
ASSEMBLY - AIR HANDLER - ExTERIOR ASSEMBLY ASSY: SEE DWG #122414 D. HAM 03-29-05 NONE Page 9 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008 TOP VIEW 122334-### SUB ASSEMBLY - 2-WHEEL HAND CART ASSY: SEE DWG #122334 LATEST A.
3.2 Wiring Diagram Shown below are the wiring diagrams for the #PELAIR15V and #PELAIR30V. Page 10 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
You are responsible for the safe operation of your Pelsue PELAIR Portable Air Conditioner. You must ensure that anyone who will operate or work around the equipment be familiar with it and general safety practices when working around electricity.
! CAUTION ! - The user must ensure that the air conditioner is located where it cannot fall into water inadvertently and that the extension cords and plug will remain dry and secure during operation. Page 13 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
5.0 - Product Operation The following section will address the capabilities and the general operation of the Pelsue PELAIR Portable Air Condi- tioner. The instructions contained within this section should be adhered to each and every time the product is used. Any person tasked with installing or operating this piece of equipment should be familiar with these procedures.
5.2 - Start-Up & Operating Procedures Prior to Operation, the PELAIR Series Portable Air Conditioner should be configured and prepared according to the following guidelines. 1. Pre-Operation Inspection: It is necessary to perform a visual inspection, each time, prior to using the product. If deficiencies are found, remove the product from service and contact the T.A.
Page 16
Ensure that the unit is “powered off” via its onboard switch prior to supplying any input voltage to the unit. f. Ensure that the power cord is in good condition and securely attached to a 20 amp-rated and breaker-protected 120VAC GROUNDED receptacle. Page 16 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
Page 17
Access the board by removing the left hand lower side panel and/or the front lower panel. All functions of the air conditioner are monitored by the microprocessor on the circuit Page 17 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
Page 18
“Power On” Cycles. If no errors have been encountered, nothing will flash, the 3 quick blinks will occur to indicate the unit has returned to normal operation. Page 18 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
* Note: it is best to pull the unit over any large obstacles. There is a grab handle at the front of the unit for lifting over obstructions. Always try to keep the air conditioner in the vertical position as practically possible during movement. Page 19 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
B) Extension cord sized incorrectly B) See Section 4.2 - 4, Run without extension cord Page 20 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
Page 21
NOTES Page 21 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
Page 22
NOTES Page 22 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
Page 23
Page 23 #122420-001 - Product Manual: PELAIR SERIES PORTABLE AIR CONDITIONER - Revision 05 - Date: 12-01-2008...
Page 24
T.A. Pelsue Company 2500 South Tejon Street, Englewood, Colorado, USA 80110 Toll free 800-525-8460 or 303-936-7432 Fax. 303-934-5581 ISO 90 0 1 Certified Internet: www.pelsue.com Email: sales@pelsue.com...