Only qualified personnel should install and service the equipment. The installation, starting up, and servicing of heating, ventilating, and air-conditioning
equipment can be hazardous and requires specific knowledge and training. Improperly installed, adjusted or altered equipment by an unqualified person
could result in death or serious injury. When working on the equipment, observe all precautions in the literature and on the tags, stickers, and labels that
are attached to the equipment.
June 2020
N N o o t t e e : : "Graphics in this document are for representation only. Actual
model may differ in appearance."
S S A A F F E E T T Y Y W W A A R R N N I I N N G G
1 1 8 8 - - E E B B 3 3 0 0 D D 1 1 - - 1 1 G G - - E E N N
Page 1
Installer’s Guide Single Packaged Cooling/Electric Heat 14 SEER Convertible, 2 — 5 Ton 4TCC4024A1000A 4TCC4030A1000A 4TCC4036A1000A 4TCC4042A1000A 4TCC4048A1000A 4TCC4060A1000A N N o o t t e e : : “Graphics in this document are for representation only. Actual model may differ in appearance.”...
Page 2
SAFETY SECTION W W A A R R N N I I N N G G I I m m p p o o r r t t a a n n t t — This document contains a wiring diagram, a parts list, and service information.
Introduction Read this manual carefully before attempting to install, S S t t e e p p 1 1 — — I I n n s s p p e e c c t t S S h h i i p p m m e e n n t t operate, or perform maintenance on this unit.
Step 2 — Determine Unit Clearances Figure 1. 2 — 3 TON MODELS Note: The view labeled Bottom Side represents the base as viewed looking up from underneath the unit. 18-EB30D1-1G-EN...
Page 6
S S t t e e p p 2 2 — — D D e e t t e e r r m m i i n n e e U U n n i i t t C C l l e e a a r r a a n n c c e e s s Figure 2.
Page 7
S S t t e e p p 2 2 — — D D e e t t e e r r m m i i n n e e U U n n i i t t C C l l e e a a r r a a n n c c e e s s Figure 3.
Page 8
S S t t e e p p 2 2 — — D D e e t t e e r r m m i i n n e e U U n n i i t t C C l l e e a a r r a a n n c c e e s s Figure 4.
Page 9
S S t t e e p p 2 2 — — D D e e t t e e r r m m i i n n e e U U n n i i t t C C l l e e a a r r a a n n c c e e s s Figure 5.
Page 10
S S t t e e p p 2 2 — — D D e e t t e e r r m m i i n n e e U U n n i i t t C C l l e e a a r r a a n n c c e e s s Figure 6.
Step 4 — Unit Installation N N o o t t e e : : The factory ships this unit for horizontal weatherproof seal where the duct enters the installation. structure. 5. Do not expose the unit to direct roof water runoff. T T o o I I n n s s t t a a l l l l t t h h e e u u n n i i t t a a t t g g r r o o u u n n d d l l e e v v e e l l : : 6.
Page 13
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n Figure 8.
Page 14
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n Table 1.
Page 15
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n Table 2.
Page 16
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n Table 4.
Page 17
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n D D u u c c t t w w o o r r k k I I n n s s t t a a l l l l a a t t i i o o n n N N o o t t e e : : Do not draw the canvas taut between the solid ducts.
Page 18
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n Table 6.
Page 19
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n Table 10.
Page 20
S S t t e e p p 4 4 — — U U n n i i t t I I n n s s t t a a l l l l a a t t i i o o n n Table 11.
Step 5 — Unit Startup P P r r e e - - S S t t a a r r t t Q Q u u i i c c k k C C h h e e c c k k l l i i s s t t O O p p e e r r a a t t i i n n g g P P r r e e s s s s u u r r e e C C h h e e c c k k s s Is the unit properly located and level with the After the unit has operated in the cooling mode for a...
Sequence of Operation G G e e n n e e r r a a l l power to the “W W ” terminal on the indoor thermostat and to the supplementary heater control circuit. An Operation of the unit heating and cooling cycles is outdoor thermostat may have been added to disallow automatic when the system is in the H H E E A A T T or C C O O O O L L the second stage (if provided) of electric heat above a...
S S e e q q u u e e n n c c e e o o f f O O p p e e r r a a t t i i o o n n F F i i n n a a l l I I n n s s t t a a l l l l a a t t i i o o n n C C h h e e c c k k l l i i s s t t If the unit has disposable-type filters, replace them with new filters of the same type and size.
Page 28
About Trane and American Standard Heating and Air Conditioning Trane and American Standard create comfortable, energy efficient indoor environments for residential applications. For more information, please visit www.trane.com or www.americanstandardair.com. The AHRI Certified mark indicates company participation in the AHRI Certification program. For verification of individual certified products, go to ahridirectory.org.