Specific Safety Rules - Scheppach DP5000 Translation From The Original Instruction Manual

in the tank.
Never over fill fuel tank. Fill tank to no more than
12.5mm (1/2") below the bottom of the filler neck to
provide space for expansion as the heat of the engine
can cause fuel to expand.
Replace all fuel tank and container caps securely and
wipe up spilt fuel. Never operate the unit without the fuel
cap securely in place.
Avoid creating a source of ignition for spilt fuel. If fuel is
spilt, do not attempt to start the engine but move the ma-
chine away from the area of spillage and avoid creating
any source of ignition until fuel vapors have dissipated.
Store fuel in containers specifically designed and appro-
ved for this purpose.
Store fuel in a cool, well-ventilated area, safely away
from sparks, open flames or other sources of ignition.
Never store fuel or machine with fuel in the tank inside
a building where fumes may reach a spark, open flame,
or other sources of ignition, such as a water heater, fur-
nace, clothes dryer and the like. Allow the engine to cool
before storing in any enclosure.
Machine use and care
Position the machine in such a way that it can not mo-
ve during maintenance, cleaning, adjustment, assembly
of accessories or spare parts, as well as under storage.
Do not force the machine. Use the correct machine for
your application. The correct machine will do the job bet-
ter and safer at the rate for which it is designed.
Do not change the engine governor settings or over-speed
the engine. The governor controls the maximum safe ope-
rating speed of the engine.
Do not run the engine at a high speed when you are not
working.
Do not put hands or feet near rotating parts.
Avoid contact with hot fuel, oil, exhaust fumes and hot
surfaces. Do not touch the engine or muffler. These parts
get extremely hot from operation. They remain hot for a
short time after you turn off the unit. Allow the engine to
cool before doing maintenance or making adjustments.
If the machine should start to make an unusual noise or
vibration, immediately shut off the engine, disconnect
the spark plug wire, and check for the cause. Unusual
noise or vibration is generally a warning of trouble.
Use only attachments and accessories approved by the
manufacturer. Failure to do so can result in personal
injury.
Maintain the machine. Check for misalignment or bin-
ding of moving parts, breakage of parts and any other
condition that may affect the machine's operation. If
damaged, have the machine repaired before use. Many
accidents are caused by poorly maintained equipment.
Keep the engine and muffler free of grass, leaves, ex-
cessive grease or carbon build up to reduce the chance
of a fire hazard.
Never douse or squirt the unit with water or any other
liquid. Keep handles dry, clean and free from debris.
Clean after each use.
Observe proper disposal laws and regulations for gas, oil,
etc. to protect the environment.
Store idle machine out of the reach of children and do
14
not allow persons unfamiliar with the machine or the-
se instructions to operate it. Machine is dangerous in the
hands of untrained users.
Service
Before cleaning, repair, inspecting, or adjusting, shut off
the engine and make certain that all moving parts have
stopped. Disconnect the spark plug wire, and keep the
wire away from the plug to prevent accidental starting.
Have your machine serviced by qualified repair personnel
using only identical replacement parts. This will ensure
the safety of the machine maintained.
m Specific Safety Rules
Thoroughly inspect the area to be worked, keep the
working area clean and free of debris to prevent tripping.
Operate on a flat level ground.
Never place any part of your body where it would be in
danger if movement should occur during
assembly, installation, and operation, maintenance,
repairing or moving.
Keep all bystanders, children, and pets at least 23m (75
feet) away. If you are approached, stop
the unit immediately.
Do not mount on dump box and never carry passengers.
Never park the machine in a place with unstable ground
which could give way, particularly when it is full.
Disengage clutch lever before starting the engine.
Start the engine carefully according to instructions and
with feet well away from the moving parts.
Never leave the operating position when the engine is
running.
Always hold the unit with both hands when operating.
Keep a firm grip on the handlebars.
Beaware that the machine may unexpectedly bounce
upward or jump forward if the machine should strike
buried obstacles such as large stones.
Walk, never run with the machine.
Do not overload the machine capacity. Drive at a safe
speed, adjusting the speed to the slope of the land, the
surface conditions of the road, and the weight of the
load.
Use extreme caution when in reverse or pulling the ma-
chine towards you.
Exercise extreme caution when operating on or crossing
gravel drives, walks, or roads. Stay alert for hidden ha-
zards or traffic.
On soft ground, drive at the first forward/reverse gear.
Do not rapidly accelerate, turn sharply or stop.
Pay the utmost attention when working on frozen ground
as the machine may tend to skid.
If possible, avoid driving on pebbly river bed, crushed
stone terrains, steel concrete, stumpy field, logs etc.,
since such operation causes fatal damage or shortens
life span of tracks.
Do not operate the machine in confined areas where the-
re may be a risk of crushing the operator between the
machine and another object.