Advertisement
Installation
Read the ENTIRE IMpORTANT SAFETY INFORMATION section at the beginning of this
manual including all text under subheadings therein before set up or use of this product.
The emission control system for this Compressor's Engine is warranted for standards set
by the U.S. Environmental Protection Agency and by the California Air Resources Board
(also known as CARB). For warranty information, refer to the engine manual.
Note: For additional information regarding the parts listed in the following pages,
refer to the Assembly Diagram near the end of this manual.
Functions
Belt Guard Frame (93) &
Belt Guard Cover (97)
ON/OFF
Switch
Tank
pressure
Gauge (76)
Tank Safety Valve (75)
1. Belt Guard - The Belt Guard encloses the pulleys and drive belts.
It protects the user from the moving parts and allows the
large pulley to direct cooling air to the Air Pump.
2. Oil Sight Glass - The oil sight glass shows proper level of
the oil. Oil level should be at center of Sight Glass.
3. Tank Drain Valve - The Air Tank Drain Valve allows moisture
to be removed from the tank to prevent corrosion.
4. Safety Valve - The Safety Valve automatically releases air if the Air
Tank pressure exceeds the preset maximum. In an emergency, the
ring can be pulled to relieve tank air pressure. There is one
safety valve on the pump and one on the tank.
5. Air Outlet - An air hose attaches to this valve. Air pressure required by
tools is set by an air pressure regulator.
6. Air Storage Tank - The Air Tank is where air
pressurized by the Air Pump is stored for use.
7. Tank pressure Gauge - The Air Tank Pressure
Gauge displays the air pressure in the tank.
8. pilot Valve - Open the Pilot Valve before starting the engine.
It relieves resistance on the engine to make starting possible.
Rotate the pin so it is vertical to open it. Once the engine is running,
close the Pilot Valve so the Compressor can build up pressure.
Item 62913
pilot Valve
For technical questions, please call 1-888-866-5797.
pump Safety Valve (6)
Muffler
Assembly (8)
Oil Sight
Glass (41)
Air Outlet (65)
Drain Valve (67)
Crankcase (44)
Oil Sight Glass (41)
Closed
Pilot Valve
OIL LEVEL
OVERFILL
FULL
LOW
Opened
Pilot Valve
Page 7
Advertisement
