Travis Industries Fire Garden 94900432 Manual
Outdoor linear complete fire pit
Hide thumbs
Also See for Fire Garden 94900432:
Table of Contents
Advertisement
Quick Links
F0
Fire Garden™
Outdoor Linear Complete Fire Pit
48x24 Complete Fire Pit
72x24 Complete Fire Pit
132x24 Complete Fire Pit
Omni-Test Laboratories, Inc.
Report # 0028GM127S
ANSI Z21.97-2017 /CSA 2.41-2017, CSA 2.17-2017
Outdoor Decorative Gas Appliances
DANGER
This appliance can produce carbon
monoxide which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an
enclosed space such as a camper,
tent, car, or home.
French language manuals at outdoorfiregarden.com. Manuels de langue Française à outdoorfiregarden.com
Travis Industries, Inc.
$10.00
By Travis Industries, Inc.
Manual
94900432
94900449
94900467
Listed by
CARBON MONOXIDE HAZARD
12521 Harbour Reach Dr., Mukilteo, WA 98275
Copyright 2022, T.I.
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
Shut off gas to the appliance.
•
Extinguish any open flame.
•
If odor continues, leave the area
•
immediately.
After leaving the area, call your gas
•
supplier or fire department.
Failure to follow these instructions
could result in fire or explosion, which
could cause property damage, personal
injury, or death.
WARNING
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance
An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
WARNING: For outdoor use only.
Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.
WARNING: Improper installation,
adjustment, alteration, service or
maintenance can cause injury or
property damage. Read the installation,
operating, and maintenance
instructions thoroughly before
installing or servicing this equipment.
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
INSTALLER: Leave this manual with the
appliance.
CONSUMER: Retain this manual for
future reference
www.travisproducts.com
Part # 100-01579
Advertisement
Table of Contents
Related Manuals for Travis Industries Fire Garden 94900432
Summary of Contents for Travis Industries Fire Garden 94900432
- Page 1 By Travis Industries, Inc. Fire Garden™ DANGER FIRE OR EXPLOSION HAZARD Outdoor Linear Complete Fire Pit If you smell gas: Manual Shut off gas to the appliance. • Extinguish any open flame. • If odor continues, leave the area •...
-
Page 2: Overview
Carbon Monoxide and Benzene, which are known to the State of California to cause cancer, birth defects, or other reproductive harm. For more information go to www.P65Warnings.ca.gov. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 3: Table Of Contents
Wiring Multiple Transformers to One Switch Wiring Diagram ..........36 Wiring Multiple Appliances to One Transformer 19 Index .............. 38 Daisy-Chain Example ........19 © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 4: Safety Precautions
The instructions in this manual must be strictly Travis Industries, Inc. grants no warranty, adhered to. Do not use makeshift methods or implied or stated, for the installation or compromise in the installation. Improper maintenance of your appliance, and assumes installation will void the warranty and safety listing. -
Page 5: Features
Orifice Size (DMS) (2) - #30 (2) - #43 Input Rating 132x24 Fire Pit Input Rating (BTU/h) 240,000 240,000 Orifice Size (DMS) (4) - #30 (4) - #43 © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 6: Linear Fire Pit Dimensions
Features and Specifications Linear Fire Pit Dimensions: © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 7: Installation Warnings
The requirements listed below are divided into sections. All requirements must be met simultaneously. The order of installation is not rigid – the qualified installer should follow the procedure best suited for the installation. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 8: Recommended Order Of Installation
Glass Wind Guard, mounting brackets, and set screws - (2) sides and (2) ends LP Conversion Kit - see “LP Conversion” on page 14 for details. Wall Switch and wall switch cover. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 9: Additional Items Required
High voltage wire (from house circuit to transformer) Weatherproof enclosure for wall switch (only needed if the switch is to be installed outdoors). Media (Crushed Glass, Ember Rock, or Tumbled Stones) Travis Industries offers the following Crushed Glass Options: Platinum sku# 94500580 ... -
Page 10: Weatherproofing The Installation
In places where the controls beneath the appliance may be submerged underwater. Submerging of any part of its controls may require the complete replacement of the controls. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 11: Clearances
Installation (qualified installers only) Clearances © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 12: Enclosure Ventilation Requirements
Failure to maintain the gap will create a severe fire risk and will void the appliance warranty. The height of the leveling legs can be adjusted by turning the leveling leg foot. The legs will adjust from 1/2" to 1" © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 13: Gas Line Requirements
The appliance comes with a 34” flex to make the connection from the gas stub-in to the key-valve installed on the end of the enclosure. The flex accepts 3/4” MPT. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 14: Lp Conversion
(if already installed). Remove the media trays (see “Removing the Media Trays” section on page Convert the appliance using the instructions to the right. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 15: Electrical Connection Requirements
120VAC at approximately 0.9 amps - make sure the circuit and wiring is appropriately sized. The power supply must be routed through a switch to turn the appliance on and off (see pg. 36). Multiple Travis Industries, Inc. 24 volt appliances may be placed on a single circuit. Each appliance uses 24VAC at approximately 1.6 amps - Make sure the circuit and wiring is appropriately sized (see diagrams starting on pg. -
Page 16: Wiring Installation
(below the pilot). Use listed low voltage wiring. Make sure to provide slack in the electrical line for removal and service. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... - Page 17 The appliance uses approximately 40 watts during startup (1.6 amps at 24 VAC). Make sure the circuit and wires are sized appropriately. The appliance requires a minimum of 22 VAC to operate (if the voltage drops below this, the appliance may not start). © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits...
-
Page 18: Using More Than One 24-Volt Appliance
(qualified installers only) Using More than One 24-volt Appliance Travis Industries, Inc. manufactures additional 24-volt appliances that can add to the ambiance of your outdoor space (Tempest Torch™, Tempest Lantern™. Visit tempesttorch.com for more details). If using more than one appliance make sure to think about how the appliances will be used and if they need to be able to be controlled separately or if it would be more convenient to control them all using one switch. -
Page 19: Wiring Multiple Appliances To One Transformer
The manner in which you wire the appliances to the transformer affects the maximum length of wire and wire gauge. Make sure to determine the wire configuration before installation. NOTE: You may use both direct-run and daisy-chain configurations. Daisy-Chain Example Direct-Run Example © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 20: Daisy-Chain Wire Length Chart
Daisy-Chain Wire Length Chart This type of wire configuration allows for multiple Travis Industries 24-volt products to be wired in a series, reducing the amount of wire used. Use the charts below to determine the correct wire gauge and length. In the example below, the transformer has 2 Linear Fire Pits and a lantern on one branch. -
Page 21: Direct-Run Wire Length Chart
The wire will also be printed with a gauge number (e.g. AWG#14 = 14 gauge, 10AWG = 10 gauge, etc.). Do not use wires of dissimilar gauges (do not use 14 gauge & 10 gauge wire on the same transformer). © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 22: Steps For Finalizing The Installation
Crushed Glass Installation Crushed glass is placed over the burners and center media trays. Use only ¼” crushed glass from Travis Industries and/or other media specifically approved by Travis Industries. Placing Crushed Glass on the Burner and Center Media Trays 48x24 Fire Pit 10 lbs. -
Page 23: Rock Ember Installation
Rock Ember Installation Rock embers can be placed over the burners and center media trays. Use only the Rock Ember material from Travis Industries and/or other media specifically approved by Travis Industries. Placing Rock Embers on the Burner and Center Media Trays 5 lbs. -
Page 24: Tumbled Stone Installation
Tumbled Stone may be placed over the burners and media trays. Only use the Tumbled Stone media kit from Travis Industries. The amount of stone indicated on the chart below refers to the small stones used to cover the burner and media tray. Large stones may be placed anywhere over the media tray but should not be installed over the burner and are not included in the recommended weights in the chart below. -
Page 25: Assembling The Glass Wind Guard
180°. The logo should now be in the upper left corner. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... - Page 26 7. When all the clamps are secure turn the assembly over and place it on the finish material around the linear fire pit. Measure the distance from the edge of the pit to the edge of the glass to ensure that it is centered. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits...
-
Page 27: Before The First Fire
Inspect the appliance, burner, and supply lines for any damage prior to operation. The burner must be replaced prior to the appliance being put into operation if it is evident that the burner is damaged. Use only Travis Industries replacement burners. It may be difficult to see the burner operating in direct sunlight. -
Page 28: Location Of Controls
If the wall switch will be located where it is not protected from precipitation, it must be installed in a weather resistant enclosure (not included). © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 29: Maintaining Your Appliance
The glass may be cleaned with a non- abrasive cleaner. To clean the inside of the glass, remove the glass place it on a non- scratching surface, and clean the inside surface. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 30: Accessing Components
Remove all the screws from the media tray(both sides) and remove the trays. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 31: Accessing The Pressure Tap
appliance. Once maintenance or testing of components is complete, follow the above steps in reverse to return the appliance to its proper configuration. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 32: Winterizing The Appliance
Start the main burner. After 15 minutes, the flames should be orange/yellow. If the appliance is not burning correctly, contact your dealer for service. If the igniter is not getting hot or lighting the appliance properly contact your dealer for service. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... -
Page 33: Replacement Parts List
Maintenance Replacement Parts List Caution: Use only Travis Industries replacement parts. Do not use substitute materials. Warning: Do not operate the appliance with the glass wind guard removed, cracked, or broken. Replacement of the glass should be done by a licensed or qualified service person. -
Page 34: Troubleshooting Table
(spider webs, etc.) from the burner and dirty or blocked orifice area. Glass is Sooting Wind will influence the flame quality and, if Windy Condition persistent, may lead to sooting on the glass. © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... - Page 35 Register your TRAVIS INDUSTRIES, INC. Limited 7 Year Warranty online at traviswarranty.com. TRAVIS INDUSTRIES, INC. warrants this gas appliance (appliance is defined as the equipment manufactured by Travis Industries, Inc.) to be defect-free in material and workmanship to the original purchaser from the date of purchase as follows: Check with your dealer in advance for any costs to you when arranging a warranty call.
-
Page 36: Wiring Diagram
Wiring Diagram Wiring Diagram © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits... - Page 37 Wiring Diagram © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits...
-
Page 38: Index
Winterizing the Appliance ........ 32 Installation Warnings .......... 7 Yearly Service Procedure ........ 32 Index © Travis Industries, Inc. 5/24/22 - 1579 Outdoor Complete Linear Fire Pits...