Installation Operation and Maintenance Instructions Contents Service Intro Troubleshooting Warranty Safety Obtaining Service Safety and Warning Disposal and Recycling Installation Environmental Requirements Electrical Cutout Dimensions Product Dimensions Side by Side Installation Water Hookup General Installation Grille Installation Door Swing Door Adjust Operating Instructions First Use Airflow and Product Loading...
Page 3
The information in this guide is intended to help you install and maintain your new Marvel crescent ice maker to protect and prolong the lifetime of your unit. We encourage you to contact our Technical Support team at (800) 223-3900 with any questions.
Installation Operation and Maintenance Instructions Safety and Warning Disposal and Recycling DANGER NOTICE Please read all instructions before installing, operating, or RISK OF CHILD ENTRAPMENT. Before you throw away servicing the appliance. your old refrigerator or freezer, take off the doors and leave shelves in place so children may not easily climb inside.
Cutout Dimensions PREPARE SITE WARNING Your Marvel product has been designed for either free- standing or built-in installation. When built-in, your unit does SHOCK HAZARD — Electrical Grounding Required. Never not require additional air space for top, sides, or rear.
Installation Operation and Maintenance Instructions Side-by-Side Installation 3. Place bracket over holes and attach to unit with two screws removed in step 2 using a T-25 Torx driver. Tighten screws Two units may be installed side-by-side. fully. Cutout width for a side-by-side installation is the cutout 4.
Installation Operation and Maintenance Instructions Water Hookup CAUTION PREPARE PLUMBING Do not use any plastic water supply line. The line is under The water valve uses a standard 1/4" (6.35 mm) compression pressure at all times. Plastic may crack or rupture with age fitting.
Page 9
Installation Operation and Maintenance Instructions Anti-Tip Bracket 3. Locate water valve inlet. 1. Slide unit out so screws on top of unit are easily accessible. 2. Remove the two screws from the opposite side of the hinge assembly using a T-25 Torx driver (see below). 4.
Installation Operation and Maintenance Instructions General Installation INSTALLATION 1. Plug in the power/electrical cord. LEVELING INFORMATION 1. Use a level to confirm 2. Gently push the unit into position. Be careful not to entangle the unit is level. Level the cord or water and drain lines. should be placed along top edge and side edge as shown.
Installation Operation and Maintenance Instructions D D o o o o r r S S w w i i n n g g Grille Installation REMOVING AND INSTALLING GRILLE Wall Wall 1/4" Min. 2-1/8" Min. WARNING (6 mm) (54 mm) Disconnect electric power to the unit before removing the grille.
Installation Operation and Maintenance Instructions Door Adjust Location of the unit may make it desirable to mount the door on the opposite side of the cabinet. HINGE COVER Hinge cover included with the literature bag is optional. The hinge hardware will be removed and reinstalled on the opposite side of the cabinet.
Page 13
Installation Operation and Maintenance Instructions Install top hinge and door: 1. Install the top hinge. Do not tighten. Remove door by tilting forward and lifting door off bottom hinge. Retain shoulder washers; they will be reused. 2. Rotate the door 180 to reverse and set the door onto the bottom hinge.
NOTICE If not intending to use the ice maker, turn the water supply Marvel recommends discarding the ice produced valve off. It is also important to raise the bin arm of the ice during the first two to three hours of operation to avoid maker (see above).
Installation Operation and Maintenance Instructions ICE MAKER ADJUSTMENT 4. Install the ice maker assembly cover. Ice Cube Thickness Adjustment Interval - As Required ADJUSTING ICE HARVEST On ice maker equipped models, adjust the cube size by 1. Remove the front grille (see GRILLE INSTALLATION). changing water amount injected into the ice maker assembly as follows: 2.
Installation Operation and Maintenance Instructions Cleaning If any surface discoloring or rusting appears, clean it quickly ® ® with Bon-Ami or Barkeepers Friend Cleanser and a EXTERIOR CLEANING nonabrasive cloth. Always clean with the grain. Always finish ® with Claire Stainless Steel Polish and Cleaner or Vinyl Clad (Black or White) Models comparable product to prevent further problems.
Installation Operation and Maintenance Instructions DEFROSTING NOTICE Manual Defrost Models DO NOT clean ice bucket using a dishwasher. The bucket This unit is a manual defrost model and will require is not dishwasher safe and will be damaged. occasional defrosting. When there is build-up of 1/4" (6 mm) or more of frost, manually defrost the unit.
Installation Operation and Maintenance Instructions Extended Non-Use VACATION/HOLIDAY, PROLONGED SHUTDOWN For questions regarding extended non-use, please call Marvel at 800.223.3900. The following steps are recommended for periods of extended non-use or if the unit will be exposed to temperatures of 40°F (5°C) or less: CAUTION 1.
Page 19
Installation Operation and Maintenance Instructions Troubleshooting BEFORE CALLING FOR SERVICE TROUBLESHOOTING GUIDE If you think your Marvel product is malfunctioning, read the DANGER CONTROL OPERATION section to clearly understand the function of the control. ELECTROCUTION HAZARD. Never attempt to repair or...
Page 20
1-YEAR LIMITED PARTS AND LABOR WARRANTY For one year from the date of original purchase, this Marvel product warranty covers all parts and labor to repair or replace any part of the product that proves to be defective in materials or workmanship. For products installed and used for normal residential use, material cosmetic defects are included in this warranty, with coverage limited to 60 days from the date of original purchase.
Page 21
800.223.3900 for directions on how to obtain warranty coverage in your area. • If the product is outside the first year warranty period, Marvel Customer Service can provide recommendations of service centers in your area. A listing of authorized service centers is also available at www.marvelrefrigeration.com under the...
Page 22
www.marvelrefrigeration.com 1260 E. VanDeinse St. Greenville, MI 48838 800.223.3900 05/10/19 30606 Rev_C...
Need help?
Do you have a question about the MA15CRS1XS and is the answer not in the manual?
Questions and answers