Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Minuteman Bio-Haz Vacuum
Summary of Contents for Minuteman Bio-Haz Vacuum
- Page 1 Parts and Instruction Manual Bio-Haz Vacuum...
- Page 2 This manual is furnished with each new MINUTEMAN Bio-Haz Vacuum. This provides the necessary operating and preventive maintenance instructions. Operators must read and understand this manual before operating or servicing this machine. This machine was designed to give you excellent performance and efficiency. For best results and minimal cost, please follow the general guidelines below: ·...
- Page 3 Parts and Instruction Manual...
-
Page 4: Table Of Contents
Changing Of Prefilters ........................6 Exploded Views ..........................7 Lid Assembly ........................... 7 Lid Assembly BOM .......................... 8 Cloth Bag Assembly ........................10 Tools and Accessories ........................11 Minuteman International Made Simple Commercial Limited Warranty ........12 Parts and Instruction Manual... -
Page 5: Important Safety Instructions
FOR COMMERCIAL USE ONLY IMPORTANT SAFETY INSTRUCTIONS When using an electrical appliance, basic precautions should always be followed, including the following: READ ALL INSTRUCTIONS BEFORE USING DANGER! - THIS VACUUM IS FOR PICK UP OF PARTICULATE MATERIAL ONLY. NOT FOR VAPOR RECOVERY. WARNING - To reduce the risk of fire, electric shock, or injury: •... -
Page 6: Inspection
Inspection Carefully unpack and inspect your machine for shipping damage. Each unit is tested and thoroughly inspected before shipment, and any damage is the responsibility of the delivery carrier who should be notified immediately. Electrical 115 Volt This machine is designed to operate on a standard 15 amp. 115 volt, 60 hz, AC circuit. Voltages below 105 volts AC or above 125 volts AC could cause serious damage to the motor. -
Page 7: User Maintenance Instructions
WARNING This vacuum may contain potentially hazardous dust depending on its appilcation. Special handling of contaminated disposal bags and filters is recommended. Disposal must be in compliance with local EPA regulations User Maintenance Instructions All service and repair should be performed by qualified vacuum service representative or electrician. No user serviceable components are employed in the electrical vacuum lid head assembly. -
Page 8: Operation And Filter Care Instructions
Operation and Filter Care Instructions The Minuteman Bio-Haz Vacuum has been specifically designed to clean up hazardous dust of all types. Special filters reduce the incidence of airborne dust that would be created by any other method of cleaning. • During the removal of hazardous dust, do not sweep, scoop, shovel, or in any manner handle other than by vacuuming. -
Page 9: Changing The Black Foam Prefilter
(Cont’d) Procedures In Removing Contaminated Filters and Cleaning of Contaminated Tank 6. Slowly pull the top of the plastic bag upwards. When you have the plastic bag fully extended upwards, slowly squeeze the plastic bag closed to avoid trapping excess air. Twist the plastic bag until enough plastic can be tied into a knot. -
Page 10: Filter Assembly
Filter Assembly 1) Intake 2) Disposable Paper Collector Bag, 384003PKG (10/pkg) 3) Bio Hazard Plastic Bag, 802206PKG (10/pk) 4) Disposable Paper Filter Protector, 761177PKG (10/pkg) 5) Cloth Filter w/Frame 6) Prefilter 7) U.L.P.A Filter 8) Safety Interlock 9) Exhaust Changing Of Prefilters In order to prolong the efficiency and performance of the critical filter it is recommended that each pre-filter, debris bag and paper filter protector be changed every time the debris bag is full. -
Page 11: Exploded Views
Exploded Views Lid Assembly Parts and Instruction Manual Page 7... -
Page 12: Lid Assembly Bom
Lid Assembly BOM ITEM PART NO. REQ’D DESCRIPTION 110030PKG PREFILTER SLEEVE, 829/839, PKG OF 6 110029 FILTER-ULPA, X829 SERIES 290017 MOULDED VAC MOTOR GASKET 290031 LID GSKT 294/6 DIECUT 290032 DOME SEAL 296 380001-4 MOTOR-VAC BYPASS 120V (ECM) W/ WIRES 380054 MOTOR-VAC 240V 6125-00 380005... - Page 13 Tank Assembly BILL OF MATERIAL - 290010-3 ITEM PART NO. REQ’D DESCRIPTION 390087 GASKET DIECUT VNN 390110 INTAKE ASSEMBLY ALUMINUM 460109 TANK 6GAL LOW INTAKE 460114 LATCH POLY TNK 460115 DOLLY, PLAST VAC TNK BLK 460118 CASTER 711160 SCR-HI/LO #10 X 5/8 ZINC 712320 WSR .22 X .45 X .04 NYL 712638...
-
Page 14: Cloth Bag Assembly
Cloth Bag Assembly Item Part No. Qty. Description 760244MCH Molded Bag Ring 760406PLT Bag Frame 805040 Cloth Bag Only, 6G 712764 SS Washer #10 711909 Pop Rivet 800056 Bag Asy Complete Parts and Instruction Manual Page 10... -
Page 15: Tools And Accessories
Tools and Accessories Part No. Description 800083 3” Rd Dust Brush Complete 133249 Dust Brush HSG 3” 800084 Bristle Insert 3” 808023 Adapter 800035 12” Crev Tool Complete 290000 Wand Asy 1-1/2”, Complete 290001 290002 800317 Hose Assy. 1-1/2” x 10’... -
Page 16: Minuteman International Made Simple Commercial Limited Warranty
A potential health hazard exits without original equipment replacement. All warranted items become the sole property of Minuteman or its original manufacturer, whichever the case may be. Minuteman disclaims any implied warranty, including the warranty of merchantability and the warranty of fitness for a particular purpose.