Table of Contents
Advertisement
Available languages
Available languages
MAJOR GENERATOR FEATURES
Honda GX390 engine
—
Electric Start
Cast-iron cylinder sleeve
Low lubricant alert system
Receptacles on control panel
Cord Retainers
Automatic voltage regulator (AVR)
8 gallon metal fuel tank
Analog Hour Meter
Portability Kit
CONTROL PANEL
A. 120 V, 20 Ampere Duplex Receptacle
20 amps of current may be drawn from each half of the recep-
tacle. However, total power drawn must be kept within nameplate rat-
ings. These receptacles may be used along with the twistlock recep-
tacle provided the generator is not overloaded.
B. 120/240 V, 30 Ampere Twistlock Receptacle
A maximum of 30 amps may be drawn from the 120/240 volt
receptacle, provided it is the only receptacle used. However, current
must be limited to the nameplate rating. If the 120/240 volt receptacle
is used along with the 120 volt receptacle, the total load drawn must
not exceed the nameplate ratings.
C. Circuit Breakers
The receptacles are protected by an AC circuit breaker. If the
generator is overloaded or an external short circuit occurs, the circuit
breaker will trip. If this occurs, disconnect all electrical loads and try
to determine the cause of the problem before attempting to use the
generator again. If overloading causes the circuit breaker to trip, re-
duce the load. NOTE: Continuous tripping of the circuit breaker
may cause damage to generator or equipment. The circuit breaker
may be reset by pushing the button of the breaker.
D. Engine On/Off Switch
E. Cord Retainer
The cord retainer is used to prevent plugs from being pulled out
of the 120-volt receptacles.
F. Analog Hour Meter
A
F
D
ON
OFF
START
120V AC/CA
ENGINE SW.
OFF
ON
Cord
CIRCUIT PROTECTOR
Retainer
E
390 cc
120V/240 AC/CA
120V AC/CA
NEUTRAL FLOATING
NEUTRAL FLOTAS
Cord
Retainer
C
This generator model is provided with both electric start and re-
coil start capabilities. Avoid prolonged cranking, as it can damage the
engine.
The battery provided is a nominal 12 volt sealed rechargeable
lead-acid battery and can be operated in any position without leak-
age. It complies with non-spillable battery regulations. Its convenient
size offers a 30% reduction over conventional batteries.
Length = 7.14 inches, Width = 3.03 inches,
Height = 6.59 inches, Weight = 12.56 lbs
18AH Rating
UL Recognized
Battery Kit Parts List
Item Description
A
*Bolt, M5 x M12 ............... 2
B.
*Nut, 5 mm ....................... 2
C.
*Flat Washer, M5 ............. 2
* These are standard parts available at your local hardware store.
Note: Brand New Generators are shipped with the Battery Con-
nections disconnected. The Positive and Negative Terminals
must be connected to the Battery before the Electric Start Fea-
ture will work.
Initial Battery Connection - Refer to Installation Instructions Below.
Battery Removal & Installation:
Removal: Remove the nut and bolt from the negative and posi-
tive post, being careful not to short across the terminals. (Shorting
the terminals together can cause sparks, damage to the battery or
generator or even burns or explosions.) Always abide by the safety
warnings provided with the battery. Remove the battery and dispose
of according to local and state regulations.
Installation: Hook up the new battery, or re-install the new bat-
tery, as follows: Place the battery in the position provided. Connect
the red wire to the positive (+) terminal and the black wire to the nega-
tive (-) terminal with the bolt, nut, and washer provided. Make sure
all connections are tight. Your battery is now connected and ready
for use.
wARNING:
To reduce the risk of electrocution or explosion,
circuit the battery terminals or charge in a sealed container. Keep
sparks and flame away.
B
POSITIVE ( + )
TERMINAL
ELECTRIC START
Qty
BLACK WIRE
REd WIRE
do not short
NEGATIVE ( – )
TERMINAL
Advertisement
Table of Contents
