Mainstreet Equipment 541FF40N User Manual page 17

User Manual
E F
NTREE RYERS
CHECKING AND ADJUSTING AUTO SAFETY PILOT
CHECKING AND ADJUSTING AUTO SAFETY PILOT
The pilot flame should surround the thermopile for 1/2". It must be large and sharp enough to cause the
The pilot flame should surround the thermopile for ½". It must be large and sharp enough to cause the thermopile to
thermopile to glow a dull red, or sufficient to hold the safety valve open.
glow a dull red, or sufficient to hold the safety valve open.
1. Remove pilot adjustment cap
1. Remove pilot adjustment cap.
2. Adjust pilot key to provide properly
sized flame shown in diagram B.
2. Adjust pilot key to provide properly sized
Diagram A shows an improperly
flame as shown in diagram B.
adjusted pilot
Diagram A shows improperly adjusted pilot.
3. Release pilot adjustment cap.
3. Replace pilot adjustment cap.
TROUBLESHOOTING





NOTE: Vibrations or shock caused by shaking or pounding baskets on top surface or by slamming door may
cause Hi-Limit Control Switch to open. If this condition persists, additional cushioning may be added to the
rubber grommets supporting this control to absorb these shocks.
Mainstreet Equipment
www.AvantcoEquipment.com
User Manual





















S
ERVICE
17
5