Page 1
OWNER’S MANUAL POWERSPORTS AT110 WARNING AT110 UNDER No one under the age of 16 should Operation of this ATV by children operate this UTV under the age of 10 increases the risk of severe injury or death. Adult supervision required for children under age 10.
Page 2
WARNING Operating, servicing and maintaining a passenger vehicle or o -road vehicle can expose you to chemicals including engine exhaust , carbon monoxide, phthalates, and lead, which are known to the state of California to cause cancer and birth defects or other reproductive harm.
Page 3
This vehicle must only be assembled and prepped in accordance to the Assembly Instructions included with this vehicle. If you have not received Assembly Instructions for this vehicle contact Coleman Powersports toll free 888-405-8725. Death or serious injury could result from failure to follow these warnings and instructions.
Page 4
INTRODUCTION Thank you for purchasing the Coleman Powersports AT110. This ATV is designed for years of reliable use and family fun. This manual will provide you with a good basic understanding of the features and operation of this ATV. This manual includes important safety information. It also includes general riding techniques, maintenance and inspection procedures.
Page 6
The Emissions Control Warranty can be found on page 39. THE WARRANTY Coleman Powersports o ers the following warranty to the initial purchaser of this new Coleman Powersports product. The initial purchaser is de ned as the rst person to purchase a new Coleman Powersports product from an Authorized Retailer.
Page 7
Please do not return the product to the retailer where the product was purchased unless instructed to do so by Coleman Powersports. The retailer of this product does not make any warranty on behalf of Coleman Powersports without the approval of Coleman Powersports. A COPY OF YOUR VEHICLE...
Page 8
This warranty does not cover and Coleman Powersports disclaims any responsibility for: Any implied warranties are limited to the duration set forth in this warranty. Coleman Powersports does not make any claim as to the merchantability of tness for a particular purpose which would extend longer than the duration of this written warranty.
TABLE OF CONTENTS WARNING Location of Safety Labels ............4 Safety Information ..............4 UNDER Engine Stop, Lanyard Cord & Remote ........5 Aftermarket Accessories & Modifications........ 5 Description ................7 Control Layout ................ 8 Controls & Functions .............. 8 Operation of this ATV by children under the age of 10 increases the risk of severe injury Pre-ride Safety Checks ............
Page 10
UNDER 10 psi(69.0kpa) 10 psi(69.0kpa) Operation of this ATV by children under the age of 10 increases the risk of severe injury or death. Adult supervision required for children under age of 16. NEVER permit children under age 10 to operate this ATV.
ATV. If a label becomes di cult to read or comes o , request a new replacement label by calling Coleman Powersports 888-405-8725. SAFETY INFORMATION THE COLEMAN POWERSPORTS AT110 ATV IS NOT A TOY AND CAN BE HAZARDOUS TO OPERATE. MAKE SURE YOU UNDERSTAND ALL INSTRUCTIONS.
Installing aftermarket parts and/or accessories could void your Coleman Powersports Installing aftermarket parts and/or accessories could void your Coleman Powersports Installing aftermarket parts and/or accessories could void your Coleman Powersports...
Page 13
Avoid Carbon Monoxide Poisoning! All engine exhaust contains carbon monoxide, a deadly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, confusion, and eventually death. Carbon Monoxide is a colorless, odorless tasteless gas which may be present even if you do not see or smell any engine exhaust. Deadly levels of carbon monoxide can collect rapidly and you can quickly be overcome and unable to save yourself.
DESCRIPTION LEFT SIDE RIGHT SIDE Air Filter Front Shock Rear Cargo Fuse 15Amp Rack Fuel Cap Spark Arrester Front Bumper Cover Foot Rest Gear Shifter Fuel On/Off Valve Engine Oil Spark Plug Dip Stick Rear Shock...
CONTROL LAYOUT Parking Brake Lock Button Speed Limiter Rear Brake Lever Brake Lever Brake Lever Front Brake Lever Main Switch Throttle Lever Choke Lever Use fuel stabilizer if using ethanol fuel. Ignition OFF CONTROLS & FUNCTIONS Ignition ON IGNITION SWITCH The positions of the main switch are as follows.
Page 16
SPEED LIMITER The AT110 is equipped vehicle speed limiter adjusting screw. Beginning riders should start with the red The Coleman Powersports AT110 is equipped vehicle speed limiter adjusting screw. Beginning riders should The Coleman Powersports AT110 is equipped vehicle speed limiter adjusting screw.
Page 17
Either the non-adjustable or adjustable speed limiter screw must be installed for NOTICE operation. Failure to install a speed limiter screw may result in water or dirt ingestion and potential damage to the vehicle. SPEED LIMITER 1. Loosen lock locknut 2.
Page 18
Always set the parking brake before starting the engine. The ATV could start moving unexpectedly if the parking brake is not applied. This could cause loss of control or a collision. Always be sure you have released the parking brake before you begin riding. The brakes could overheat if you ride the ATV without releasing the parking brake.
Page 19
Check the operation of the throttle lever. It must open smoothly and spring back to the idle position when released. If sun can cause fuel to spill out of the fuel tank. throttle is not operating properly DO NOT START ENGINE. Contact Coleman Powersports customer service at 888-405-8725 in order to arrange service.
Do not operate the vehicle if any problem is discovered. If a problem cannot be cannot be corrected by the procedures described in this manual, have the vehicle corrected by the procedures described in this manual, contact Coleman Powersports if the ATV is still under warranty or located an authorized Coleman Powersports service center.
Page 22
ITEM ROUTINE PAGE Throttle Lever • Make sure that operation is smooth. Lubricate cable and lever housing if necessary. • Check lever free play, and adjust if necessary. Control Cables • Make sure that operation is smooth. Lubricate if necessary. Drive Chain •...
Page 23
Check the operation of the throttle lever. It must open smoothly and spring back to the idle position when released. throttle is not operating properly DO NOT START ENGINE. Contact Coleman Powersports customer service at throttle is not operating properly DO NOT START ENGINE. Contact Coleman Powersports customer service at throttle is not operating properly DO NOT START ENGINE.
Page 24
CHASSIS FASTENERS Make sure that all nuts, bolts and screws are properly tightened before starting engine. STARTING ENGINE (COLD) Set the parking brake. (The engine can be started only when the rear front/rear brake lever is applied.) Turn the fuel valve lever to the on position. Turn the ignition key to the on position.
Page 25
ENGINE BREAK-IN Proper engine break-in will increase the lifespan of your Coleman Powersports vehicle. The engine break-in period is the Proper engine break-in will increase the lifespan of your Coleman Powersports vehicle. The engine break-in period is the Proper engine break-in will increase the lifespan of your Coleman Powersports vehicle. The engine break-in period is the Proper engine break-in will increase the lifespan of your Rival Motorsports vehicle.
Page 26
Overloading your Rival Motorsports ATV could cause a lack of control resulting in severe Overloading your Coleman Powersports ATV could cause a lack of control resulting in Overloading your Coleman Powersports ATV could cause a lack of control resulting in...
Page 28
This ATV is intended for use by operators 10 years of age and This ATV is intended for use by operators 10 years of age and WARNING WARNING This ATV is intended for use by operators 6 years of age and older.
Page 29
Never carry a passenger. Carrying a passenger on this ATV greatly reduces your ability to balance and control this ATV. You could have an accident, resulting in severe injury or death to you and/or your passenger. The long seat is to allow the operator to shift position as needed during operation.
Page 30
Protective clothing Protective Goggles Protective Gloves Protective Boots Protective Helmet Do not operate after or while consuming alcohol or drugs. Consuming alcohol or drugs could seriously affect your judgment, cause you to react more slowly, and affect your balance and perception. Never consume alcohol or drugs before or while driving this ATV.
Page 31
DURING RIDING Always keep your feet on the foot boards during operation; otherwise, they may contact the rear wheels. Removing even one hand or foot can reduce your ability to control the ATV or could cause you to lose your balance and fall off of the ATV. If you remove a foot from a foot board, your foot or leg may come into contact with the rear wheels, which could injure you or cause an accident.
Page 32
Never operate this ATV on any public street, road or highway, even a dirt or gravel one. You could collide with another vehicle. Know the terrain where you ride. Ride cautiously in unfamiliar areas. Stay alert for holes, rocks, or roots in the terrain, and other hidden hazards which may cause the ATV to upset.
Page 33
You could collide with another vehicle if operating in off-road areas where you cannot for other vehicles Do not ride in areas posted “no trespassing.” Do not ride on private property without getting permission. OPERATING YOUR COLEMAN POWERSPORTS ATV: OPERATING YOUR COLEMAN POWERSPORTS ATV: OPERATING YOUR COLEMAN POWERSPORTS ATV: OPERATING YOUR RIVAL MOTORSPORTS ATV: area is free of obstacles and other riders.
Page 34
STEERING YOUR ATV To achieve maximum traction while riding off road, the two rear wheels turn together at the same speed. Therefore, unless the wheel on the inside of the turn is allowed to slip or lose some traction, the ATV will resist turning. A special turning technique must be used to allow the ATV to make turns quickly and easily.
Page 35
Avoid higher speeds until you are thoroughly familiar with the operation of your ATV. Always check the terrain carefully before attempting any hill. In all cases avoid inclines with slippery or loose surfaces, or obstacles that might cause you to lose control. UPHILL RIDING To climb a hill, you need traction, momentum, and steady throttle.
Page 36
Stalling, rolling backwards or improperly dismounting while climbing a hill could result in ATV overturning. If you cannot control the ATV, dismount immediately on the uphill side. DOWNHILL RIDING When riding your ATV downhill, shift your weight as far to the rear and uphill side of the ATV as possible.
Page 37
WATER CROSSINGS The ATV can be used to cross slow moving, shallow water of up to a maximum of 11 cm (4 in) in depth. Before entering the water, choose your path carefully. Enter where there is no sharp drop off, and avoid rocks or other obstacles which may be slippery or upset the ATV.
Page 38
Care should be used when riding on loose or slippery surfaces since the ATV may slide. If unexpected and uncorrected, sliding could lead to an accident. To reduce the tendency for the front wheels to slide in loose or slippery conditions, positioning your weight over the front wheels will sometimes help.
MAINTENANCE CAUTION that service be performed by an authorized Coleman Powersports service center. that service be performed by an authorized Coleman Powersports service center. that service be performed by an authorized Coleman Powersports service center. recommended that service be performed by an authorized Rival Motorsports dealer.
Page 41
PERIODIC MAINTENANCE CHART FOR THE EMISSION CONTROL SYSTEM • For ATVs not equipped with an odometer or an hour meter, follow the month maintenance intervals. • For ATVs equipped with an odometer or an hour meter, follow the km (mi) or hours maintenance intervals. However, keep in mind that if the ATV isn’t used for a long period of time, the month maintenance intervals should be followed.
Page 42
GENERAL MAINTENANCE AND LUBRICATION CHART INITIAL EVERY WHICHEVER COMES FIRST Month CHECK OR km (mi) 1300 2500 2500 5000 MAINTENANCE JOB (200) (800) (1600) (1600) (3200) ITEM Hours Air Filter Element • Clean and replace if necessary. Every 20-40 hours (more often in wet or dusty areas) Front Brake* •...
Page 43
GENERAL MAINTENANCE AND LUBRICATION CHART CONTINUED WHICHEVER COMES FIRST INITIAL EVERY Month CHECK OR km (mi) 1300 2500 2500 5000 MAINTENANCE JOB (200) (800) (1600) (1600) (3200) ITEM Hours Wheel Hub • Check for looseness or damage, and replace if necessary. Bearings* Chassis •...
Page 44
GENERAL MAINTENANCE AND LUBRICATION CHART CONTINUED WHICHEVER COMES FIRST INITIAL EVERY Month CHECK OR km (mi) 1300 2500 2500 5000 MAINTENANCE JOB (200) (800) (1600) (1600) (3200) ITEM Hours Moving Parts and • Lubricate Cables* • Check operation and correct if necessary. Throttle Lever Housing and •...
Page 45
PERIODIC MAINTENANCE RECORD MAINTENANCE SERVICING DATE SERVICING DEALER OR PERSON REMARK INTERVAL PERFORMED...
EMISSION CONTROL SYSTEM WARRANTY Below is the emission control system warranty printed in the owner’s manual, the copy of the owner’s manual is available upon your request. YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board, the U.S. Environmental Protection Agency, and Tao Motor Inc. (hereinafter “Tao Motor”) are pleased to explain the emission control system warranty on your 2017 Model Year ATV.
Page 47
dealers or contracted service shop is available in your area, repairs may be performed at any available service establishment, or by any individual, using any replacement part. The manufacturer will reimburse the owner for the expenses, including diagnostic charges by order to receive compensation, the owner may reasonably be required to keep receipts and failed parts and send to Tao Motor Inc., 2201 dealership involved.
Page 48
You are responsible for presenting your vehicle to the Tao Motor’s dealer as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. As the vehicle owner, you should be aware that Tao Motor may deny If you use your vehicle in any type of sanctioned competitive event, this warranty is immediately and completely void.
Page 49
emission control system warranty terms stated in this warranty. The foregoing statements of warranty are exclusive and in line of all other remedies. Some states do not allow limitations on how long an implied warranty lasts so the above limitations may not apply to you.
Page 50
POWERSPORTS (888) 405-8725 1775 E. University Dr., Tempe, AZ. 85281 www.colemanpowersportsusa.com www.facebook.com/colemanpowersportusa www.instagram.com/colemanpowersports_usa...
Need help?
Do you have a question about the AT110 and is the answer not in the manual?
Questions and answers