Related Manuals for JETSURF JETSURF ULTRA SPORT
Summary of Contents for JETSURF JETSURF ULTRA SPORT
- Page 1 USER MANUAL versions 18-R001/EN_part A p a r t m o d e l s JETSURF ULTRA SPORT JETSURF FACTORY GP JETSURF RACE...
-
Page 2: Symbols Used
C Z - M S R This symbol is used to mark important warnings which are often Craft Identification Number (CIN): ignored by the JetSurf users. Please pay due attention to these J S U warnings. You will thus avoid making frequent user mistakes. -
Page 3: User Manual
This user manual does not include detailed maintenance or repair instructions. If you experience any problems, neers to push the limits of motor sports. The power boards created by JetSurf™ are the only motorized water contact the manufacturer of the vessel or its representative. If you have the maintenance manual, please follow vehicles with the ability to be transported by hand, car, boat or plane (as hand luggage on international/ it during the vessel maintenance. -
Page 4: Table Of Contents
JUMPS ON JETSURF . . . . . . . . . . . . . . . . . . 16... -
Page 5: Warnings
Before using this vehicle, read the following plates. If you have any questions, consult a sales repre- 3 – warning on the ICU 4 – sticker MSR 0717/H1-EN situated at the snorkel sentative of JetSurf™. 5 – stickers MSR 0616/D1-EN and MSR 0316/D2-EN situated on the engine complement hood PLACE ENGINE SHUT-OFF KEY... -
Page 6: 2A Safety Matters
Basic safety information is provided and it is not all-inclusive. JetSurf™ strongly encourages all owners and operators to regularly review the U.S. Coast Guard safety information (www.uscg.mil and www.uscgboating.org)* and other safe- ty-minded, watercraft websites and authorities which apply to the relevant area/region under which the JetSurf™... -
Page 7: Definition
All riders must use helmet, life vest and a safety leash at all times while operating JetSurf™ to prevent any serious injury or death in the events of accident (you can find more details in CLOTHING category). -
Page 8: Engine Preparation
This could result in damage to the engine that would not be covered The use of an arm or leg leash is compulsory and must be used at all times while using JetSurf™. under warranty. -
Page 9: Law Enforcement
In many jurisdictions, it will not be necessary to register the power board with the state of principal injuries that may occur. Owners must not allow any Third Party to operate the JetSurf™ without prior use. However, because the power board is motorized, registration may be necessary. Verify with the instruction in correct use and operational risks. -
Page 10: Other Safety Matters
JetSurf™ power board will be operated. For operators in the United States, refer to the - Be at least sixteen (16) years old or the minimum age required within the jurisdiction in which the website*: www.uscg.boating.org... - Page 11 JetSurf™ cannot anticipate every circumstance that can occur in operating the power board. The information provided is general in nature and may not apply to the location in which you will be operating the power board. Always perform due diligence in prepa- ration and planning for all outings, with particular attention to doing so in the safest manner possible.
-
Page 12: 3A Ride
STERN Ultra Sport and Every JetSurf™ is supplied with a light stand. The stand should be used on a solid levelled surface and FACTORY GP it is only used to keep the JetSurf motorized power board in a comfortable height. Use of the JetSurf stand is strongly recommended to keep the JetSurf motorised power board above the ground, it is intended as an aid for preparation, maintenance and cleaning of the motorized power board. -
Page 13: Straps
STRAPS or its vapours present as an electric discharge could cause an explosion, JetSurf™ have fully adjustable straps. They can be adjusted by pulling the loose ends of straps with which may result in serious injury or death. force or by means of plastic buckles. Make sure that the straps are comfortable and are not too The battery power the electronic system of the motorized power board. - Page 14 OF THE CAPACITY. MODE1: BAL. CHARGE – it is intended for charging after the last IN WINTER OR WHEN NOT USING JETSURF, IT IS NECESSARY TO CHARGE THE BATTERY IN THE ICU MINIMUM ONCE IN EVERY 3 MONTHS. ride of the day. Select this mode when charging JetSurf for the first time.
-
Page 15: Fuel Top-Up
PETROL TO OIL MIXTURE 1 part of oil To 1 litre of petrol NEVER add fuel into the tank which is inside the JetSurf™. Before adding add 0.02 l (20 ml) of oil fuel, ALWAYS take the tank out. 50 : 1... -
Page 16: Start And First Ride
10 seconds can result in permanent damage to the engine and ex- haust system. Such damage is not covered by the guarantee. DO NOT leave JetSurf™ in direct sunlight or anywhere that would allow its surface to rise to a temperature in excess of 65°C/149°F. Excessive temperatures can cause damage to the engine. -
Page 17: Jetsurf Starting
RIDE BRIEF DESCRIPTION OF STARTING If the JetSurf™ is ready (the chapter Before start), you can start using it. To check whether the engine is working and warmed-up, first try the device out of water – BEFORE EVERY RIDE. 1 . STAGE- ICU activation... -
Page 18: Starting In Deep Water Or After Falling Down
It is not necessary to keep the full speed but when the speed is the path of any other vessel and there is no swimmer or obstacle near your JetSurf. When standing not sufficient, the vessel becomes unstable and more difficult to control. -
Page 19: Jetsurf Control - Stopping/Falling
A BRIEF LIST OF THE TASKS TO BE DONE AFTER THE RIDE As soon as the rider pulls the power board from water, lean it against something with its tip up and wait for a while until most of the water has run out of the JetSurf . Place the JetSurf... -
Page 20: Engine
F I G U R E 5 6) Put the spark plug boots back in place and se- 3) Tilt the JetSurf™ towards the spark plug opening down (its head engine) . When the valve is open and cure it with a boot holder. -
Page 21: 4A Storage
ABSOLUTELY NECESSARY to wash the fuel tank completely before air transport of your In winter or when JetSurf is not used, it is necessary to charge the battery in ICU at least once in every power board. Wash the tank with water and detergent. Repeat washing as long as you can still smell 3 months. -
Page 22: Maintenance
(signalling LED must not be lit or flashing). you do not use your JetSurf for a long time, follow the instructions specified in the chapter LONG-TERM Do not remove the boot from the spark plug if there is water in the en- STORAGE, 40/part A. -
Page 23: Maintenance Of Freewheel
MAINTENANCE MAINTENANCE APPLYING LUBRICANT IN THE FREEWHEEL spark plug holder You can find freewheel under cover in the middle of carbon gear cover on the side of the engine. It is boot spark plug necessary to refill grease every 25 Engine hour while following instructions. boot PROCEDURE: –... -
Page 24: Maintenance Of Exhaust Ending
MAINTENANCE OF ELECTRIC BILGE PUMP AFTER TAKING DOWN CARBON GEAR COVER The bilge pump suck water from the internal area of JetSurf . It is a vital part for the JetSurf opera- tion. During every ride, check whether the pump work properly. Keep the suction filter clean. -
Page 25: Table Of Regular Maintenance
Klueber Isoflex LD18 owner(s) of the boat who purchase(s) the boat within twelve (12) consecutive months of the earlier of (a) the date purchased by the first retail purchaser through an authorized JetSurf™ Sales facility, or (b) grease Special A... - Page 26 Conditions may exist outside of JetSurf™’s control, which may exclude or limit the scope of the war- as to conform at the time of sale with applicable regulations, and that the engine is free from defects ranty statement..
- Page 27 Law. You are entitled to a replacement or refund for a major failure and for compensation for ranted by JetSurf™ for the period of time before the first scheduled replacement date for that part. any other reasonably foreseeable loss or damage. You are also entitled to have the goods repaired or Emission warranty parts that are scheduled for regular inspection, but not regular replacement, are replaced if the goods fail to be of acceptable quality and the failure does not amount to a major failure.
-
Page 28: 8A Troubleshooting
OR IS IN ANY DOUBTS REGARDING THEIR ABILITY TO PERFORM THE RE- PAIR, IT IS NECESSARY TO LEAVE THE REPAIR TO THE QUALIFIED MECHA- NICS OF JetSurf™ COMPANY WHO HAVE BEEN TRAINED BY THE MANU- FACTURER AND ARE CERTIFIED FOR IT. -
Page 29: Check Of The Spark Plug And Timing Sensor Function
F I G U R E 1 DIAGNOSTICS Required tools: spark plug spanner supplied by A) If the spark plug does not spark, proceed JetSurf (accessories) - 21 mm. according to the table on page 53 - TROUBLE- CONNECTING THE MOUNTING TOOL FOR SHOOTING, 1st line highlighted dark. - Page 30 TROUBLESHOOTING CERTIFICATES spanner. If the spark plug is brand new, tighten it with a spanner by 2/3 of a turn. If the spark plug has been used before, tighten it only by 1/8 – 1/4 of a turn. WHEN TIGHTENING THE SPARK PLUG, FOLLOW THE INSTRUCTIONS FROM THE SPARK PLUG MANUFACTURER! 13) Place the boot on the spark plug.
- Page 31 CERTIFICATES CERTIFICATES 1 8 - R 0 0 1 / E N _ p a r t A 1 8 - R 0 0 1 / E N _ p a r t A...
- Page 32 Helmet and Life Vest. The use of an arm or leg leash is compulsory and must be used at all times. 15) Allow any Third Party or Persons to use the JetSurf™ without prior instruction and train- ing in correct use and operational risks.
- Page 33 Helmet and Life Vest. The use of an arm or leg leash is compulsory and must be used at all times. 15) Allow any Third Party or Persons to use the JetSurf™ without prior instruction and train- E-mail: ing in correct use and operational risks.
- Page 34 I have completed training conducted by an Authorized JetSurf™ representative and understand For service and ordering spare parts please contact what steps must be undertaken to ensure the JetSurf™ board(s) are maintained, cared for, ser- FIRST YOUR SELLER/DISTRIBUTOR! viced and strored.
- Page 35 .jetsurf .com...