TABLE OF CONTENTS Confirm that you have the right pump: Safety Instructions ............2 Applications and Operating Ranges ........ 2 Installation ..............3 Electrical ................. 4 Operation ................ 5 Maintenance ..............6 Troubleshooting ............10 Warranty ............... 11 Repair Parts ..............12 Dimensions ..............
INSTALLATION Table I – Minimum Pumping Rates Flow Series Minimum Pumping Rate Risk of electric shock. Can shock, burn or kill. Ground pump motor correctly before connecting BVM(I/X)1 1.0 GPM to power supply, per article 250-80 of the National BVM(I/X)3 1.5 GPM Electrical Code (NEC) in the U.S., or the Canadian BVM(I/X)5...
If the system pressure is greater than the pump’s against running dry. The highest point of the loop should maximum inlet pressure the limits of the pump can be at least as high as the lowest point of the motor. This be exceeded if the discharge pressure backs up to the loop/valve combination will allow the pump and the inlet side of the pump.
OPERATION Operation of open systems with the liquid level below the top of the pump: Priming NOTICE: The suction pipe requires a check valve or Risk of explosion and scalding. Do not run isolation valve. the pump with the discharge valve closed; the water in 1.
Starting 1. If a suction line isolation valve has been installed, check to be sure that it is completely opened. 2. For initial starting, the isolation valve in the discharge pipe should be almost closed. 3. Start the pump. 4. When the piping system has been filled with liquid, slowly open the discharge isolation valve until it is completely open.
Page 7
13. Reinstall the coupling (43) on the pump and motor Pump Shaft Flange shaft. If the pump has a shaft pin, the pin axially Head locates the pump shaft. If the pump does not have a shaft pin, then set the coupling so that it grips equal lengths of the pump and motor shaft.
Page 8
10. BVM1–BVM20: Slide the motor stool (36) over the listed in Table III. Place the motor stool (53) on staybolts (81) and onto the sleeve (48). Slide the the pump head and fasten it with four pump head pump head (36) over the staybolts onto the stack bolts (74A).
Page 9
Regular Maintenance Checks 13. Follow Steps 11–19 under Motor Replacement to reinstall the motor. The following checks should be made at regular intervals: Risk of explosion and scalding. Do not run 1. The pump meets required performance and is pump with discharge valve closed; the water in the pump operating smoothly and quietly.
TROUBLESHOOTING Risk of electrical shock and possible unexpected starts. Disconnect all power to the pump before servicing or working on pump. Make sure that power is locked out and that pump cannot be accidentally started. Problem Cause A. Power failure B.
Limited Warranty BERKELEY warrants to the original consumer purchaser (“Purchaser” or “You”) of the products listed below, that they will be free from defects in material and workmanship for the Warranty Period shown below. Product Warranty Period Water Systems: whichever occurs first: Water Systems Products —...
Page 15
Component BVM10 BVMI10, BVMX10 BVM15, BVM20 BVMI/X15, BVMI/X20 Discharge Discharge Discharge Discharge Diffuser, Normal Diffuser, Normal Diffuser, Normal Diffuser, Normal Diffuser, with Bearing Diffuser, with Bearing Diffuser, with Bearing Diffuser, with Bearing Bearing Bearing Bearing Bearing Impeller Impeller Impeller Impeller Wear Ring Wear Ring Wear Ring...
Page 16
REPAIR PARTS Cast Iron Stainless Models Models BVM33 BVM(I/X)33 BVM45 BVM(X)45 BVM64 BVM(X)64 BVM90 BVM(X)90 Stainless Cast Iron Flanged Flanged Figure 12...
Page 17
BVMI33, BVMX33, BVMX45, Component BVM33, BVM45, BVM64, BVM90 BVMX64, BVMX90 Diffuser, Top Diffuser, Top Diffuser, Normal Diffuser, Normal Diffuser, with Bearing Diffuser, with Bearing Bearing Sleeve Bearing Sleeve Impeller Impeller Collet Collet Collet Nut Collet Nut Strap Retainer Strap Retainer Pump Head Pump Head Shaft...
Page 18
REPAIR PARTS Cast Iron Stainless Models Models BVM120 BVMX120 BVM150 BVMX150 15HP~60HP 75HP~100HP Cast Iron Stainless Flanged Flanged Figure 13...
Page 19
Component BVM120, BVM150 BVMX120, BVMX150 Diffuser, Top Diffuser, Top Diffuser, Normal Diffuser, Normal Diffuser, with Bearing Diffuser, with Bearing Bearing Sleeve Bearing Sleeve Impeller Impeller Collet Collet Collet Nut Collet Nut Strap Retainer Assemby Strap Retainer Assembly Strap Retainer Strap Retainer Pump Head Pump Head Shaft...
PUMP DIMENSIONS BVM/BVMI/BVMX 1 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 22
PUMP DIMENSIONS BVM/BVMI/BVMX 1 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 24
PUMP DIMENSIONS BVM/BVMI/BVMX 3 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 26
PUMP DIMENSIONS BVM/BVMI/BVMX 3 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Safety Motor & & Number Factor Phase Voltage Frame Only...
Page 28
PUMP DIMENSIONS BVM/BVMI/BVMX 5 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 30
PUMP DIMENSIONS BVM/BVMI/BVMX 5 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Safety Motor & & Number Factor Phase Voltage Frame Only...
Page 32
PUMP DIMENSIONS BVM/BVMI/BVMX 10 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 34
PUMP DIMENSIONS BVM/BVMI/BVMX 10 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Safety Motor & & Number Factor Phase Voltage Frame Only...
Page 36
PUMP DIMENSIONS BVM/BVMI/BVMX 15 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Safety Motor & & Number Factor Phase Voltage Frame Only...
Page 37
PUMP DIMENSIONS BVM/BVMI/BVMX 15 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Safety Motor & & Number Factor Phase Voltage Frame Only...
Page 38
PUMP DIMENSIONS BVM/BVMI/BVMX 20 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 39
PUMP DIMENSIONS BVM/BVMI/BVMX 20 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Safety Motor & & Number Factor Phase Voltage Frame Only...
Page 40
PUMP DIMENSIONS BVM/BVMI/BVMX 33 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 41
PUMP DIMENSIONS BVM/BVMI/BVMX 33 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Safety Motor & & Number Factor Phase Voltage Frame Only...
Page 42
PUMP DIMENSIONS BVM/BVMX 45 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 43
PUMP DIMENSIONS BVM/BVMX 45 PUMP DIMENSIONS – STANDARD BVMX Flange (ANSI) Flange (ANSI) 3" 250 lb.R.F. 3" 250 lb.R.F. 8 x Ø.88" 8 x Ø.88" G 1/2 G 1/2 4 x Ø.56" 4 x Ø.56" Ø3.13" Ø3.13" 10.56" 10.44" 13" 13"...
Page 44
PUMP DIMENSIONS BVM/BVMX 45 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 45
PUMP DIMENSIONS BVM/BVMX 45 PUMP DIMENSIONS – METRIC BVMX Flange (ANSI) Flange (ANSI) 3" 250 lb.R.F. 3" 250 lb.R.F. 8 x Ø22 8 x Ø22 G 1/2 G 1/2 4 x Ø14 4 x Ø14 Ø80 Ø80 G 1/2 G 1/2 G 1/2 G 1/2 G 1/2...
Page 46
PUMP DIMENSIONS BVM/BVMX 64 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 47
PUMP DIMENSIONS BVM/BVMX 64 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 48
PUMP DIMENSIONS BVM/BVMX 90 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 49
PUMP DIMENSIONS BVM/BVMX 90 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 50
PUMP DIMENSIONS BVM/BVMX 120 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 51
PUMP DIMENSIONS BVM/BVMX 120 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 52
PUMP DIMENSIONS BVM/BVMX 150 PUMP DIMENSIONS – STANDARD BVM Cast Iron BVMI/BVMX Stainless Steel Dimensions in inches Weight in Lbs Dimensions in inches Weight in Lbs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Page 53
PUMP DIMENSIONS BVM/BVMX 150 PUMP DIMENSIONS – METRIC BVM Cast Iron BVMX Stainless Steel Dimensions in mm Weight in kgs Dimensions in mm Weight in kgs Motor Pump Pump Pump Pump Model Motor Service Motor & & Number Factor Phase Voltage Frame Only...
Need help?
Do you have a question about the Berkeley BVM Series and is the answer not in the manual?
Questions and answers