Battery - Gasoline Vehicle - Club Car Turf 1 2007 Owner's Manual

BATTERY – GASOLINE VEHICLE
See General Warnings on page 17.
ý
DANGER
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and
service area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full
face shield and rubber gloves when working on or near batteries.
• Follow all instructions carefully when working with batteries.
• Charge battery in a well-ventilated area only.
• Battery – Poison! Contains acid! Causes severe burns. Avoid contact with skin, eyes, or
clothing. Antidotes:
- External: Flush with water. Call a physician immediately.
- Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable
oil. Call a physician immediately.
- Eyes: Flush with water for 15 minutes. Call a physician immediately.
ý
WARNING
• Do not jump-start a dead battery using another battery and jumper cables.
The battery in a Club Car gasoline vehicle is a 12-volt, low-maintenance battery that requires infrequent
watering (Figure 27).
Figure 27 Battery
Any corrosion around the positive (+) or negative (–) terminals should be washed off with a solution of baking
soda and water (1 cup (237 mL) per gallon (3.8 L) of water). Rinse solution off the battery. Do not allow this
solution to get into the battery. Be sure terminals are tight (battery terminals should be tightened to 12 ft-lb (16
N·m)). Let the terminals dry and then spray them with Battery Terminal Protector Spray (CCI 1014305). See
following CAUTION.
ý
CAUT ION
• If battery wire terminals are damaged or corroded, they should be replaced or cleaned as
necessary. Failure to do so may cause them to overheat during operation and could result in a
fire, property damage, or personal injury.
LEVEL
INDICATOR
Figure 28 Gasoline Battery Electrolyte Level
2007 Turf/Carryall Vehicle Owner's Manual
Battery – Gasoline Vehicle
BATTERY
CAP
PLATES
ELECTROLYTE
LEVEL AT LEAST
1/2 INCH (13 MM)
ABOVE
PLATES OR
TO LEVEL
INDICATOR
Page 53