Vehicle Controller - Electric Vehicles; Batteries - Electric Vehicles - Club Car Turf 1 2007 Owner's Manual

VEHICLE CONTROLLER – ELECTRIC VEHICLES
The Club Car electric vehicle is equipped with a solid state speed controller. In order to properly service and
maintain the solid state controller vehicle, it is necessary to understand the electrical circuitry and the func-
tions of all components in the system. Therefore, if any repair or servicing needs to be performed, we recom-
mend that it be performed by an authorized Club Car distributor/dealer using Club Car OEM parts.
BATTERIES – ELECTRIC VEHICLES
See General Warnings on page 17.
ý
DANGER
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and
service area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full
face shield and rubber gloves when working on or near batteries.
• Charge batteries in a well-ventilated area only. Batteries emit hydrogen while being charged.
Hydrogen is an explosive gas and must never exceed a level of 2% of the air.
• Battery – Poison! Contains acid! Causes severe burns. Avoid contact with skin, eyes, or
clothing. Antidotes:
- External: Flush with water. Call a physician immediately.
- Internal: Drink large quantities of milk or water followed with milk of magnesia or vegetable
oil. Call a physician immediately.
- Eyes: Flush with water for 15 minutes. Call a physician immediately.
ý
WARNING
• Wear safety glasses or approved eye protection when servicing the vehicle or battery charger.
Wear a full face shield and rubber gloves when working on or near batteries.
• Use insulated tools when working near batteries or electrical connections. Use extreme
caution to avoid shorting of components or wiring.
• Ensure battery connections are clean and properly tightened. See Battery Care on page 48.
• Use only 4-gauge (AWG) wires with low-resistance terminals to replace battery wires on IQ
Plus models.
CAUT ION
• Turn off all accessories before charging batteries.
NOTE: Recycle or dispose of discarded batteries in accordance with local, state, and federal regulations.
Club Car electric vehicles use deep-cycle batteries. Automotive batteries should never be used in electric
vehicles.
New batteries will not deliver their full capabilities until they have been discharged and recharged 20 to 50
times. To obtain maximum service life from new batteries, restrict the use of vehicles with new batteries to one
hour of operation between charges for the first two months vehicle is in service. Batteries should be fully
charged before first use of new vehicle, before first use of a vehicle after storage, and before releasing vehicle
for use each day.
Vehicle Controller – Electric Vehicles
2007 Turf/Carryall Vehicle Owner's Manual Page 47