Remove, unwrap, and temporarily lay aside any parts that are not attached to the range. Make sure no parts are left in the carton for accidental disposal. Carefully inspect the range for damage. The open burners are held in place with a shipping screw to protect them while in transit.
The gas supply line must be at least the same size or greater than the inlet line of the range. All FiveStar ranges use a ½” NPT inlet. Check any installer-supplied intake pipes and fittings visually and...
Page 5
Do not forget to relight the pilot on other gas appliances when you turn the gas back on. Because hard piping restricts movement of the range, the use of an AGA- certified flexible metal appliance connector is recommended unless local codes require a hard-piped connection.
Page 6
FLOW OF AIR FOR COMBUSTION OR VENTILTION. SEE FIG. 2. Positioning/Leveling To position the range use a lift jack or enough manpower to lift the range completely. Avoid sliding, pushing, or pulling the range because this increases the possibility of bending the legs or the coupling connectors and could also result in damage to the floor covering.
Ultra High-Low™ Sealed Burners FiveStar sealed burner models may not be adjusted without factory authorization. Please call 800-251-7224 to inquire about sealed burner adjustments. ALL ADJUSTMENTS AND/OR...
Depending on the particular features of your FiveStar range, there may be one, two, or three shut-off valves. Manual shut-off valves will always be ordered from left to right in the following manner: 1.
Copper has always proven itself to be the most dependable conductor. However, many homes may be wired to connect to a range by means of aluminum wiring. This is not an ideal situation, and we urge you to have a qualified electrician change to a copper cord connection.
Never allow children to play with the range controls. The range and pans on it can be hot. Do not allow anyone to climb on the range or use it or the doors for stepping, leaning, or sitting. Possible hazards or injuries may result. It is recommended that items not be stored on, in, or above the range.
When replacing an oven light bulb, be sure the oven is cool. Disconnect power to the range, and use a dry cloth to handle the bulb. Do not heat unopened food containers in the oven. Pressure could build up and the container could burst causing injury.
Contact your dealer for the name of a local authorized service agency. If none is available, contact FiveStar’s factory Parts & Service Department by calling 1-800-251- 7224. Telephone hours are from 8:00am to 5:00pm, Eastern Time, Monday through Thursday, and from 8:00am to 4:00pm on Fridays.
3. THESE AREAS MUST REMAIN OPEN AND UNOBSTRUCTED. Cooking Utensils Most cooking utensils are suitable for use on the FiveStar, and it is not necessary to replace your present domestic utensils with commercial cookware. Cookware should be in good condition and free of excessive...
Page 14
Aluminum Foil in Oven and Broiler Aluminum foil is a cause of many range fires. Make certain that vents or air openings are not covered by foil. If the vents located along the sides of the oven bottom are blocked, poor cooking and burner performance will result.
For best results, bake foods on one rack at a time as described in this manual. However, very good results can be obtained when baking on multiple racks using the TurboFlow convection feature. The convection oven is suggested for multiple rack cooking, especially three rack cooking.
Broiling Broiling times vary depending on a meat’s thickness, fat content, and personal taste. Always be careful when handling hot broiler pans. Use both hands and oven mitts when handling. Serious injury can result due to spillage of hot grease. Gas Broiling Never leave a dirty broiler pan in place.
CLEANING THE RANGE OR COOKTOP Make certain all parts of the range are cool before cleaning. Be sure to replace all parts correctly. Knobs Pull forward to remove the control knobs. Wash with warm, soapy water. Do not use abrasive or harsh cleansers or scrub with abrasive materials.
Gas ovens have removable floors for easier cleaning. To remove the gas oven floor, first remove racks from the oven. If the range has a convection fan, remove the front screws around the assembly to remove the cover. If the oven does not contain convection, skip this step.
Page 19
LIFT-OFF OVEN DOOR FIG. 19 LIFT-OFF DOOR MECHANISM To remove oven door(s) Open door fully. Rotate the Hinge Retainers into the locked position, as shown, over the hook located on the bottom side of each hinge quadrant. Lift the door slightly to clear the hinge slots, and pull straight out to clear hinge mechanism from main...
CLEANING THE ELECTRIC OVEN Each FiveStar electric oven contains a self-clean cycle. These self-cleaning electric ovens clean with very high temperatures (well above cooking temperatures) which reduce soils to a fine powdered ash for easy clean up with a damp cloth.
Page 21
To Unlock the Door After Self-Clean Keep the oven dial in CLEAN position. Push and hold the momentary door lock switch on the control panel while moving the door lock handle to the right until it stops. Turn the oven control knob to OFF position.
Page 29
Wiring Range Connection Cord (For Dual-Fuel Ranges Only) FIG. 24 FIG. 23 WARNING!!! THIS APPLIANCE MUST BE CONNECTED AS SHOWN IN FIG. 23 OR FIG. 24. IF A CORD IS UTILIZED IT MUST BE RATED AT 250 VOLTS, 40 AMPERES, AND CERTIFIED FOR USE...
14” in diameter. A wok is not included. Optional Accessories These accessories pieces may be purchased from a local authorized FiveStar dealer. To find a dealer near you, visit www.fivestarrange.com. Portable FiveStar Griddle For Use with Open Burners Only...
Page 31
For 4” Low-Profile Range Backguard Models BKG024, 030, 036, 048, and BKT060; Range Island Trim Models RBT024, 030, 036, 048, and BKT060; Cooktop Island Trim Models TBT036 and 048; and Side Trim Models SST002 and SST007. See Part Descriptions below.
Service Department by calling 1-800- 251-7224 or 423-476-6544, or email customerservice@fivestarrange.com. If service repair requires installation of parts, use only FiveStar parts to ensure protections under the warranty. This manual should remain with the range at all times for service reference.
Burned out light bulb. c. Defective switch. Correction a. Connect range to wall outlet or check circuit breaker or fuse box. b. Have servicer rate burner. c. Clean ports with a straight pin. d. Place burner in proper position on valve and burner hanger.