Advertisement
6. operAtion
WARNING! Read the safety instructions at the start of this
document before using this product.
Wear suitable protective clothing i.e. Gloves, Eye Protection,
and reinforced work boots.
6.1
towing the trailer/cart.
noTE: The maximum towing speed for this product is 10mph.
6.1.1 Do not exceed the 230kg weight capacity of the cart.
6.1.2 only tow the trailer/cart with recommended vehicles i.e. Lawn/
Garden tractors and small ATVs (All Terrain Vehicles) e.g.
Quadbike.
6.1.3 Ensure that the trailer cart is correctly connected to the towing
hitch on the vehicle and that the hitch pin is retained with the
'R' clip provided.
6.1.4 It is your responsibility to ensure that the towing vehicle is
adequate to tow the trailer and its load. Check that the brakes
are powerful enough. Check that the gross weight of the trailer
plus its load does not exceed the towing capacity of the
vehicle. The vehicle manufacturer's recommended towing limit
should be in the vehicle manufacturer's handbook.
6.1.5 Always ensure that the rear panel is in place before loading the
cart with loose material otherwise the sides may be pushed out
making it difficult to attach the rear panel.
6.1.6 Use extreme caution when operating the vehicle and trailer on
sloping land especially when the cart is filled to capacity. If in
doubt about stability in any situation, do not proceed.
6.1.7 for best handling and traction always ensure that the load is
evenly distributed in the cart.
6.2
to dump material from the cart.
6.2.1 To dump material from the cart firstly ensure that the cart is in
the right position and that no one is in the dumping area.
6.2.2 Remove the rear panel prior to dumping and stand clear of the
cart.
6.2.3 To tip the load, press the foot pedal. Gravity will ensure that a
full load is swiftly shed and therefore no parts of your body
should be in the way of the tipping container.
6.2.4 once the load is shed, take hold of the upper edge of the
container and pull it back down onto the trailer/cart chassis
until it latches back into the notch in the foot pedal lever.
6.2.5 Immediately refit the rear panel ensuring that the alignment
pins have engaged.
WARNING! Do not tow the trailer with the container in the
tipped position.
6.3
Use as a flat bed trailer.
6.3.1 By removing the back, front and side panels the trailer/cart can
be used as a flat bed for transporting items that are bigger than
the area of the trailer base such as fencing panels and other
sheet material.
6.3.2 Do not exceed the maximum weight capacity of 230kg.
6.3.3 over-sized loads must be properly strapped to the trailer/cart
to prevent them moving during transit.
6.3.4 Care should be taken when transporting over-sized loads that
items projecting from the trailer do not collide with people or
buildings and other fixtures and fittings such as gates and
doorways.
WARNING! It is not recommended that the trailer be towed
with the side and front panels folded down. Always remove the
panels to prevent them making contact with objects on the
ground especially in areas of rough terrain.
NOTE: It is our policy to continually improve products and as such we reserve the right to alter data, specifications and component parts without prior notice.
IMPORTANT: no liability is accepted for incorrect use of this product.
WARRANTY: Guarantee is 12 months from purchase date, proof of which will be required for any claim.
INFORMATION: for a copy of our latest catalogue and promotions call us on 01284 757525 and leave your full name and address, including postcode.
7. MAintenAnce & StorAge
7.1
7.1.1 After each use, clean any material out of the trailer/cart.
7.1.2 If necessary rinse and dry the inside and outside of the trailer/
7.1.3 Regularly check the tyre pressures. The recommended
7.1.4 Grease the axle and wheel bearings every 6 months or more
7.1.5 Periodically check all fasteners for tightness.
7.1.6 Annually clean and lightly lubricate parts.
7.1.7 Use a matching glossy enamel spray paint to touch up
7.2
7.2.1 never allow materials to remain in the trailer cart for extended
7.2.2 never store the trailer/ cart in a wet condition.
7.2.3 Store indoors or in a protected area during the winter and other
Sole UK Distributor, Sealey Group,
Kempson Way, Suffolk Business Park,
Bury St. Edmunds, Suffolk,
IP32 7AR
Original Language Version
Maintenance.
cart.
pressure is 25 PSI.
regularly if required.
scratched or worn painted metal surfaces.
Storage.
periods of time.
periods of severe weather.
01284 757500
01284 703534
www.sealey.co.uk
Web
sales@sealey.co.uk
email
TBB230
Issue no.1
17/11/11
Advertisement
