Page 1
All manuals and user guides at all-guides.com...
Page 2
All manuals and user guides at all-guides.com...
Page 3
All manuals and user guides at all-guides.com Preface Notebook Computer M660SE/M665SE Service Manual...
Page 4
All manuals and user guides at all-guides.com Preface Notice The company reserves the right to revise this publication or to change its contents without notice. Information contained herein is for reference only and does not constitute a commitment on the part of the manufacturer or any subsequent ven- dor.
Page 5
This manual is intended for service personnel who have completed sufficient training to undertake the maintenance and inspection of personal computers. It is organized to allow you to look up basic information for servicing and/or upgrading components of the M660SE/ M665SE series notebook PC.
Page 6
All manuals and user guides at all-guides.com Preface IMPORTANT SAFETY INSTRUCTIONS Follow basic safety precautions, including those listed below, to reduce the risk of fire, electric shock and injury to per- sons when using any electrical equipment: 1. Do not use this product near water, for example near a bath tub, wash bowl, kitchen sink or laundry tub, in a wet basement or near a swimming pool.
Page 7
All manuals and user guides at all-guides.com Preface Instructions for Care and Operation The notebook computer is quite rugged, but it can be damaged. To prevent this, follow these suggestions: Don’t drop it, or expose it to shock. If the computer falls, the case and the components could be damaged. Do not expose the computer Do not place it on an unstable Do not place anything heavy...
Page 8
All manuals and user guides at all-guides.com Preface 4. Avoid interference. Keep the computer away from high capacity transformers, electric motors, and other strong mag- netic fields. These can hinder proper performance and damage your data. 5. Take care when using peripheral devices. Use only approved brands of Unplug the power cord before peripherals.
Page 9
All manuals and user guides at all-guides.com Preface Battery Precautions • Only use batteries designed for this computer. The wrong battery type may explode, leak or damage the computer. • Do not continue to use a battery that has been dropped, or that appears damaged (e.g. bent or twisted) in any way. Even if the computer continues to work with a damaged battery in place, it may cause circuit damage, which may possibly result in fire.
Page 10
All manuals and user guides at all-guides.com Preface Related Documents You may also need to consult the following manual for additional information: User’s Manual on CD This describes the notebook PC’s features and the procedures for operating the computer and its ROM-based setup pro- gram.
External Locator - Left & Right Side Views ........1-8 External Locator - Bottom View .............1-9 SYSTEM BLOCK DIAGRAM ............B-2 M660SE Mainboard Overview - Top (Key Parts) ......1-10 CLOCK GENERATOR ..............B-3 M660SE Mainboard Overview - Bottom (Key Parts) ....1-11 CPU-1 .....................B-4 M660SE Mainboard Overview - Top (Connectors) ......1-12...
Page 12
All manuals and user guides at all-guides.com Preface CRT & LVDS ................B-25 CPU FAN, LPC ROM ..............B-26 MINI-PCI & BLUETOOTH ............B-27 AUDIO VT1708A/ALC883 ............B-28 LED ....................B-29 CHARGER, DC IN ..............B-30 1.05VS, 1.5V, 2.5VS ..............B-31 VCORE ..................
Chapter 1: Introduction Overview This manual covers the information you need to service or upgrade the M660SE/M665SE series notebook computer. Information about operating the computer (e.g. getting started, and the Setup utility) is in the User’s Manual. Information about drivers (e.g. VGA & audio) is also found in User’s Manual. That manual is shipped with the computer.
All manuals and user guides at all-guides.com Introduction System Specifications Latest Specification Information The specifications listed in this Appendix are correct at the time of going to press. Certain items (particularly processor types/speeds and CD/DVD device types) may be changed, delayed or updated due to the manufacturer's release schedule. Check with your service center for details.
Page 15
All manuals and user guides at all-guides.com Introduction Feature Specification Security Security (Kensington® Type) Lock Slot BIOS Password BIOS One 4Mb Flash ROM Phoenix™ BIOS 15.4" WXGA (1280 * 800) TFT LCD Video Adapter VIA VN896 Integrated Video System (Internal On Chip) Chrome 9HC™...
Page 16
All manuals and user guides at all-guides.com Introduction Feature Specification Power Supports ACPI 2.0 and PCI Bus Power Management 1.1 Battery Low Suspend Management Compliant Supports Wake on LAN Power Full Range AC/DC Adapter 19V, 3.42A or 18.5V, 3.5A (65W), 100~240V, 50~60Hz Battery 6 Cell Smart Lithium-Ion Battery Pack, 4000mAH Environmental...
All manuals and user guides at all-guides.com Introduction Model Differences The models vary slightly in external cover design and color. Figure 1 Model Differences M660SE M665SE System Specifications 1 - 5...
All manuals and user guides at all-guides.com Introduction External Locator - Top View with LCD Panel Open Figure 2 Top View 1. Optional Built-In PC Camera 2. LCD 3. Speakers 4. Power Button 5. Hot Key Buttons 6. Keyboard 7. TouchPad and Buttons 8.
All manuals and user guides at all-guides.com Introduction External Locator - Front & Rear Views Figure 3 Front Views 1. LED Indicators Figure 4 Rear Views 1. 1 * USB Port 2. DC-In Jack 3. Battery External Locator - Front & Rear Views 1 - 7...
All manuals and user guides at all-guides.com Introduction External Locator - Left & Right Side Views Figure 5 Left Side View 1. Security Lock Slot 2. Optical Device Drive Bay 3. RJ-11 Modem Jack 4. S/PDIF-Out Jack 5. Microphone-In Jack 6.
All manuals and user guides at all-guides.com Introduction External Locator - Bottom View Figure 7 Bottom View 1. Vent/Fan Intake 2. Battery 3. Hard Disk Bay Cover 4. CPU/RAM Bay Cover Overheating To prevent your com- puter from overheating make sure nothing blocks the vent/fan in-...
Chapter 2: Disassembly Overview This chapter provides step-by-step instructions for disassembling the M660SE/M665SE series notebook’s parts and sub- systems. When it comes to reassembly, reverse the procedures (unless otherwise indicated). We suggest you completely review any procedure before you take the computer apart.
All manuals and user guides at all-guides.com Disassembly NOTE: All disassembly procedures assume that the system is turned OFF, and disconnected from any power supply (the battery is removed too). Maintenance Tools The following tools are recommended when working on the notebook PC: •...
All manuals and user guides at all-guides.com Disassembly Maintenance Precautions The following precautions are a reminder. To avoid personal injury or damage to the computer while performing a re- moval and/or replacement job, take the following precautions: Power Safety Warning 1.
Page 30
All manuals and user guides at all-guides.com Disassembly Disassembly Steps The following table lists the disassembly steps, and on which page to find the related information. PLEASE PERFORM THE DISASSEMBLY STEPS IN THE ORDER INDICATED. To remove the Battery: To remove the Bluetooth: 1.
All manuals and user guides at all-guides.com Disassembly Removing the Battery 1. Turn the computer off, and turn it over. Figure 1 2. Slide the latches ( & ) the direction of the arrow, and hold latch in place. Battery Removal 3.
All manuals and user guides at all-guides.com Disassembly Removing the Hard Disk Drive The hard disk drive can be taken out to accommodate other 2.5" serial (SATA) hard disk drives with a height of 9.5mm Figure 2 (h). Follow your operating system’s installation instructions, and install all necessary drivers and utilities (as outlined in HDD Assembly Chapter 4 of the User’s Manual) when setting up a new hard disk.
Page 33
All manuals and user guides at all-guides.com Disassembly 4. Carefully grip the mylar tab and slide the hard disk in the direction of arrow. Figure 3 5. Lift the hard disk up Figure d in the direction of arrow. HDD Assembly 6.
All manuals and user guides at all-guides.com Disassembly Removing the System Memory (RAM) Figure 4 The computer has two memory sockets for 200 pin Small Outline Dual In-line Memory Modules (SO-DIMM) supporting RAM Module Removal DDRII 533/667MHz. The main memory can be expanded up to 2GB. The SO-DIMM modules supported are 256MB, 512MB and 1024MB DDRII Modules.
Page 35
All manuals and user guides at all-guides.com Disassembly 5. Gently push the two release latches ( & on the sides of the memory socket in the direction indicated by the Figure 5 arrows (Figure Memory Removal 6. The RAM module(s) will pop-up Figure d , and you can then remove it.
All manuals and user guides at all-guides.com Disassembly Removing the Processor Figure 6 Processor Removal 1. Turn off the computer, and remove the battery (page 2 - 5) and the CPU/RAM bay cover (page 2 - 2. The CPU heat sink will be visible at point on the mainboard.
Page 37
All manuals and user guides at all-guides.com Disassembly 5. Turn the release latch towards the unlock symbol , to release the CPU (Figure 6. Carefully (it may be hot) lift the CPU up out of the socket (Figure 7. Reverse the process to install a new CPU. 8.
All manuals and user guides at all-guides.com Disassembly Removing the Wireless LAN Module Figure 8 Wireless LAN 1. Turn off the computer, remove the battery (page 2 - 5) and the module bay cover (page 2 - Module Removal 1. The Wireless LAN module will be visible at point on the mainboard.
All manuals and user guides at all-guides.com Disassembly Removing the Modem Figure 9 Modem Removal 1. Turn off the computer, remove the battery (page 2 - 5), and remove the hard disk bay cover (page 2 - 2. The modem will be visible at point on the mainboard.
All manuals and user guides at all-guides.com Disassembly Removing the Bluetooth Module Figure 10 Bluetooth Removal 1. Turn off the computer, remove the battery (page 2 - 5) and remove the hard disk bay cover (page 2 - 2. The Bluetooth module will be visible at point on the mainboard.
All manuals and user guides at all-guides.com Disassembly Removing the Optical (CD/DVD) Device Figure 11 Optical Device 1. Turn off the computer, remove the battery (page 2 - Removal 2. Locate the hard disk bay cover and remove screws ( 3.
All manuals and user guides at all-guides.com Disassembly Removing the Keyboard Figure 12 Keyboard Removal 1. Turn off the computer, and remove the battery (page 2 - 2. Press the three keyboard latches at the top of the keyboard to elevate the keyboard from its normal position (you a.
Part Lists Appendix A:Part Lists This appendix breaks down the M660SE/M665SE series notebook’s construction into a series of illustrations. The com- ponent part numbers are indicated in the tables opposite the drawings. Note: This section indicates the manufacturer’s part numbers. Your organization may use a different system, so be sure to cross-check any relevant documentation.
The following table indicates where to find the appropriate part list illustration. Table A - 1 Part List Illustration Part Pages# Location page A - 3 Top - (M660SE) page A - 4 Top - (M665SE) page A - 5 Bottom - (M660SE/M665SE) page A - 6 LCD - (M660SE/M665SE)
All manuals and user guides at all-guides.com Part Lists Top (M660SE) Figure A - 1 Top (M660SE) 無鉛 無鉛 無鉛 無鉛 (太乙加邊框) 無鉛 無鉛 (銅釘設計變更)(無鉛) 無鉛 無鉛 鴻富 無鉛 無鉛 無鉛 無鉛 無鉛 無鉛 無鉛 Top (M660SE) A - 3...
All manuals and user guides at all-guides.com Part Lists Top (M665SE) Figure A - 2 Top (M665SE) 無鉛 無鉛 無鉛 無鉛 (太乙加邊框) 無鉛 無鉛 (銅釘設變) 無鉛 無鉛 (折角96度)(無鉛) 鴻富 無鉛 無鉛 無鉛 無鉛 無鉛 被 無鉛 無鉛 A - 4 Top (M665SE)
All manuals and user guides at all-guides.com Part Lists DVDRW (M660SE/M665SE) Figure A - 7 DVDRW (M660SE/ M665SE) DVDRW (M660SE/M665SE) A - 9...
Page 52
All manuals and user guides at all-guides.com Part Lists A - 10...
Page 53
All manuals and user guides at all-guides.com Schematic Diagrams Appendix B:Schematic Diagrams This appendix has circuit diagrams of the M660SE/M665SE notebook’s PCB’s. The following table indicates where to find the appropriate schematic diagram. Diagram - Page Diagram - Page Diagram - Page...
All manuals and user guides at all-guides.com Schematic Diagrams SYSTEM BLOCK DIAGRAM M660SU BLOCK DIAGRAM PWR_HOT BOARD HOTKEY LT BOARD Yonah 478 IMVP-6 VR CLOCK GEN uFCPGA ICS953009AF+ICS9P936AF USB BOARD FSB667 AUDIO&MODEM BOARD VGA G27M DDR2 SO-DIMM Sheet 1 of 40 VRAM NORTH BRIDGE VN896...
All manuals and user guides at all-guides.com Schematic Diagrams VN896-4 1.05VS 3.3VS BGA5E 1.5VS AE14 VCC15 AE16 VCC15 Y 14 AE18 VCC15 Y 15 AE20 VCC15 Y 16 AE21 VCC15 DVP2D00 Y 17 AE22 DVP2D00 VCC15 DVP2D01 Y 18 AJ10 DVP2D01 VCC15 DVP2D02...
All manuals and user guides at all-guides.com Schematic Diagrams VGA G72M-4 M660SE ALL DEL 1.8VS 1.8VS BGA3 BGA2 FBA_RAS# FBA_RAS# FBA_RAS# FBA_RAS# VD D FBA_CAS# FBA_CAS# FBA_CAS# FBA_CAS# VD D FBA_WE# FBA_WE# FBA_WE# VD D FBA_WE# FBA_CS0# FBA_CS0# FBA_CS0# FBA_CS0#...
All manuals and user guides at all-guides.com Schematic Diagrams VT8237A-2 VT8237R plus => 4.7K VT8237A => 6.12K 2.5VS 3.3V 2.5V 2.5VS AP339A SR EXT R 308 6.19K_1%_06 2.5VSATA FB14 H CB3216KF-800T30_12 IDE_PDD[0..15] C 447 C 440 2.5VS->2.5V 951101 ID E_PDD[ 0..15] .1U_50V_06 BGA6B .1U_50V_06...
All manuals and user guides at all-guides.com Schematic Diagrams For VIA platform 3.3V 3.3VLANPH 3.3VLANPH HC B2012KF-121T30_08 CR S# R257 33_04 C RS C RS 17 C 382 COL# R256 33_04 C OL 3.3V C OL 17 TXD 3 TXD 3 17 .
All manuals and user guides at all-guides.com Schematic Diagrams USB & CCD USB PORT 60 mil R122 470K_04 HCB2012K-500T40_08 USBVCC EMI solution,when placement OC0# near to USB Port? OC0# 5VS_CCD R132 560K_04 *HCB2012K-500T40_08 48 mil Z2207 HCB3216K-800T30_12 J_USB1 Z2201 60 mil AO3409 J_CCD1 Z2202...
Place D17, R349 for PR100 J_CRT1 R442 *1K_04 BAV99 BAV99 BAV99 DZ 11A91-ND208-4F FC M1608K-121T06_06 FRED Z2403 FC M1608K-121T06_06 FGRN Z2402 For M660SE USE FC M1608K-121T06_06 FBLU 24 mil *SCS751 75_1%_04 Z2404 951118 2.5VS PLLVCC 2.5VS LVDSVCC 2.5VS DVDD 75_1%_04...
All manuals and user guides at all-guides.com Schematic Diagrams CPU FAN, LPC ROM VDD5 FAN CONTROL 3.3VS 40MIL FW ROM 20mil VDD5 HCB2012K-500T40_08 C632 C633 Sheet 25 of 40 Z2503 .1U_50V_04 .1U_50V_04 10U_10V_08 PLT_RST# R503 100_04 Z2505 11,15,26 PLT_RST# RST# .1U_50V_04 PCLK_FWH CPU FAN,...
All manuals and user guides at all-guides.com Schematic Diagrams AUDIO VT1708A/ALC883 PLEASE PLACE CLOSE CODEC & 5VS_AUD Z2712 C739 270P_10V_06 AMP THE POWER INPUT PINS AU DG Z2713 C536 270P_10V_06 AU DG Z2714 C737 10U_10V_08 AU DG R714 0_06 C512 C502 C556 C731...
All manuals and user guides at all-guides.com Schematic Diagrams EXT GPU 1.0VS/1.2VS VI N PR136 Z 3402 PC148 10_06 PR139 PD22 1U_10V_06 PC60 PC54 PC58 1. 5M_04 F M0540-N SGND3 Z 3403 PQ44 .1U_25V_06 10U_25V_12 10U_25V_12 Z 3404 IRF7413ZPBF PR140 1.0V_EN EN/PSV 1.