Table of Contents
Advertisement
!
WARNING
A strong gas smell, or the hissing sound of gas
indicates a serious problem with your gas grill
or the LP gas tank. Failure to immediately follow
the steps listed below could result in a fire or
explosion that could cause serious bodily injury,
death, or property damage.
• Shut off gas supply to the gas grill.
• Turn the Control Knobs to OFF position.
• Put out any flame with a fire extinguisher.
• Open Grill Lid.
• Get away from the LP gas tank.
• Do not try to fix the problem yourself.
• If odor continues or you have a fire you
cannot extinguish, call your fire department.
Do not call near the LP gas tank because
your telephone is an electrical device and
could create a spark resulting in fire and/
or explosion.
NOTE: The normal flow of gas through the
regulator and hose assembly can create a
humming nosie. A low volume of nosie is
perfectly normal and will not interfere with
operation of the grill. If humming nosie is
loud and excessive you may need to purge
air from the gas line or reset the regulator
e x c e s s g a s f l o w d e v i c e . T h i s p u r g i n g
procedure should be done every time a new
LP gas tank is connected to your grill. For
help call the Customer Service Helpline for
assistance.
Customer Service Helpline, 8:00am - 5:00
pm EST, Monday through Friday at
1-800-667-7313.
Checking For Gas Leaks
Never test for leaks with a flame. Prior to first use,
at the beginning of each season, or every time your
LP gas tank is changed, you must check for gas leaks.
Follow these four steps:
1.
Make a soap solution by mixing one part liquid
detergent and one part water.
2.
Turn the grill Control Knobs to the full OFF
position, then turn the gas ON at source.
3.
Apply the soap solution to all gas connections.
If bubbles appear in the soap solution the con-
nections are not properly sealed. Check each
fitting and tighten or repair as necessary.
4.
If you have a gas leak that you cannot repair,
turn off the gas at the source, disconnect fuel line
from your grill and call 1-800-667-7313 or your gas
supplier for repair assistance.
Grill Lighting Instructions
Basic Lighting Procedures
1.
Familiarize yourself with the safety guidelines
at the f ront of this manual. Do not smok e
while lighting grill or check ing gas supply
connections.
2.
Be sure the LP gas tank is filled.
3.
Check that the end of each Burner Tube is
properly located over each valve orifice.
4.
Make sure all gas connections are securely
tightened..
5.
Open the Grill Lid.
!
Failure to open Grill Lid during the lighting
procedures could result in a fire or explosion
that could cause serious bodily injury, death,
or property damage.
Set control knobs to OFF and open the LP gas
6.
tank valve slowly until 1/4 to 1/2 open.
OFF
7.
Push and turn the RIGHT control knob to HIGH/ .
HIGH
8.
Immediately press the electric ignitor for 3-4
seconds to light the burner.
PRESS
9.
If the burner does not light, turn the control knob to
OFF, wait 5 minutes for gas to clear, then retry.
10.
Repeat steps to light each burner individually
11.
Adjust control knobs to your desired cooking
temperature.
19
WARNING
Open LP
gas tank
OFF
ELECTRIC
IGNITOR
Advertisement
Table of Contents
