Parker CRYSTAL-AIRE Owner's Manual
  1. Manuals
  2. Brands
  3. Parker Manuals
  4. Air Cleaner
  5. CRYSTAL-AIRE
  6. Owner's manual
Parker CRYSTAL-AIRE Owner's Manual

Parker CRYSTAL-AIRE Owner's Manual

Modular air cleaning systems
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
Modular Air Cleaning
Systems
Owner's Manual

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the CRYSTAL-AIRE and is the answer not in the manual?

Questions and answers

Related Manuals for Parker CRYSTAL-AIRE

Summary of Contents for Parker CRYSTAL-AIRE

  • Page 1 Modular Air Cleaning Systems Owner’s Manual...
  • Page 2 For quick future reference, fill in the system information in the spaces below. Should you need assistance, call the Parker Customer Service number shown below. To expedite your service, have the following information available when contacting Parker.

  • Page 3: Table Of Contents

    Page Safety Precautions ....................4 Introduction ......................6 Application .......................6 Air Changes Per Hour (Ach) ..................7 Specifications ......................7 Installing Your CRYSTAL-AIRE uv System ............8-9 ® Application ......................8 Inspection ......................8 Unpacking ......................8 Specification .......................8 Installation ......................8 Wall Mount ......................9 Ceiling Mount .....................9 Electrical Requirements ..................9...

  • Page 4: Safety Precautions

    UV lamp operation and filter element condition. local and national codes and regulations. • The CRYSTAL-AIRE uv system should not be used for ® • Do not operate UV without complete lamp enclosure in support of personnel or material.
  • Page 5 Installation of evaluate and understand potential combustion or deflagration Parker equipment should be by a licensed contractor that is hazards that may exist. In addition, NFPA standards require also experienced in potential fire and explosion hazards and...

  • Page 6: Introduction

    CRYSTAL-AIRE uv system should be established by your local ® Standard 170: Ventilation of Health Care Facilities. CRYSTAL- AIRE uv distributor or by PARKER sales represen- ® tative. When correctly applied, the CRYSTAL-AIRE uv may ® We have manufactured an air cleaner engineered to rigid help meet the ASHRAE reopening of schools and universities specifications and quality control checks.
  • Page 7 CHART 1 ACHCFM CHART for ROOM SIZES and AIR CHANGES PER HOUR (ACH) 150 ft 300 ft 400 ft 500 ft 600 ft 750 ft 1200 ft # ACH 10x15 15x20 20x20 20x25 20x30 25x30 30x40 1200 1125 1800 1000 1200 1500 2400...

  • Page 8: Inspection

    Notify your delivery carrier immedi- ately and enter a claim if any damage is found. Wall Mounting: 1. Remove the wall bracket from CRYSTAL-AIRE ® Unpacking 2. Locate an appropriate area on the wall to mount the...
  • Page 9 CRYSTAL-AIRE ® and the UV lamp will illuminate. It is typical that there is a slight fan delay on start-up and when changing speeds. 1. To install, carefully raise the CRYSTAL-AIRE uv to the ® mounting location. a. USE CAUTION WHEN LIFTING, UTILIZE LIFTING...
  • Page 10 FILTRATION / UV FUNCTION In any CRYSTAL-AIRE uv system, contaminated air is drawn ® PREFILTER through a 4 stage filtration chamber, cleaned and conditioned, This is a one-inch-thick disposable MERV 8 filter consist- then exhausted by the system blower. Airborne particles, both ing of pleated, glass fiber media inside a metal frame.
  • Page 11 The electrical interlock switch prevents power to the blower The power on/off switch is located on the outside of the and UV lamp when the access door or the pre-filter is not CRYSTAL-AIRE uv as part of the control panel area. This is a ®...

  • Page 12: Blower Module

    D A N G E R The following procedures will expose hazardous live and moving parts. Switch Off/isolate the electrical supply to the CRYSTAL-AIRE uv system. ® Due to the simplicity of the design, breakdowns are restricted to these components: •...
  • Page 13 FILTERS The pre-filter, main filter and carbon filter will require periodic replacement. Refer to filter changeout section below, however actual pre-filter and main filter replacement interval may vary depending on the quality of the air that which is being filtered. For dirty and dusty environments, the pre and main filter will require more frequent replacements whereas a cleaner envi- ronment will require less frequent pre and main filter replace-...
  • Page 14 PARTS ORDERING PART DESCRIPTION PART NUMBER REFERENCE Mobile Unit 01-10258-00 Wall Unit 01-10258-01 Ceiling Unit 01-10258-02 Hanging Unit 01-10258-03 Pre-filter DPHT-101 Main Filter MERV 13 2809349 Main Filter MERV 14 2909237 Main Filter HEPA 2971351 Power Switch EX0040-1 Fan Speed Selector Switch 20-2755 Indicator Lamp 20-1064...
  • Page 15 PARTS ORDERING Power Switch Fan Speed Selector Switch Odor Filter Fan Speed Selector Switch Knob Indicator Lamp Fuse Fan Motor Speed Selector Switch UV Lamp Differential Pressure Switch UV Lamp Ballast Caster Transformer Door Interlock Switch Main Filter HEPA, Optional MERV 13/14 Prefilter...

  • Page 16: Troubleshooting Guide

    Increase blower speed. (Refer to Fan Speed Selector, page 11). Contact your local distributor or Parker E. Fan on/off switch is on and 1. Faulty lamps Replace lamps illuminated, fan is operating, UV 2.
  • Page 17 CRYSTAL-AIRE uv SYSTEM WIRING DIAGRAM ®...
  • Page 18 MCB, PNP, SDC, SFC, and SHM series will be free from defects in materials and workmanship for ten (10) years from the date of shipment from Parker. Subject to the terms and conditions hereof, warrants to the original Buyer...
  • Page 20 Filtration Division EMEA Metamora, Ohio 419 644 4311 Arnhem, Netherlands +31 (0) 26 376 0376 © 2021 Parker Hannifin Corporation. Product names are trademarks or registered trademarks of their respective companies IOM_PKR_CRYSTALAIREuv_052021 PN: 44-10300-0001 Parker Hannifin Corporation Industrial Gas Filtration...

Table of Contents