Table of Contents
Advertisement
Installation Drawings
D2.5L G2–95 Gal Tank (10000028999, page 1 of 2)
4
INTERNAL DIVIDER PANEL
SEPARATES FUEL TANK
VENTILATION DUCT FROM THE
ENGINE, ALTERNATOR AND
EXHAUST SYSTEM
REMOVE PANEL TO ALLOW
TANK VENTS TO
TERMINATE OUTSIDE OF
THE GENERATOR
ENCLOSURE (CHECK LOCAL
AND STATE CODE FOR
APPLICABILITY)
B
209 [8.2]
EXHAUST OUTLET
580 [22.8]
EXHAUST OUTLET
RADIATOR/EXHAUST
DISCHARGE AIR
FUEL TANK
VENTILATION
DUCT
OPEN PUNCHED LOUVERS
TYPICAL ON BOTH SIDES
OF FUEL TANK
VENTILATION DUCT TO
PROVIDE ADEQUATE
CROSS-FLOW OF AIR
VENTILATION
EXHAUST MUFFLER
ENCLOSED WITHIN
A
GENERATOR ENCLOSURE
DRAWING CREATED FROM PRO/ENGINEER
3D FILE. ECO MODIFICATION TO BE
APPLIED TO SOLID MODEL ONLY.
4
Installation Guidelines for Protector Diesel Generators
3
884
[34.8]
CG
RADIATOR/EXHAUST
DISCHARGE AIR
RADIATOR DRAIN HOSE
AIR INTAKE
(BOTH SIDES)
COOLANT RECOVERY BOTTLE
(BOTH SIDES)
RADIATOR FILL CAP ACCESS
AIR CLEANER ELEMENT
REFERENCE OWNERS MANUAL FOR PERIODIC
REPLACEMENT PART LISTINGS.
BATTERY 12 VOLT
REMOVE COVER FOR
NEGATIVE GROUND
ACCESS TO RADIATOR
FILL CAP
TOP VIEW
631 [24.8]
DOOR WIDTH
TYP
1648 [64.9]
OVERALL
LEFT SIDE VIEW
3
SH
REV
WINDCHILL VERSION
1/2
A
SERVICE ITEM
2.5L
WEIGHT DATA WITH EMPTY BASETANK
(SEE NOTE 5)
OIL FILL CAP
RIGHT SIDE
GENERATOR AS SHOWN 797 [1757]
OIL DIP STICK
RIGHT SIDE
WITH WOODEN SHIPPING SKID 835 [1841]
OIL FILTER
RIGHT SIDE
OIL DRAIN HOSE
LEFT SIDE
WEIGHT: KG [LBS]
DIMENSIONS: MM [INCH]
RIGHT SIDE
LEFT SIDE
ROOF
LEFT SIDE
MUFFLER
FRONT
FAN BELT
EITHER SIDE
BATTERY
LEFT SIDE
REAR ENCLOSURE
COVER PANEL
SEE NOTE 4
CUSTOMER ACCESS
ASSEMBLY, CONTROL
PANEL ACCESS,
BATTERY CHARGER
LOCATED WITHIN
SEE NOTE 4
CIRCUIT BREAKER
HEIGHT
SEE NOTE 3
REMOVABLE
STUB-UP COVER
SEE NOTE 4
177 [7.0]
776 [30.6]
OVERALL WIDTH
LIFTING PROVISION (4 PLACES)
REAR VIEW
GENERAC POWER SYSTEMS OWNS THE COPYRIGHT OF THIS DRAWING
WHICH IS SUPPLIED IN CONFIDENCE AND MUST NOT BE USED FOR
ANY PURPOSE OTHER THAN FOR WHICH IT IS SUPPLIED WITHOUT
THE EXPRESS WRITTEN CONSENT OF GENERAC POWER SYSTEMS.
c GENERAC POWER SYSTEMS 2013
A.1
NOTES:
1. MINIMUM RECOMMENDED CONCRETE PAD SIZE: 1092 (43") WIDE X 1887 (74.3") LONG.
REFERENCE INSTALLATION GUIDE SUPPLIED WITH UNIT FOR CONCRETE PAD GUIDELINES.
2. ALLOW SUFFICIENT ROOM ON ALL SIDES OF THE GENERATOR FOR MAINTENANCE
AND SERVICING. THIS UNIT MUST BE INSTALLED IN ACCORDANCE WITH CURRENT
APPLICABLE NFPA 37 AND NFPA 70 STANDARDS AS WELL AS ANY OTHER FEDERAL,
STATE, AND LOCAL CODES.
3. CONTROL PANEL / CIRCUIT BREAKER INFORMATION:
- SEE SPECIFICATION SHEET OR OWNERS MANUAL
- ACCESSIBLE THROUGH CUSTOMER ACCESS ASSEMBLY DOOR ON REAR OF GENERATOR.
4. REMOVE THE REAR STUB-UP AND REAR ENCLOSURE COVER PANEL TO ACCESS
THE STUB-UP AREAS AS FOLLOWS:
- HIGH VOLTAGE CONNECTION INCLUDING AC LOAD LEAD CONDUIT CONNECTION,
NEUTRAL CONNECTION, AND BATTERY CHARGER 120 VOLT AC (0.5 AMP MAX) CONNECTION.
- LOW VOLTAGE CONNECTION INCLUDING TRANSFER SWITCH CONTROL WIRES
AND ACCESSORY RELAY CONNECTION (QTY 4)
5. CENTER OF GRAVITY AND WEIGHT MAY CHANGE DUE TO UNIT OPTIONS.
6. BOTTOM OF GENERATOR SET MUST BE ENCLOSED TO PREVENT PEST INTRUSION AND
RECIRCULATION OF DISCHARGE AIR AND/OR IMPROPER COOLING AIR FLOW.
7. REFERENCE OWNERS MANUAL FOR LIFTING WARNINGS.
8. MOUNTING BOLTS OR STUDS TO MOUNTING SURFACE SHALL BE 5/8-11 GRADE 5
(USE STANDARD SAE TORQUE SPECS)
9. MUST ALLOW FREE FLOW OF INTAKE AIR, DISCHARGE AIR AND EXHAUST. SEE SPEC
SHEET FOR MINIMUM AIR FLOW AND MAXIMUM RESTRICTION REQUIREMENTS.
10. GENERATOR MUST BE INSTALLED SUCH THAT FRESH COOLING AIR IS AVAILABLE
AND THAT DISCHARGE AIR FROM RADIATOR IS NOT RECIRCULATED.
LIFT OFF DOOR PROVIDES ACCESS
TO: FUEL FILL, FUEL LEVEL GAUGE,
NORMAL VENT, INNER TANK
EMERGENCY VENT, OUTER TANK
VISE ACTION LATCH, ONE
EMERGENCY VENT, OPTIONAL 90%
PER DOOR, ONE LIFT-OFF
ALARM ASSEMBLY, OPTIONAL 5
DOOR ON FRONT, RIGHT,
AND LEFT SIDES
706 [27.8]
TYP
1525 [60.0]
TYP
TYP
2052 [80.8]
OVERALL LENGTH
RIGHT SIDE VIEW
SEE NOTES 5, 7 AND
CENTER OF GRAVITY
DIMENSIONS
TITLE
INSTALL PROTECTOR D2.5L G2
95 GAL EXT TANK
ISSUE DATE:
06/2017
SIZE
CAGE NO
DWG NO
B
N/A
ELECTRONICALLY APPROVED
INSIDE WINDCHILL
SCALE
0.050
WT-KG
2
1
B
GALLON SPILL BOX
A
REV
10000028999
A
SEE ABOVE SHEET
1 of 2
1
39
Advertisement
Table of Contents
