Troubleshooting - Champion 93520 User Manual

TROUBLESHOOTING

Problem
Engine will not start .
Engine will not start;
Engine starts but runs roughly .
Engine shuts down during operation .
Engine cannot supply enough power or
overheating .
Wedge movement is slow or erratic .
Oil leak from hose connection .
Oil leak from cylinder .
Wedge will not extend or retract .
Wedge does not Auto-Return .
Excessive bouncing while towing .
For further technical support:
Technical Service
Mon – Fri 8:30 AM – 5:00 PM (PST/PDT)
Toll Free: 1-877-338-0999
tech@championpowerequipment .com
19
REV 93520-20120419
Cause
No fuel .
Faulty spark plug .
Unit loaded during start up .
Low oil level .
Choke in the wrong position .
Spark plug wire loose .
Out of fuel .
Low oil level .
Insufficient ventilation .
Air in the hydraulic oil system .
Debris lodged in beam guides .
Low hydraulic oil .
Loose hose clamp or hydraulic fitting .
Faulty cylinder rod seal .
Scored or bent cylinder rod .
Loose hydraulic fitting .
Faulty combination washer seal on
cylinder hydraulic fitting .
Faulty control valve .
Faulty hydraulic pump .
Low hydraulic oil .
Low hydraulic oil .
Faulty control valve .
Under-inflated tires .
ENGLISH
Solution
Add fuel .
Replace spark plug .
Remove load from unit .
Fill crankcase to the proper level .
Place log splitter on a flat, level surface .
Adjust choke
Adjust choke
Fill fuel tank
Fill crankcase to the proper level . Place
log splitter on a flat, level surface
Check for air restriction . Move to a
well ventilated area
Purge air by extending and retracting
the wedge several times until motion
is smooth .
Clear debris from beam .
Check oil level and add as needed .
Tighten hose clamp or hydraulic
fitting .
Contact Customer Service .
Contact Customer Service .
Tighten hydraulic fitting .
Contact Customer Service .
Contact Customer Service .
Contact Customer Service .
Check oil level and add as needed .
Check oil level and add as needed .
Contact Customer Service .
Inflate tires to proper pressure . Refer
to tire sidewall .
93520