Summary of Contents for Welbilt Manitowoc LB Manitowoc LB730
Page 1
Engineered for Ease LB Model Ice Storage Bins Installation, Operation and Maintenance Manual Caution Read this instruction before operating this equipment. Original Document Part Number: 000016538 Rev01 02/21...
Section 1 Installation Operation Maintenance Model Numbers 30 Inch Bin Dimensions This manual covers the following models 34” (86.4 cm) Single Door Upright Ice Storage Bins 30 inch wide 48 inch wide 60 inch wide LB1460 LB730 LB1448 LB1760 Before You Begin After uncrating and removing all packing material, inspect the equipment for concealed shipping damage.
Installation Operation Maintenance Section 1 Installation Procedure Drain Requirements 1. Remove hardware kit from bin. • Bin drain termination must have an air gap. • Legs • Drain lines must have a 1.5 inch drop per 5 feet of run (2.5 cm per meter), and must not create traps.
Page 5
Section 1 Installation Operation Maintenance Accessories Cleaning and Sanitizing Bin Interior Interior of bin must be cleaned and sanitized prior to use and K00499 48” Paddle must be cleaned on a routine basis during use. K00503 60” Paddle Ice storage bins must be descaled and sanitized every six K00500 37”...
Installation Operation Maintenance Section 1 Before Calling For Service Checklist If a problem arises during operation of your ice storage bin, follow the checklist below before calling service. Routine adjustments and maintenance procedures are not covered by the warranty. Problem Possible Cause To Correct Drain must be open site with an air gap and...
Section 1 Manuel d’installation et d’utilisation Numéros de modèle Dimensions du bac de 30 po Ce manuel concerne les modèles suivants : 34” (86.4 cm) Bacs à glaçons verticaux à porte unique 30 po de largeur 48 po de largeur 60 po de largeur LB1460 LB730...
Manuel d’installation et d’utilisation Section 1 Procédure d’installation 16. Lissez le bord en silicone pour créer un joint complet. Un joint en silicone insuffisant entraînera des fuites. 1. Retirez le jeu de pièces du bac. 17. Laissez sécher le silicone pendant 24 heures avant •...
Page 9
Section 1 Manuel d’installation et d’utilisation Nettoyage et désinfection de l’intérieur du bac POUR UN ACCÈS PLUS LARGE Lorsqu’un accès plus large est nécessaire ou pour favoriser L’intérieur du bac doit être nettoyé et désinfecté avant utilisation l’écoulement : et doit être nettoyé régulièrement pendant l’utilisation. 1.
Manuel d’installation et d’utilisation Section 1 Liste de contrôle avant d’appeler un technicien Si un problème survient pendant le fonctionnement de votre bac à glaçons, suivez la liste de contrôle ci-dessous avant d’appeler un technicien. Les réglages et les procédures d'entretien de routine ne sont pas couverts par la garantie. Problème Cause possible Pour corriger...
Page 11
Sección 1 Manual de instalación y operación Números de modelo Dimensiones del recipiente de 30 pulg. Este manual cubre los siguientes modelos 34” (86.4 cm) Recipientes verticales de almacenamiento de hielo de una puerta 30 pulg. de ancho 48 pulg. de ancho 60 pulg.
Manual de instalación y operación SecciónSección 1 Procedimiento de instalación 16. Alise el borde de silicona para crear un sello absoluto. Un sello de silicona insuficiente provocará fugas. 1. Extraiga el kit de tornillería del recipiente. 17. Permita que la silicona se seque durante 24 horas antes •...
Page 13
SecciónSección 1 Manual de instalación y operación Accesorios Limpieza y desinfección del interior del recipiente El interior del recipiente debe limpiarse y desinfectarse antes de K00499 Paleta de 48 pulg. su uso y debe limpiarse de manera periódica cuando esté en uso. K00503 Paleta de 60 pulg.
Page 14
Manual de instalación y operación SecciónSección 1 Lista de verificación antes de solicitar servicio de mantenimiento Si surge algún problema durante la operación de su recipiente de almacenamiento de hielo, siga la lista de verificación que se indica a continuación antes de llamar al servicio de mantenimiento. Los ajustes de rutina y procedimientos de mantenimiento no están cubiertos por la garantía.
Need help?
Do you have a question about the Manitowoc LB Manitowoc LB730 and is the answer not in the manual?
Questions and answers