Related Manuals for Acdeos AXS –FL
Summary of Contents for Acdeos AXS –FL
- Page 1 AXS – FL Step Condensed Manual A full size complete manual is available on www.acdeos.com ACDEOS BV Touwbaan 1A 2352 CZ Leiderdorp Netherlands WWW.ACDEOS.COM Date: March 2019 Rev.
-
Page 2: Technical Specifications
Technical specifications Product description Electrically operated step for mounting externally under the vehicle floor Installation Externally under the vehicle floor below the front, middle or rear door Dimensions Step depth 300 mm, Step width 600, 900 or 1000 mm depending on model Please refer to the installation drawings for detailed dimensions Weight... -
Page 3: Safety Instructions
13. Repair and maintenance must be done by qualified and trained staff only. 14. If any parts need replacing, ensure only original Acdeos Parts are used. 15. If the anti slip profile on the step becomes worn, the step platform must be replaced. -
Page 4: Mounting / Installation
/ chassis changes. Exact measurements of the product should be taken from the official installation drawings. Ask Acdeos for the last revision and official installation drawing. Figures, drawings in this manual are only for indication. - Page 5 Take the flexible mounting brackets supplied with the step. These brackets can be mounted in several ways. The brackets should be used to fix the rear side of the step to the bottom of the vehicle. It is recommended to find a strong point at the vehicle floor.
- Page 6 This fixing requires some technical knowledge and own interpretation. Adjust the step to be horizontal under the vehicle. Finally fit all bolts and nuts to mount the step completely. In the case the flange of the chassis is too far back, it is possible to flip the brackets as to place the step further forward.
-
Page 7: Electrical Installation
For safety reasons we recommend this signal is used. If you decide not to use this signal Acdeos cannot take any responsibility for any unsafe operation of the step. - Page 8 Mechanical Installation of door switch: Find the right place on the door to install the door 12.5mm switch, preferably around the area in the doorpost where you find the original door switch. Make sure there is minimum around 10-12 mm free space between the door and the door post when the door is closed.
- Page 9 4. When installing the switch using the nuts, the switch must stick out at least 12 mm because of the need for magnetic flow around the switch. 5. The distance between the end of the switch and the door should still be 7 mm. IMPORTANT: Max torque to fit the switch is 5 Nm (This is light hand tight) If you use higher torque, the switch will break / crack, which will lead to unreliable door signals.
-
Page 10: Operation
Operation Deploy Operation procedure The step must have clearance from the vehicle. The vehicle must have the parking brake on, and then the step can be safely operated. The electronics receive a signal from the door switch or driver switch. If a door switch is installed the step will move out automatically once the door is opened. -
Page 11: Manual Operation
At closing a signal from the close switch will indicate that the Step is completely closed. This close signal will also give the vehicle the OK that it is safe to drive the vehicle away, the Red LED light at the dashboard will go off. If the step is not stowed properly the RED LED keeps blinking. - Page 12 We strongly recommend MOTIP White PTFE grease part nr 090204 for all parts in the step, do not use WD40 or silicon sprays Other similar PTFE grease sprays can also be used. This spray is also available at Acdeos under part number S150 310...
- Page 13 Product AXS STEP Electrical Sliding step Type AXS FL 600 A AXS FL 900 A AXS FL 1000 A Production under responsibility of Company Acdeos BV Address Touwbaan 1A City 2352 CZ Leiderdorp Country Netherlands Website WWW.ACDEOS.COM Legal represented by Mr.
-
Page 14: Appendix 1; Electric Schedule
8 Appendix 1; electric schedule... -
Page 15: Appendix 2; Installation Drawings
9 Appendix 2; Installation drawings: AXS FL 600 / 900 / 1000 A... - Page 16 ACDEOS BV A Mobility Networks company Touwbaan 1A 2352 CZ Leiderdorp The Netherlands +31 71 5891819 Info@acdeos.com www ACDEOS.com...